2011 FIAT FREEMONT radiator cap

WARNING!
You or others can be badly burned by hot
engine coolant (antifreeze) or steam
from your radiator. If you see or hear steam
coming from under the hood, do not open the
hood until the radiator has had time to cool.
Never try to open a cooling system pressure cap
when the radiator or coolant bottle is hot .
TOWING A DISABLED VEHICLETowing Condition Wheels OFF The Ground MANUAL TRANSMISSION
Flat Tow NONE • Trans in NEUTRAL
• Ignition key in ACC
Wheel Lift Or Dolly Tow Rear
NO
Front OK
Flatbed ALL BEST METHOD
Proper towing or lifting equipment is required to pre-
vent damage to your vehicle. Use only tow bars and
other equipment designed for the purpose, following
equipment manufacturer’s instructions. Use of safety
chains is mandatory. Attach a tow bar or other towing
device to main structural members of the vehicle, not
to bumpers or associated brackets. State and local laws
applying to vehicles under tow must be observed. If you must use the accessories (wipers, defrosters,
etc.) while being towed, the ignition must be in the
ON/RUN position, not the ACC position.
213
KNOWING
YOURVEHICLE SAFETY
STARTING ANDDRIVING
WARNING
LIGHTS AND
MESSAGESIN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Rear Wiper Removal/Installation – If Equipped
1. Lift the pivot cap on the rear wiper arm upward, thiswill allow the rear wiper blade to be raised off of the
liftgate glass. (fig. 168)
NOTE: The rear wiper arm cannot be raised fully
upward unless the pivot cap is raised first.
2. Lift the rear wiper arm upward to raise the wiper blade off of the liftgate glass.
3. Grab the bottom of the wiper blade and rotate it forward to unsnap the blade pivot pin from the
wiper blade holder. (fig. 169)
4. Install the wiper blade pivot pin into the wiper blade holder at the end of the wiper arm, and firmly press
the wiper blade until it snaps into place.
5. Lower the wiper blade and snap the pivot cap into place. ADDING WASHER FLUID
The windshield washer and the rear window washer
share the same fluid reservoir. The fluid reservoir is
located in the engine compartment. Be sure to check
the fluid level in the reservoir at regular intervals. Fill
the reservoir with windshield washer solvent (not
radiator antifreeze) and operate the system for a few
seconds to flush out the residual water.
When refilling the washer fluid reservoir, apply some
washer fluid to a cloth or towel and wipe the wiper
blades clean. This will help blade performance.
To prevent freeze-up of your windshield washer system
in cold weather, select a solution or mixture that meets
or exceeds the temperature range of your climate. This(fig. 168)
1 — Wiper Arm
2 — Pivot Cap
(fig. 169)1 — Wiper Blade
2 — Blade Pivot Pin
3 — Wiper Arm
4 — Wiper Blade Holder
224
KNOWING
YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

To minimize the possibility of catalyst damage:
• Do not shut OFF the engine or interrupt the ignitionwhen the transmission is in gear and the vehicle is in motion.
• Do not try to start the engine by pushing or towing the vehicle.
• Do not idle the engine with any ignition coil connec- tors disconnected for prolonged periods.
COOLING SYSTEM
WARNING!
 When working near the radiator cool-
ing fan, disconnect the fan motor lead or
turn the ignition switch to the LOCK position.The
fan is temperature controlled and can start at
any time the ignition switch is in the ON position.
 You or others can be badly burned by hot
coolant or steam from your radiator. If you see or
hear steam coming from under the hood, do not
open the hood until the radiator has had time to
cool. Never try to open a cooling system pressure
cap when the radiator is hot .
Coolant Checks
Check engine coolant (antifreeze) protection every
12 months (before the onset of freezing weather,
where applicable). If coolant is dirty or rusty in appear-
ance, the system should be drained, flushed, and re-
filled with fresh coolant. Check the front of the A/C
condenser for any accumulation of bugs, leaves, etc. If dirty, clean by gently spraying water from a garden hose
vertically down the face of the condenser.
Check the coolant recovery bottle tubing for brittle
rubber, cracking, tears, cuts, and tightness of the con-
nection at the bottle and radiator. Inspect the entire
system for leaks.
Cooling System – Drain, Flush, And Refill
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
If the solution is dirty or contains a considerable
amount of sediment, clean and flush with a reliable
cooling system cleaner. Follow with a thorough rinsing
to remove all deposits and chemicals. Properly dispose
of the old engine coolant (antifreeze) solution.
Selection Of Coolant – 2.0L Diesel Engine
Use only the manufacturer's recommended coolant
(antifreeze). Refer to “Fluids, Lubricants, and Genuine
Parts” in “Technical Specifications” for further informa-tion.
 Do not use HOAT (Hybrid Organic Ad-
ditive Technology) products in the Diesel
Engine.
 Do not use OAT (Organic Additive Technology)
products containing 2-EH (2–ethyl hexanol).
(Continued)
226
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

(Continued)
 Do not use plain water alone or alcohol base
engine coolant (antifreeze) products. Do not use
additional rust inhibitors or antirust products, as
they may not be compatible with the radiator
engine coolant and may plug the radiator.
 This vehicle has not been designed for use with
Propylene Glycol based coolants. Use of Propyl-
ene Glycol based coolants is not recommended.
Adding Coolant – 2.0L Diesel Engine
Your vehicle has been built with an improved engine
coolant (antifreeze) that allows extended maintenance
intervals. This coolant can be used up to five years or
168 000 km before replacement. To prevent reducing
this extended maintenance period, it is important that
you use the same coolant throughout the life of your
vehicle.
Please note that it is the owner's responsibility to
maintain the proper level of protection against freezing
according to the temperatures occurring in the area
where the vehicle is operated.
NOTE: Mixing coolant types will decrease the life of
the engine coolant (antifreeze) and will require more
frequent coolant changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to ensure that coolant will return to the
radiator from the coolant recovery bottle. The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing sur-
faces.
WARNING!
 The warning words “DO NOT OPEN
HOT” on the cooling system pressure
cap are a safety precaution. Never add coolant
when the engine is overheated. Do not loosen or
remove the cap to cool an overheated engine.
Heat causes pressure to build up in the cooling
system. To prevent scalding or injury, do not re-
move the pressure cap while the system is hot or
under pressure.
 Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result .
Disposal Of Used Coolant
Used ethylene glycol-based engine coolant is a regu-
lated substance requiring proper disposal. Check with
your local authorities to determine the disposal rules
for your community. To prevent ingestion by animals or
children, do not store ethylene glycol-based engine
coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child, contact a
physician immediately. Clean up any ground spills
immediately.
227
KNOWING
YOURVEHICLE SAFETY
STARTING ANDDRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Coolant Level
The radiator normally remains completely full, so there
is no need to remove the radiator cap unless checking
for coolant freeze point or replacing coolant. Advise
your service attendant of this. As long as the engine
operating temperature is satisfactory, the coolant
bottle need only be checked once a month. When
additional coolant is needed to maintain the proper
level, it should be added to the coolant bottle. Do not
overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles
(kilometers) of operation, you may observe vapor
coming from the front of the engine compartment.
This is normally a result of moisture from rain, snow, or
high humidity accumulating on the radiator and being
vaporized when the thermostat opens, allowing hot
coolant to enter the radiator.
If an examination of your engine compartment shows
no evidence of radiator or hose leaks, the vehicle may
be safely driven. The vapor will soon dissipate.
• Do not overfill the coolant recovery bottle.
• Check coolant freeze point in the radiator and in the coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also
be protected against freezing.
• If frequent coolant additions are required, or if the level in the coolant recovery bottle does not drop
when the engine cools, the cooling system should be
pressure tested for leaks. • Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
• Keep the front of the radiator clean. If your vehicle is equipped with air conditioning, keep the front of the
condenser clean.
• Do not change the thermostat for Summer or Win- ter operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs
may result in unsatisfactory coolant performance,
poor gas mileage, and increased emissions.
BRAKE SYSTEM
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake fail-
ure and possibly an accident . Driving
with your foot resting or riding on the brake
pedal can result in abnormally high brake tem-
peratures, excessive lining wear, and possible
brake damage.You would not have your full brak-
ing capacity in an emergency.
Master Cylinder – Brake Fluid Level Check
Check the fluid level in the master cylinder immediately
if the “Brake Warning Light” indicates system failure.
Check the fluid level in the master cylinder when
performing underhood services.
228
KNOWING
YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Camera, Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Capacities, Fluid . . . . . . . . . . . . . . . . . . . . . . . . . 241
Caps, FillerFuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . 218,219
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 113
Radiator (Coolant Pressure) . . . . . . . . . . . . . . . 227
Car Washes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Carbon Monoxide Warning . . . . . . . . . . . . . . . . . 163
Cargo (Vehicle Loading) . . . . . . . . . . . . . . . . . . . . 100
Cargo Area Cover . . . . . . . . . . . . . . . . . . . . . . . 101
Cargo Area Features . . . . . . . . . . . . . . . . . . . . . . . 99
Cargo Compartment . . . . . . . . . . . . . . . . . . . . . . . 99 Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Luggage Carrier . . . . . . . . . . . . . . . . . . . . . . . . 104
Cargo Load Floor . . . . . . . . . . . . . . . . . . . . . . . . 100
Cargo Management System . . . . . . . . . . . . . . . . . . 100 Rollaway Tonneau Cover . . . . . . . . . . . . . . . . . . 101
Tri-Fold Load Floor . . . . . . . . . . . . . . . . . . . . . 100
Cargo Tie-Downs . . . . . . . . . . . . . . . . . . . . . . . . 100
Cellular Phone . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Changing A Flat Tire . . . . . . . . . . . . . . . . . . . . . . 193
Checking Your Vehicle For Safety . . . . . . . . . . . . . . 162
Checks, Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Child Booster Seat . . . . . . . . . . . . . . . . . . . . . . . 144
Child Restraint . . . . . . . . . . . . . . 141,143,145,149,151
Child Restraint Tether Anchors . . . . . . . . . . . . 146,149
Child Safety Locks . . . . . . . . . . . . . . . . . . . . . . . . 92Cleaning Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Windshield Wiper Blades . . . . . . . . . . . . . . . . . 223
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Coin Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Cold Weather Operation . . . . . . . . . . . . . . . . . . . 168
Compact Disc (CD) Maintenance . . . . . . . . . . . . . 129 Compact Spare Tire . . . . . . . . . . . . . . . . . . . . . . 237
Computer, Trip/Travel . . . . . . . . . . . . . . . . . . . . . . 23
Connector
UCI . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
Universal Consumer Interface (UCI) . . . . . . . . . . 129
Conserving Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Console, Floor . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Console, Overhead . . . . . . . . . . . . . . . . . . . . . . . . 77
Cool Down, Turbo . . . . . . . . . . . . . . . . . . . . . . . 168
Coolant Pressure Cap (Radiator Cap) . . . . . . . . . . . 227
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . 226 Adding Coolant (Antifreeze) . . . . . . . . . . . . . . . 227
Coolant Capacity . . . . . . . . . . . . . . . . . . . . . . . 241
Coolant Level . . . . . . . . . . . . . . . . . . . . . . 226,228
Diesel Engine . . . . . . . . . . . . . . . . . . . . . . . . . 226
Disposal of Used Coolant . . . . . . . . . . . . . . . . . 227
Drain, Flush, and Refill . . . . . . . . . . . . . . . . . . . 226
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Points to Remember . . . . . . . . . . . . . . . . . . . . 228
Pressure Cap . . . . . . . . . . . . . . . . . . . . . . . . . 227
Radiator Cap . . . . . . . . . . . . . . . . . . . . . . . . . 227
Selection of Coolant (Antifreeze) . . . . . . 226,241,242
Temperature Gauge . . . . . . . . . . . . . . . . . . . . . . . 7
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . 230
Cupholders . . . . . . . . . . . . . . . . . . . . . . . . . . 85,232
Data Recorder, Event . . . . . . . . . . . . . . . . . . . . . 161
Daytime Brightness, Interior Lights . . . . . . . . . . . . . 69
Daytime Running Lights . . . . . . . . . . . . . . . . . . . . . 67
Defroster, Rear Window . . . . . . . . . . . . . . . . . . . . 74
Defroster, Windshield . . . . . . . . . . . . . . . . . . . 60,164
Delay (Intermittent) Wipers . . . . . . . . . . . . . . . . . . 70
Diagnostic System, Onboard . . . . . . . . . . . . . . . . . 111
Diesel Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 240,242
Diesel Fuel Requirements . . . . . . . . . . . . . . . . . . . 240
248
KNOWING
YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Radiator Cap (Coolant Pressure Cap) . . . . . . . . . . . 227
Radio (Sound Systems) . . . . . . . . . . . . . . . . . . . . . 126
Radio Operation . . . . . . . . . . . . . . . . . . . . . . . . . 130
Radio Remote Controls . . . . . . . . . . . . . . . . . . . . 127
Rear Air Conditioning . . . . . . . . . . . . . . . . . . . . . . 62
Rear Camera . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Rear Cupholder . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Rear Fog Lights . . . . . . . . . . . . . . . . . . . . . . . . . . 189
Rear Liftgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Rear Park Sense System . . . . . . . . . . . . . . . . . . . . 120
Rear Seat, Folding . . . . . . . . . . . . . . . . . . . . . . . 47,51
Rear Window Defroster . . . . . . . . . . . . . . . . . . . . 74
Rear Window Features . . . . . . . . . . . . . . . . . . . . . 73
Rear Wiper/Washer . . . . . . . . . . . . . . . . . . . . . . . 73
Rearview Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . 53
Reclining Front Seats . . . . . . . . . . . . . . . . . . . . . . . 42
Reclining Rear Seats . . . . . . . . . . . . . . . . . . . . . 48,51
Recorder, Event Data . . . . . . . . . . . . . . . . . . . . . 161
Recreational Towing . . . . . . . . . . . . . . . . . . . . . . 183
Refrigerant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Release, Hood . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Reminder, Lights On . . . . . . . . . . . . . . . . . . . . . . . 67
Reminder, Seat Belt . . . . . . . . . . . . . . . . . . . . . . . 141
Remote Keyless Entry (RKE) . . . . . . . . . . . . . . . . . 12
Remote Sound System (Radio) Controls . . . . . . . . . 127
Repeater Lights, Side . . . . . . . . . . . . . . . . . . . . . . 203
Replacement Bulbs . . . . . . . . . . . . . . . . . . . . . . . 200
Replacement Keys . . . . . . . . . . . . . . . . . . . . . . . . . 11
Replacement Tires . . . . . . . . . . . . . . . . . . . . . . . 239
Resetting Oil Change Indicator . . . . . . . . . . . . . 22,186
Restraint, Head . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Restraints, Child . . . . . . . . . . . . . . . . . . . . . . . . . 141
Restraints, Occupant . . . . . . . . . . . . . . . . . . . . . . 132
Retractable Cargo Area Cover . . . . . . . . . . . . . . . 101
Reverse Lights . . . . . . . . . . . . . . . . . . . . . . . . . . 203Rocking Vehicle When Stuck . . . . . . . . . . . . . . . . . 210
Roof Rack (Luggage Rack) . . . . . . . . . . . . . . . . . . . 104
Rotation, Tires . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Safety Checks Inside Vehicle . . . . . . . . . . . . . . . . . 163
Safety Checks Outside Vehicle . . . . . . . . . . . . . . . 165
Safety Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Safety, Exhaust Gas . . . . . . . . . . . . . . . . . . . . . 99,163
Schedule, Maintenance . . . . . . . . . . . . . . . . . . . . . 215
Seat Belt Maintenance . . . . . . . . . . . . . . . . . . . . . 232
Seat Belt Reminder . . . . . . . . . . . . . . . . . . . . . . . 141
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . 132,133,163
Adjustable Upper Shoulder Anchorage . . . . . . . . 136
And Pregnant Women . . . . . . . . . . . . . . . . . . . 141
Child Restraint . . . . . . . . . . . . . . . . 141,143,145,151
Front Seat . . . . . . . . . . . . . . . . . . . . . . . . 133,134
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Operating Instructions . . . . . . . . . . . . . . . . . . . 134
Pretensioners . . . . . . . . . . . . . . . . . . . . . . . . . 138
Rear Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . 133
Reminder . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
Untwisting Procedure . . . . . . . . . . . . . . . . . . . . 136
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38 Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Child Booster . . . . . . . . . . . . . . . . . . . . . . . . . 144
Easy Entry . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Heated . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Height Adjustment . . . . . . . . . . . . . . . . . . . . 38,43
Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Rear Folding . . . . . . . . . . . . . . . . . . . . . . . . . 47,51
Reclining . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Reclining Rear . . . . . . . . . . . . . . . . . . . . . . . . 48,51
Seatback Release . . . . . . . . . . . . . . . . . . . . 43,47,51
Tilting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Security Alarm (Theft Alarm) . . . . . . . . . . . . . . 14,189
254
KNOWING
YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
SERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS