Page 80 of 136
PRACTICAL INFORMATION
78 -
CHECKS
Oil filter
Change the fi lter regularly, in accordance
with the servicing schedule.
Only use products recom-
mended by PEUGEOT or
products of equivalent quality
and specifi cations.
To ensure best performance from
components as important as the
power steering and the braking sys-
tem, PEUGEOT selects and offers
quite specifi c products.
To prevent damage to the electrical
units, avoid washing the engine.
RUNNING OUT OF FUEL (DIESEL)
If you should run out of fuel, it is nec-
essary to re-prime the circuit:
- fi ll the fuel tank with at least fi ve
litres of diesel,
- squeeze and release the manual
re-priming pump, under the bonnet
under the protective cover, until fuel
appears in the transparent pipe,
- operate the starter until the engine
starts.
FUEL SUPPLY CUT-OFF(PETROL)
In a serious collision, a mechanism pre-
vents fuel from reaching the engine.
To re-establish the fuel supply, press
the switch on the corner of the front
right-hand suspension assembly, under
the bonnet.
Air filter and passenger
compartment filter
Have the fi lter elements replaced
regularly. If you drive in dusty condi-
tions, change them twice as often.
Brake pads
Brake pad wear depends on the style
of driving, in particular for vehicles
which are used in town, over short
distances.
It may be necessary to check the
thickness of the pads, even between
services.
Disc and drum wear status
For any information relating to checking
the disc and drum wear status, contact
a PEUGEOT dealer.
Manual gearbox
This does not require an oil change.
Check the level in accordance with the
manufacturer's servicing schedule.
To check the main levels and cer-
tain components, in accordance
with the manufacturer's servicing
schedule, refer to the pages of
the servicing booklet which corre-
spond to your vehicle's engine.
Handbrake
Where the handbrake travel is too
great or there is a reduction in the
performance of the system, the
handbrake should be adjusted, even
between services.
Have the system checked by a
PEUGEOT dealer.
Battery
At the start of winter, have your battery
checked by a PEUGEOT dealer.
Page 93 of 136
91 PRACTICAL INFORMATION
-
Fuse N°
Rating
Functions
1
10A
Pre-heater unit (Diesel) - Brake and clutch
switches - Reversing lamps.
2
15A
Fuel pump.
3
10A
ABS control unit.
4
10A
Engine control unit.
5
-
Not used.
6
15A
Front foglamps.
7
20A
Headlamp wash pump.
8
20A
Fan assembly relay - Engine control unit.
9
15A
Left-hand dipped beam.
10
15A
Right-hand dipped beam.
11
10A
Left-hand main beam.
12
10A
Right-hand main beam.
13
15A
Horn.
14
10A
Front and rear screen wash pumps.
15
30A
Oxygen sensor - Air fl ow sensor.
16
30A
Air pump relay.
17
30A
Front windscreen wiper.
18
40A
Air conditioning fan.
Engine compartment fusebox
To gain access to the box in the en-
gine compartment (next to the bat-
tery), unclip the cover.
After carrying out work, close the
cover carefully to ensure its sealing.
Page 104 of 136
102 -
PETROL ENGINES AND GEARBOXES
Model codes
GA/GB/GC/GD/GF/GG/GJ...
...KFWC
GA/GJ/GK/GN...
...NFUC
ENGINES
1.4 litre
1.6 litre
Cubic capacity (cc)
1 360
1 587
Bore x stroke (mm)
75 x 77
78.5 x 82
EU standard maximum power (kW)
55
80
Maximum power at engine speed (rpm)
5 500
5 800
EU standard maximum torque (Nm)
120
147
Maximum torque at engine speed (rpm)
3 400
4 000
Fuel
Ron 95 - Ron 98
Ron 95 - Ron 98
Catalytic converter
Yes
Yes
Gearbox
Manual (5 speed)
Manual (5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement)
3 (1) - 3.25 (2)
3.2 (1) - 3.4 (2)
(1) Draining by gravity - (2) Draining by suction
Page 105 of 136
103 TECHNICAL DATA
-
Model codes
GA/GB/GC/GD/GF/GG/
GJ/GK/GN...
...9HWC
GA/GB/GC/GD/GF/GG/
GJ/GK/GN ...
... 9HXC
GA/GB/GC/GD/GF/GG/
GJ/GK/GN...
... WJYB
ENGINES
1.6 litre Turbo HDI 75
1.6 litre Turbo HDI 90
1.9 litre
Cubic capacity (cc)
1 560
1 560
1 867
Bore x stroke (mm)
75 x 88.3
75 x 88.3
82.2 x 88
EU standard maximum power (kW)
55
66
51
Maximum power at engine speed (rpm)
4 000
4 000
4 600
EU standard maximum torque (Nm)
175
215
125
Maximum torque at engine speed (rpm)
1 750
1 750
2 500
Fuel
Diesel
Diesel
Diesel
Catalytic converter
Yes
Ye s
Yes
Gearbox
Manual (5 speed)
Manual (5 speed)
Manual (5 speed)
Oil capacity (in litres)
Engine (with cartridge replacement)
3.75
3.8
4.8
DIESEL ENGINES AND GEARBOXES
Page 106 of 136
TECHNICAL DATA
104 -
Quality of the fuel used for petrol engines
Quality of the fuel used for Diesel engines
The petrol engines are perfectly compatible with E10 type petrol biofuels (containing 10 % ethanol), conforming to European
standards EN 228 and EN 15376.
E85 type fuels (containing up to 85 % ethanol) are reserved exclusively for vehicles marketed for the use of this type of fuel
(BioFlex vehicles). The quality of the ethanol must comply with European standard EN 15293.
For Brazil only, special vehicles are marketed to run on fuels containing up to 100 % ethanol (E100 type).
The Diesel engines are perfectly compatible with biofuels which conform to current and future European standards (Diesel
fuel which complies with standard EN 590 mixed with a biofuel which complies with standard EN 14214) available at the
pumps (containing up to 7 % Fatty Acid Methyl Ester).
The B30 biofuel can be used in certain Diesel engines; however, this use is subject to strict application of the special servicing
conditions. Contact a PEUGEOT dealer or a qualifi ed workshop.
The use of any other type of (bio)fuel (vegetable or animal oils, pure or diluted, domestic fuel...) is strictly prohibited (risk of
damage to the engine and fuel system).
Page 123 of 136
121
06 SCREEN MENU MAP
RADIO-CD
MAIN FUNCTION
*
The parameters vary according to vehicle.
CHOICE A
CHOICE B...
MONOCHROME A
Choice A1
Choice A2
REG MODE
CD REPEAT
RANDOM PLAY
VEHICLE CONFIG *
REV WIPE ACT
OPTIONS
GUIDE LAMPS
DIAGNO
STICS
RDS SEARCHCONSUL
T
ABANDON
UNITS
TEMPERATURE: °CELSIUS/°FAHRENHEIT
FUEL CONSUMPTION:
KM/L - L/100 - MPG
1
2
3
31
2
2
2
2
1
2
3
2
3
1
2
2
1
2
2
Page 127 of 136
125 VISUAL INDEX-
EXTERIOR
Accessories ............................... 97 Key, starting, battery ......... 6, 46-47
Central locking ............... 46, 49, 50
Rear lamp .................................. 86
3rd brake lamp........................... 87
Spare wheel, jack,
changing, fi tting .................. 79-80
Infl ating .................................... 112
ABS, EBFD, Brakes....... 64, 74, 78
Tyres, pressures ................ 80, 112
Pads, discs, drums .................... 78
Fuel tank .................. 16, 20, 53, 78 Door mirrors ............................... 57
Snow screen .............................. 94
Front lamps..................... 54, 82-85
Foglamps ............................. 54, 86
Direction indicators ..... 54, 82, 85-86
Headlamp adjustment................ 60
Changing bulbs..................... 82-87
Opening/closing
the doors .................. 6, 46, 49-52
Opening the bonnet ............. 16, 53
Side door child lock ................... 51
Locks ..................................... 6, 46 Towbar ....................................... 96
Lifting, towing............................. 95
Page 131 of 136
129 VISUAL INDEX-
TECHNICAL DATA - MAINTENANCE
Levels ............................. 72-75, 77
- oil dipstick,
- power steering fl uid,
- brake fl uid,
- coolant.
Petrol supply cut-off,
Diesel fuel priming ................... 78
Screenwash/headlamp wash,
fi lling reservoir .................. 55, 77
Bulbs, changing bulbs
- front ................................... 82-85
- rear ................................... 86-87 Dimensions ......................... 98-101
Engine technical data ....... 102-103
Weights, loads .................. 106-111
Identifi cation markings ............. 112
Opening the bonnet, stay ...... 16, 53
Under bonnet engine views ...... 72-75 Air/oil fi lters, checks ........ 72-75, 78
Engine fuses .............................. 91
Battery ................................. 78, 92
