2011 FORD FUSION HYBRID fuel cap

EXCEPTIONS
In addition, there are several exceptions to the Normal Schedule. They
are listed below:
Normal vehicle axle maintenance
❑Rear axles and power take-off (PTO) units containing synthetic fluid and light duty trucks equipped with Ford-design axles
are lubricated for life. These fluids are not to be checked or changed unless a leak is suspected, service is required or the
axle assembly has been submerged in water. The axle and PTO fluids should be changed anytime the axle and PTO have
been submerged in water. During extended trailer tow operation above 70°F (21°C) ambient and wide open throttle for
extended periods above 45 mph (72 km/h), non-synthetic rear axle fluids should be changed every 3,000 miles
(4,800 km) or three months, whichever occurs first. The 3,000 mile (4,800 km) fluid change interval may be waived if
the axle was filled with 75W140 synthetic gear fluid meeting Ford specification WSL-M2C192-A, part number F1TZ-19580-B
or equivalent. Add friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear axles (refer to
Maintenance product specifications and capacitiesin theMaintenance and Specificationschapter for details). The axle fluid
should be changed anytime an axle has been submerged in water.
Police/Taxi/Livery vehicle axle maintenance
❑Change rear axle fluid every 100,000 miles (160,000 km). Rear axle fluid change may be waived if the axle was filled
with 75W140 synthetic gear fluid meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Add
four ounces (118 mL) of friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear axles.
The axle fluid should be changed anytime the axle has been submerged in water.
California fuel filter replacement
❑If the vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this
maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful
life. Ford Motor Company, however, urges you to have all recommended maintenance services performed at the specified
intervals and to record all vehicle service.
Middle East hot climate specifications
❑If operating conditions are normal and you drive your vehicle under typical, everyday conditionsandyou are using an API
performance category oil of SL or later (for example SM, etc.) then you can follow the 7,500 mile (12,000 km) normal
service oil change intervals schedule. Vehicles operating in the Middle East, North Africa, Sub-Saharan Africa or locations with
similar climates must follow the oil change interval of 3,000 mile (4,800 km) if the owner is using oils defined by the
American Petroleum Institute (API) performance category of API SK or earlier (for example SJ, etc.).
❑Edge/MKX AWD only– vehicles operating off-road in sand during high ambient temperatures must replace the AWD
PTU (All-wheel drive Power Transfer Unit) lube every 20,000 miles (32,000 km).
Scheduled Maintenance
337
2011 Fusion Hybrid(hfv)
Owners Guide, 2nd Printing
USA(fus)

Cell phone use ............................15
Changing a tire .........................254
Child safety seats ......................176
attaching with tether straps ..183
in front seat ............................177
in rear seat ..............................177
LATCH .....................................180
recommendations ...................174
Child safety seats - booster
seats ...........................................185
Cleaning your vehicle
engine compartment ..............275
instrument panel ....................277
interior .....................................278
plastic parts ............................276
washing ....................................274
waxing .....................................274
wheels ......................................275
wiper blades ............................276
Climate control (see Air
conditioning or Heating) ......68, 71
Clock ............................................51
Compass, electronic ....................90
calibration .................................91
set zone adjustment .................90
Console ........................................92
overhead ....................................89
Controls
power seat ...............................136
steering column ......................100
Coolant
checking and adding ......290–291
refill capacities ................294, 311
specifications ..........................311
Cross Traffic Alert ....................237
Cruise control
(see Speed control) ....................98
Cupholder(s) .............................141Customer Assistance ................244
Ford Extended Service
Plan ..................................318, 321
Getting assistance outside
the U.S. and Canada ..............270
Getting roadside assistance ...244
Getting the service you
need .........................................266
Ordering additional owner’s
literature .................................272
Utilizing the
Mediation/Arbitration
Program ...................................270
D
Daytime running lamps
(see Lamps) ................................79
Defrost
windshield .................................71
Dipstick
automatic transmission
fluid ..........................................307
engine oil .................................286
Driving under special
conditions ..................................232
through water .........................243
E
Electronic message center .........36
Emergencies, roadside
jump-starting ..........................261
running out of fuel .........260, 300
Emission control system ..........304
Engine ........................................313
cleaning ...................................275
idle speed control ...................288
lubrication specifications .......311
refill capacities ........................311
Index
341
2011 Fusion Hybrid(hfv)
Owners Guide, 2nd Printing
USA(fus)

service points ..................284–285
Engine block heater .................220
Engine oil ..................................286
checking and adding ..............286
dipstick ....................................286
filter, specifications ........287, 310
recommendations ...................287
refill capacities ........................311
specifications ..........................311
Event data recording ..................13
Exhaust fumes ..........................220
F
Fleet MyKey programming ......110
Floor mats .................................109
Fluid capacities .........................311
Fog lamps ....................................78
Fuel ............................................295
calculating fuel
economy ............................38, 301
cap ...........................................297
capacity ...................................311
choosing the right fuel ...........298
detergent in fuel .....................299
filler funnel .............................300
filling your vehicle
with fuel ..................295, 297, 301
filter, specifications ........295, 310
fuel pump shut-off ..................245
improving fuel economy ........301
octane rating ...................299, 313
quality ......................................299
running out of fuel .........260, 300
safety information relating
to automotive fuels ................295
Fuses ..................................246, 248G
Garage door opener ..................102
Gas cap (see Fuel cap) ............297
Gas mileage
(see Fuel economy) .................301
Gauges .........................................25
H
Hazard flashers .........................245
Headlamps ...................................77
aiming ........................................80
autolamp system .......................77
bulb specifications ....................83
daytime running lights .............79
flash to pass ..............................79
high beam .................................78
replacing bulbs .........................84
turning on and off ....................77
Heating
heating and air conditioning
system .................................68, 71
Hood ..........................................283
I
Ignition ...............................217, 313
Illuminated visor mirror .............89
Infant seats
(see Safety seats) .....................176
Inspection/maintenance (I/M)
testing ........................................305
Instrument panel ........................92
cleaning ...................................277
cluster ........................................18
lighting up panel and
interior .......................................79
Index
342
2011 Fusion Hybrid(hfv)
Owners Guide, 2nd Printing
USA(fus)