2011 FORD KUGA headlamp

C394
TO ELECTRONIC GROUND (no longer used)BATTERY BACKED SOUNDER: STATUS
RAIN SENSORTO SUNROOF
AMBIENT TEMP SENSOR INTRUSION SENSOR
CRUISE CONTROL SW
ELECTRONIC GROUND SUPPLY ROOF
TO ELECTRONIC GROUND
RENT DEVICE
MINI LIFTGATE FEATURE WILL BE ADDED FOR C394 BOXES ONLY
FROM MINI LIFTGATE REL. SW. EXT. FROM MINI LIFTGATE AJAR SW
NOTES
1 WHERE PINS, FUSES AND RELAYS ARE SHOWN AS SPARE OR PROTECTED THESE NEED
2 SPARE CAPACITY SHOULD NOT BE TAKEN INTO ACCOUNT FOR COSTING
3 THE PJB NEEDS TO BE TESTED WITH MAXIMUM FUNCTIONALITYTO BE POPULATED DURING PROTOTYPE PHASE AND REMOVED FOR PRODUCTION -
THE TRACKS IN THE PCB WILL REMAIN FOR FUTURE USE
3M5T-14489-AR*
3M5T-14A073-B*
32 WAY
C95 GREEN
WHITE
LOW BLUE BROWN BROWN BLACK GREEN
FLOOR - 1 ROOF - 1 32 WAY
C96
46 WAY
C100
C102 C99 41 WAY
46 WAY
FLOOR - 2
COCKPIT - 1 C98 14 WAY
C103
CONNECTOR DETAILS
COCKPIT - 2
BOX NUMBER32 WAY
BLUE
3M5T-14489-AP* 3M5T-14489-ZX* 3M5T-14489-ZV* 3M5T-14489-BP* 98AG-14489-TM* 3M5T-14489-ZR*
FRONT - 2
FRONT - 1
3M5T-14489-AR*TT
3M5T-14A073-B*TT
32WAWWYAAC95GREEN
WHITELOW
BLUE
BROWNBROWN
BLACK
GREEN
FLOOR-1
ROOF-1
32WAWWYAA
C96
46WAWWYAA
C100
C102
C99
41WAWWYAA
46WAWWYAAFLOOR-2
COCKPIT-1
C9814WAWWYAA
C103COCKPIT-2
BOXOONUMBER
32WAWWYAABLUE3M5T-14489-AP*TT3M5T-14489-ZX*TT
3M5T-14489-ZV*TT3M5T-14489-BP*TT
98AG-14489-TM*
3M5T-14489-ZR*TTFRONT-2FRONT-1
THE DOTTED INPUTS / OUTPUTS ARE POPULATED DURING DEVOLOPMENT PHASE
AND MUST BE DEPOPULATED FOR J#1
TO WASHER PUMP FRONT
TO WASHER PUMP REAR
FROM STALK SWITCH FROM WIPER / WASHER SWITCH FROM WIPER / WASHER SWITCH
FROM STALK SWITCH
FROM HANDBRAKE SW
FROM BRAKE FLUID LEVEL SWITCH
RADIO FROM INTRUSION SENSOR
TO IP
TO IP
TO CABIN
TO CABIN
FROM LIGHT SWITCH
FROM AMBIENT TEMP SENSOR
FROM CRUISE SW
TO RKE MODULE FROM AC SWITCH
TO KVM MODULE
NOTE:
C102C102C96C103C103C103C96C96C103C98
GND MICROC CONTROL RTNIS GNDAMB TEMP SENS GNDMS CAN -MS CAN +VEHICLE SPEEDRAIN SENSORBATTERY BACKUP SOUNDER
RADIO ANTITHEFT
BRAKE FLUID LEVEL SW
PARK BRAKEHIGH BEAM SWFLASH SW
FRONT WASHER SWITCH
REAR WASHER SW
IS SENSE
AMBIENT TEMP SENSORC CONTROL+-RESRKE SERIAL DATA
HEADLAMP LOW BEAM SW
AUX HEATER REQUEST/HSCOV_FAP
TAILGATE IN TAILGATE AJAR SWTAILGATE INTAILGATE SW EXTERNAL
02
C98C95C98C99C99C98C95C103C98C102C103C103
C102C103C98C95C103C99
C96
C99C99
ntral Junction Box (CJB)
700-01-7 Power Distribution - Central Junction Box (CJB)
2011.0 Kuga (G1226099)
BACK TO CHAPTER INDEXTO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

TO
TO RIGHT HEADLAMP(LEV. MOTOR) C837
TO LEFT HEADLAMP(LEV. MOTOR) C836
.0.0
TO CIGAR LIGHTER.TO REAR CONSOLE POWER POINT 0.0
GROAIR G39
C155
52.5
WA
BK
31-HA231-HA6 BK WA 2.5
C158 12.5
WA
BK
31-HA30S16WA
BK
31-HA21C9122.5
WA
BK
31-HA61
C609
GROGGROGGGROBAG
700-03-4 A-Pillar RH Ground Point
2011.0 Kuga (G1246659)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

TO COOLING FAN MODULE
.TO HOOD SWITCH
C897
TO LEFT HEADLAMP
TO LEFT FRONT FOG LAMP
TO LEFT SIDE TURN SIGNAL LAMP (C214 ONLY)
.BRAKE FLUID LEVEL SW.
C810.TO DUAL PRESSURE SW.
C882.TO DUAL PRESSURE SW.
C882
.TO BRAKE PRESSURE SWITCH
C446
TO RIGHT FRONT FOG LAMP
TO HORN
TO DIESEL FUEL HEATER RELAY
.R9 TO HEADLAMP CLEANING REL.
.WATER IN FUEL
C778
.C945 TO FUEL FILTER HEATER
.TO AC CLUTCH
C957
.TO PCM
C419
.TO PCM
C419
.TO PCM
C419
.TO PCM
C417
.TO PCM
C418
.TO PCM
C418
TO LEFT HID LAMP
.TO IGNITION 2 & PARK LIGHT RELAY
EJB.TO A/C COMPRESSOR CYCLING SWITCH
C692
.C79 TO LOW WASHER WATER LEVEL SWITCH.BRAKE FLUID LEVEL SW.
C810
91-GL7 BK WA 0.501
131
0.50
WA
BK-BU
91-GC70.50
WA
BK-BU
91-PA1391-FA38 BK-OG WA 0.50
S1180.50
WA
BK-OG
91-GC891-DA3 BK-OG WA 1.0
10.50
WA
BK-GN
91-TA36
31-KA21B BK WA 4.0R9_4
91-RE8K BK-YE WK 0.7591-RE8L BK-YE WK 1.01.0WK
BK-YE
91-RE8MG4H4K2H4J4K4
0.75WK
BK-YE
91-RE8H0.75WK
BK-YE
91-RE8G
91-RE8J BK-YE WK 0.75
0.50WK
BK-OG
91-RJ322
2.5WK
BK-BU
91-RN2G57B
LEFT FRONT
GROUNDS53
31-FA6 BK WK 1.0
31-PE8B BK WK 0.75
GROUND LEFT FRONT
G57A
2C945
1
3
GROUND ELECTRONIC LEFT FRONT
G31A
91-DA3A BK-OG WA 1.5
91-FA17A BK-RD WA 0.501
R4_20.50
WA
BK-GN
91-BB18
1.0
WA
BK-BU
91-GC7B1
GROUNDGGROUNDGGGROUNDFENDER 2
GROUNDGGROUNDGGGROUNDFENDER 2
ELECTRONICEELECTRONICEEELECTRONICFENDER
700-03-17 Engine Compartment Ground Point LH
2011.0 Kuga (G1246665)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

.TO RIGHT HEADLAMP C837
.
00.0TO EHPAS MODULE
.
TO RIGHT FRONT WINDOW WASHER JET C720
.
TO LEFT FRONT WINDOW WASHER JET C721
.C791
TO BAT. BACKUP SOUNDER.TO HEDLAMP WASHER PUMP C745.C307
TO FUEL FIRED HEATER MODULE
.TO FRONT WIPER MOTOR C848
.C837
TO RIGHT HID LAMP
suffix B* suffix A* EMC GROUN
LHD
EMC GROUN 18C942
EMC GROUN18C942
RHD
suffix F*18C942
1
C340.75
WA
BK
31-HB1S1220.75
WA
BK
31-HB13
0.75
WA
BK
31-HB26
2
2
C79
91-DA7 BK
G74
BODY
GROUND
C79
31-FC9 BK WA
G
R
BRG5C8781
31-KA9A
31-KA9S111
4
91-DA7A BK
G74
BODY
GROUND
31-KA9B BK WA 2.5
GROUND BODY G74
BK
91-DA7B
1
C878
GR
BRG58
WABK
31-FC9A
31-KA9C
GROUNDGGROUNDGGGROUNDEMC
GRGGRGGGRSU
GROUNDGGROUNDGGGROUNDEMC
GROUNDGGROUNDGGGROUNDEMC
GRGGRGGGRSU
700-03-18 Engine Compartment Ground Point RH
2011.0 Kuga (G1246666)
BACK TO CHAPTER INDEX
TO MODEL INDEXFORD KUGA 2011.0MY WIRING DIAGRAMS

- DW, Vehicles With: 6-Speed
Manual Transaxle - MMT6,
Emission Requirements: Stage
V...................................................700-00
Engine Upper View—2.0L Duratorq-TDCi (100kW/136PS)
- DW/2.0L Duratorq-TDCi
(103kW/140PS) - DW/2.0L
Duratorq-TDCi (120kW/163PS)
- DW, Vehicles With: 6-Speed
Automatic Transaxle -
6DCT450, Emission
Requirements: Stage V
AWD............................................. 700-00
Evaporative Emission Canister Purge Valve..................................303-13
Exhaust Camshaft Position (CMP) Sensor............................303-14A
Exhaust Gas Recirculation (EGR) Cooler Bypass
Valve—A.................................... 303-08B
Exhaust Gas Recirculation (EGR) Cooler Bypass Valve Position
Sensor—C................................. 303-08B
Exhaust Gas Recirculation (EGR) Vacuum Regulator
Valve.......................................... 303-08B
Exhaust Gas Recirculation (EGR) Valve—B.................................... 303-08B
Exhaust Gas Recirculation (EGR) Valve Position
Sensor....................................... 303-08B
Exhaust Gas Temperature Sensor....................................... 303-14B
Exhaust Gas Temperature Sensor....................................... 303-14B
Exhaust Variable Valve Timing (VVT) Oil Control
Solenoid ..................................... 303-14A
Exterior Lighting—Vehicles Without: Adaptive Front
Lighting/High Intensity
Discharge
Headlamps ................................... 417-01
Exterior Lighting—Vehicles With: Adaptive Front Lighting,
Vehicles Without: High
Intensity Discharge
Headlamps ................................... 417-01Exterior Lighting—Vehicles With:
Adaptive Front Lighting/High
Intensity Discharge
Headlamps ................................... 417-01
Exterior Mirror Control Switch ...........................................501-09
Exterior Mirror Control Switch ...........................................501-09
Exterior Mirror LH............................501-09
Exterior Mirror RH............................501-09
Fog Lamps.......................................417-01
Footwell Air Discharge Temperature Sensor.....................412-01
Footwell Air Discharge Temperature Sensor.....................412-01
Footwell Lamp LH............................417-02
Footwell Lamp RH...........................417-02
Footwell Vent/Duct Blend Door Actuator ........................................ 412-01
Four-Wheel Drive (4WD) Control Module ......................................... 308-07
Front Bumper—2.5L Duratec (147kW/200PS) - VI5, LHD
4WD............................................. 700-00
Front Bumper—2.5L Duratec (147kW/200PS) - VI5, RHD
4WD............................................. 700-00
Front Bumper—2.0L Duratorq-TDCi (100kW/136PS)
- DW, LHD 4WD/LHD
FWD............................................. 700-00
Front Bumper—2.0L Duratorq-TDCi (100kW/136PS)
- DW/2.0L Duratorq-TDCi
(103kW/140PS) - DW/2.0L
Duratorq-TDCi (120kW/163PS)
- DW, LHD 4WD/LHD FWD,
Emission Requirements: Stage
V................................................... 700-00
Front Bumper—2.0L Duratorq-TDCi (100kW/136PS)
- DW, RHD 4WD/RHD
FWD............................................. 700-00
Front Bumper—2.0L Duratorq-TDCi (100kW/136PS)
- DW/2.0L Duratorq-TDCi
(103kW/140PS) - DW/2.0L
Duratorq-TDCi (120kW/163PS)
- DW, RHD 4WD/RHD FWD,
Emission Requirements: Stage
V................................................... 700-00
2011.0 Kuga
Index
BACK TO CHAPTER INDEX TO MODEL INDEX
PAGE 8 OF 16
FORD KUGA 2011.0MY WIRING DIAGRAMS

Fuel Rail TemperatureSensor....................................... 303-14B
Fuel Rail Temperature Sensor—A................................. 303-14C
Fuel Vaporizer System Fuel Pump—A ...................................... 309-00
Fuel Vaporizer System Glow Plug—A........................................ 309-00
Generator .........................................414-02
Generator .........................................414-02
Generator .........................................414-02
Glove Compartment Lamp............................................ 417-02
Glow Plug 1...................................303-07B
Glow Plug 2...................................303-07B
Glow Plug 3...................................303-07B
Glow Plug 4...................................303-07B
Glow Plug Module.........................303-07B
Glow Plug Relay............................303-07B
Headlamp Assembly LH..................417-01
Headlamp Assembly RH................................................ 417-01
Headlamp Control Module ......................................... 417-01
Headlamp High Beam Relay ............................................ 417-01
Headlamp Leveling Front Sensor .......................................... 417-01
Headlamp Leveling Rear Sensor .......................................... 417-01
Headlamp Low Beam Relay ............................................ 417-01
Headlamp Switch.............................417-01
Headlamp Washer...........................501-16
Headlamp Washer...........................501-16
Headlamp Washer Pump ............................................ 501-16
Headlamp Washer Pump Relay ............................................ 501-16
Headliner—LHD 4WD/LHD FWD............................................. 700-00
Headliner—RHD 4WD/RHD FWD............................................. 700-00
Heated Oxygen Sensor (HO2S) .......................................303-14A
Heated Oxygen Sensor (HO2S)...................................... 303-14C
Heated Rear Window Element........................................ 501-11
Heated Rear Window Element........................................ 501-11Heated Rear Window
Switch ........................................... 501-11
Heated Seats—LHD 4WD/LHD FWD............................................. 501-10
Heated Seats—RHD 4WD/RHD FWD............................................. 501-10
Heated Windshield Element........................................ 501-11
Heated Windshield Relay ............................................ 501-11
Heated Windshield Switch and Heated Rear Window Switch
Assembly ...................................... 501-11
Heated Windshield, Rear Window, Exterior Mirrors and
Washer Jets—Vehicles
Without: Door Module...................501-11
Heated Windshield, Rear Window, Exterior Mirrors and
Washer Jets—Vehicles
Without: Door Module...................501-11
Heated Windshield, Rear Window, Exterior Mirrors and
Washer Jets—Vehicles With:
Door Module.................................501-11
Heated Windshield, Rear Window, Exterior Mirrors and
Washer Jets—Vehicles With:
Door Module.................................501-11
Heater Core Housing Left-Hand View—LHD 4WD/LHD FWD,
V

ehicles With: Air
Conditioning/Automatic
Temperature Control....................700-00
Heater Core Housing Left-Hand View—LHD 4WD/LHD FWD,
Vehicles With: Air
Conditioning/Manual
Temperature Control....................700-00
Heater Core Housing Left-Hand View—RHD 4WD/RHD FWD,
Vehicles With: Air
Conditioning/Automatic
Temperature Control....................700-00
Heater Core Housing Left-Hand View—RHD 4WD/RHD FWD,
Vehicles With: Air
Conditioning/Manual
Temperature Control....................700-00
2011.0 Kuga
Index
BACK TO CHAPTER INDEX TO MODEL INDEX
PAGE 10 OF 16
FORD KUGA 2011.0MY WIRING DIAGRAMS