2011 FORD E SERIES ignition

If the service engine soonindicator remains on, have your vehicle
serviced at the first available opportunity. Although some malfunctions
detected by the OBD-II may not have symptoms that are apparent,
continued driving with the service engine soon
indicator on can
result in increased emissions, lower fuel economy, reduced engine and
transmission smoothness, and lead to more costly repairs.
Readiness for Inspection/Maintenance (I/M) testing
Some state/provincial and local governments may have
Inspection/Maintenance (I/M) programs to inspect the emission control
equipment on your vehicle. Failure to pass this inspection could prevent
you from getting a vehicle registration. Your vehicle may not pass the I/M
test if the service engine soon
indicator is on or not working
properly (bulb is burned out), or if the OBD-II system has determined
that some of the emission control systems have not been properly
checked. In this case, the vehicle is considered not ready for I/M testing.
If the service engine soon
indicator is on or the bulb does not
work, the vehicle may need to be serviced. Refer toOn-board
diagnostics (OBD-II)in this chapter.
If the vehicle’s engine or transmission has just been serviced, or the
battery has recently run down or been replaced, the OBD-II system may
indicate that the vehicle is not ready for I/M testing. To determine if the
vehicle is ready for I/M testing, turn the ignition key to the on position
for 15 seconds without cranking the engine. If the service engine
soon
indicator blinks eight times, it means that the vehicle is not
ready for I/M testing; if the service engine soon
indicator stays on
solid, it means that the vehicle is ready for I/M testing.
The OBD-II system is designed to check the emission control system
during normal driving. A complete check may take several days. If the
vehicle is not ready for I/M testing, the following driving cycle consisting
of mixed city and highway driving may be performed:
15 minutes of steady driving on an expressway/highway followed by
20 minutes of stop-and-go driving with at least four 30-second idle
periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete. If
the vehicle is still not ready for I/M testing, the above driving cycle will
have to be repeated.
Maintenance and Specifications
281
2011 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)

ENGINE DATA
Engine 4.6L V8 engine 5.4L V8 engine 6.8L V10 engine
Cubic inches 281 330 415
Required fuel87 octane or
E85
187 octane or
E85187 octane
Firing order 1-3-7-2-6-5-4-8 1-3-7-2-6-5-4-8 1-6-5-10-2-7-3-8-4-9
Ignition system Coil on plug Coil on plug Coil on plug
Spark plug gap0.041–0.047 inch
(1.04–1.20mm)0.051–0.057 inch
(1.29–1.45mm)0.051–0.057 inch
(1.29–1.45mm)
Compression
ratio9.38:1 9.0:1 9.0:1
14.6L V8 and 5.4L V8 FFV engines only.
Engine drivebelt routing
•4.6L V8, 5.4L V8 and 6.8L V10 engines without A/C
•4.6L V8, 5.4L V8 and 6.8L V10 engines with A/C
Maintenance and Specifications
301
2011 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)

Exhaust fumes ..........................184
F
Fail safe cooling ........................267
Flexible Fuel Vehicle (FFV) ....269
Floor mats .............................71–72
Fluid capacities .........................294
Four-Wheel Drive vehicles
preparing to drive your
vehicle .....................................194
Fuel ............................................269
calculating fuel
economy ............................22, 276
cap ...........................................272
capacity ...................................294
choosing the right fuel ...........274
detergent in fuel .....................274
filling your vehicle
with fuel ..................269, 272, 276
filter, specifications ........269, 293
fuel pump shut-off switch .....212
improving fuel economy ........276
octane rating ...................274, 301
quality ......................................275
running out of fuel .................275
safety information relating to
automotive fuels .....................269
Fuel - flex fuel vehicle
(FFV) .................................269, 274
Fuses ..................................214–215
G
Gas cap (see Fuel cap) ............272
Gas mileage (see Fuel
economy) ...................................276
Gauges .........................................19
H
Hazard flashers .........................212Head restraints ...........................85
Headlamps ...................................50
aiming ........................................53
bulb specifications ....................56
daytime running lights .............50
flash to pass ..............................51
high beam .................................50
replacing bulbs .........................57
turning on and off ....................50
Heating
heater only system .............47, 49
heating and air conditioning
system .......................................48
Hood ..........................................255
I
Ignition ...............................181, 301
Illuminated visor mirror .............63
Infant seats
(see Safety seats) .....................117
Inspection/maintenance (I/M)
testing ........................................281
Instrument panel
cleaning ...................................249
cluster ........................................14
lighting up panel and
interior .......................................51
J
Jack ............................................222
positioning ...............................222
storage .....................................222
Jump-starting your vehicle ......232
K
Keyless entry system
autolock .....................................72
Index
334
2011 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)

Keys .............................................83
positions of the ignition .........181
L
Lamps
bulb replacement
specifications chart ..................56
daytime running light ...............50
headlamps .................................50
headlamps, flash to pass ..........51
instrument panel, dimming .....51
interior lamps ...........................54
replacing bulbs .........................57
LATCH anchors .........................121
Lights, warning and indicator ....14
anti-lock brakes (ABS) ..........187
Load limits .................................163
Loading instructions .................170
Locks
autolock .....................................72
doors ..........................................72
Lubricant specifications ...........294
Lug nuts ....................................231
Lumbar support, seats ...............87
M
Message center ...........................21
english/metric button ...............26
warning messages .....................26
Mirrors .........................................65
automatic dimming rearview
mirror ........................................65
fold away ...................................67
side view mirrors (power) .......65
Motorcraftparts ..............253, 293
N
Navigation system .......................46O
Octane rating ............................274
Oil (see Engine oil) ..................258
P
Parking brake ............................187
Parts (see Motorcraft
parts) .........................................293
Power distribution box (see
Fuses) ........................................218
Power door locks ........................72
Power mirrors .............................65
Power point .................................63
Power steering ..........................193
fluid, checking and adding ....282
fluid, refill capacity ................294
fluid, specifications .................294
Power Windows ...........................64
Preparing to drive your
vehicle ........................................194
R
Radio ......................................29, 31
Rear-view camera system .........206
Recommendations for
attaching safety restraints for
children ......................................115
Relays ........................................214
Remote entry system .................77
illuminated entry ......................81
locking/unlocking doors ..........72,
78–79
panic alarm ...............................79
replacement/additional
transmitters ...............................80
Index
335
2011 Econoline(eco)
Owners Guide, 1st Printing
USA(fus)