2011 FIAT DUCATO LEVEL 1

222
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
F0N0137mfig. 227
Replacing the windscreen wiper blades fig. 227
Proceed as follows:
❒lift the arm A of the wiper and position the blade so
that it forms an angle of 90° with the arm;
❒remove the press-fitted blade B from arm A;
❒insert the new blade making sure it is locked.
SPRAY NOZZLES
Windscreen washer fig. 228
If the jet of fluid is inadequate, firstly check that there is
fluid in the reservoir (see “Checking fluid levels” in this
section).
WINDSCREEN WIPER
BLADES
Periodically clean the rubber part using special products;
TUTELA PROFESSIONAL SC 35 is recommended.
Replace the blades if the rubber edge is deformed or
worn. In all cases, it is advisable to replace them
approximately once a year.
A few simple precautions can reduce the possibility of
damage to the blades:
❒make sure that the rubber part is not stuck to the
windscreen at sub-zero temperatures. Use an
antifreeze product to release it if required;
❒remove any snow from the glass: in addition to
protecting the blades, this prevents effort on the
motor and overheating;
❒do not operate the windscreen wipers on dry glass.
Driving with worn wiper blades is
a serious hazard, because visibility is
reduced in bad weather.
WARNING

224
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
❒wipe a sponge with a slightly soapy solution over the
bodywork, frequently rinsing the sponge;
❒rinse well with water and dry with a jet of air or
a chamois leather.
Dry the less visible parts particularly carefully, such as
the door frames, bonnet and the headlight frames,
where water may stagnate more easily. It is a good idea
to leave the vehicle outdoors for a while after washing it
to give the water time to evaporate.
Do not wash the vehicle after it has been left in the sun
or with the bonnet hot: this may alter the shine of the
paintwork.
Exterior plastic parts should be cleaned in the same way
as the rest of the vehicle.
Where possible, do not park the vehicle under trees;
the resinous substances released by many species give
the paint a dull appearance and increase the possibility
of rust.
To protect the paint more effectively, polish
occasionally with special protective waxes; when the
paint tends to cloud because of a build-up of smog,
polish with slightly abrasive protective waxes.
IMPORTANT Bird droppings must be washed off
immediately and carefully as the acid they contain is
particularly aggressive. VEHICLE BODY AND UNDERBODY
WARRANTY
Your vehicle is covered by warranty against perforation
due to rust of any original element of the structure or
body.
For the general terms of this warranty, refer to the
Warranty Booklet.
ADVICE FOR PRESERVING THE BODYWORK
Paint
Paintwork does not only serve an aesthetic purpose, but
also protects the underlying sheet metal. Touch up
abrasions and scratches immediately to prevent rust
formation. Use only original paint products for touch-
ups (see “Bodywork paint identification plate” in the
“Technical specifications” section). Normal maintenance
of paintwork consists in washing the car: the frequency
depends on the conditions and environment where the
car is used. For example, it is advisable to wash the
vehicle more often in areas with high levels of
environmental pollution or on roads spread with salt.
To correctly wash the vehicle proceed as follows:
❒remove the aerial from the roof to prevent damage
to it if the vehicle is washed in an automatic system;
❒wash the body using a low pressure jet of water;

5.6
5.9
5.9
5.6
5.9
5.9
5.5
6.0
6.46.6
6.9
6.9
6.6
6.9
6.9
7.0
7.6
8.08.3
8.5
8.5
8.3
8.5
8.5
9.5
10.3
10.730q
33q
35q
30q
33q
35q
30q
33q
35q
6.1
6.1
6.47.1
7.1
8.08.7
8,7
10.7
266
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
FUEL CONSUMPTION
The fuel consumption figures given in the table below are determined on the basis of the homologation tests set down by
specific European Directives. The procedures below are followed for measuring consumption:
urban cycle: cold starting followed by driving that simulates urban use of the vehicle; extra-urban cycle: frequent
accelerations in all gears, simulating extra-urban use of the vehicle: speed varies between 0 and 120 km/h;
mixed cycle: is calculated weighing about 37% of urban cycle consumption and about 63% of extra-urban consumption.
IMPORTANT The type of route, traffic situations, weather conditions, driving style, general conditions of the vehicle, trim
level/equipment/accessories, climate control system, vehicle load, roof rack, other situations that affect air drag may lead to
different fuel consumption levels than those measured.
130 Multijet
150 Multijet
180 Multijet Power
30q-33q
30q-33q
30q-33q
According to the European Directive in force (litres/100 km)
Versions Gross vehicle weight Consumptions
COMBI Urban Extra-urban Mixed
PANORAMA
130 Multijet
150 Multijet
180 Multijet Power

267
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
186
186
210
173
180
180
173
180
180
184
200
210
CO2EMISSIONS
The CO2emission levels at the exhaust given in the following tables refer to combined consumption.
130 Multijet
150 Multijet
180
Multijet Power
30q-33q
30q-33q
30q-33q
30q
33q
35q
30q
33q
35q
30q
33q
35q
According to the European Directive in force (g/km)
Versions Gross vehicle weight Emissions
COMBI
PANORAMA
130 Multijet
150 Multijet
180
Multijet Power

275
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– jump starting ....................... 169
– maintenance ........................ 218
– recharging ............................ 202
– replacement ........................ 218
– tips for extending life ........ 219
Body (marking) ......................... 228
Body
– maintenance ........................ 224
– version code ....................... 229
Bonnet ........................................ 104
Brake Assist (emergency
braking assistance) ................. 110
Brakes
– fluid level .............................. 215
– technical specifications ...... 232
Bulb replacement ..................... 181
– bulb types ....................182-183
– external bulb
replacement ............................ 184
– general information ........... 181
– internal bulb replacement .. 193Cab glove compartment
(Capucine) ............................... 91
Carrying children safely .......... 130
Carrying children safely .......... 130
– “Universal Isofix” child
restraint assembly setup ...... 134
– child seats ............................ 130
– positioning of child seats on
seats ..............................133-136
Ceiling lights .............................. 76
– bulb replacement ....... 193-194
Central door
locking/unlocking system ..... 96
Chassis (marking) .................... 229
Checking the levels ................. 209
Checking the levels ................. 209
– brake fluid ............................ 215
– brake fluid ............................ 216
– engine coolant .................... 213
– engine oil ............................. 211ABS 108
Accessories purchased
by the owner .......................... 121
Additional heater ..................... 60
Additional rear heating ........... 66
Additional independent
heater ....................................... 61
Additional rear air
conditioning ............................ 67
Air filter ..................................... 217
Arm rests.................................... 33
Ashtray ........................................ 88
ASR .............................................. 112
Automatic climate control ..... 54
Automatic headlight sensor
(dusk sensor) .......................... 70
Battery
– battery disconnection
function (disconnector) .... 80
INDEX
............................
...........
......

276
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– washer fluid for
windscreen/rear
window/headlamps ............ 214
Cigar lighter .............................. 88
Cleaning and maintenance
– bodywork ............................ 223
– engine compartment .......... 225
– front headlights .................... 225
– glasses ................................... 225
– interiors ............................... 225
– leather upholstery .............226
– paintwork ............................ 224
– plastic parts .......................... 226
– rubber tubes ....................... 221
– seats and fabric parts ........ 226
– windows ................................ 225
CO
2emissions........................... 267
Instrument panel .................... 14
Code card................................... 5
Compartment under front
passenger seat ........................ 86
Compartment under the seat .. 36
Controls .................................... 79Cruise Control (constant speed
regulation) ............................... 74
Cruise Control (constant speed
regulator) ................................ 74
Cup/can holder ........................ 87
Dashboard ................................ 3
Daytime lights
– bulb replacement ............... 186
– control ................................. 68
Dead lock (device) .................. 99
Desk/bookrest........................... 90
Dimensions ............................... 237
Dipped beam headlights
– bulb replacement ............... 186
– control ................................. 68
Dipped headlights
– bulb replacement ............... 186
– control................................... 74
Direction indicators
– bulb replacement ....... 187-189
– control ................................. 69Direction indicators
– control ................................. 69
– front bulb replacement ..... 187
– rear bulb replacement ...... 189
Door lock .................................. 81
Door pockets ........................... 86
Doors ......................................... 96
DPF (diesel particulate filter).... 124
DPF (diesel particulate filter).... 124
EBD system .............................. 108
Electric windows ...................... 103
Electrical power supply and fuel
cut off switch .......................... 82
Electrical/electronic devices
(installation) ............................ 121
Electronic alarm ....................... 10
Engine codes ............................. 228
Engine compartment
– bonnet opening/closing ..... 104
– checking the levels ............. 209
– washing.................................. 225
Engine coolant fluid
– checking the level ............... 214

277
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Fluids and lubricants
(quantity and products) 263-264
Fog lights
– alignment ............................. 108
– bulb replacement ............... 188
– control ................................. 79
Follow Me Home (device) ..... 70
Front air bags ............................ 137
Fuel consumption
– engine oil ............................. 212
– fuel ........................................ 266
Fuel flap ...................................... 124
Fuel level gauge ........................ 16
Fuel reserve .............................. 155
Fuel tank cap ............................. 123
Fuel
– consumption ....................... 264
– electricity supply and fuel
cut off switch........................ 82
– fuel cap ................................. 123
– fuel level gauge ................... 16
– saving .................................... 148
Fuses (if a fuse blows) .............195
– fuse list ................................. 198– fuses (if a fuse blows) ........ 195
– general information ........... 195
– location (fuse boxes) ......... 196
– users list ............................... 198
Gearbox
– using the manual gearbox ... 146
General warnings...................... 2
Glove compartment ................ 85
Handbrake ................................ 145
Handbrake lever ...................... 145
Hazard warning lights ............. 79
Head restraints ........................ 40
Headlight alignment
correction ............................... 107
Headlight washers
– control................................... 73
– maintenance ........................ 223
Headlights .................................. 107
– adjusting headlights
abroad .................................. 108
– beam orientation................. 107
– bulb replacement ............... 184 – temperature gauge ............ 16
Engine coolant temperature
gauge ........................................ 16
Engine oil gauge ......................... 17
Engine oil
– checking the level ............... 211
– engine oil gauge .................. 17
– oil consumption ................. 214
– technical specifications ...... 264
Engine
– bonnet .................................. 104
– identification code ............. 229
– marking ................................ 228
– specifications ....................... 230
Environment (protecting) ...... 124
EOBD system ........................... 115
ESP system ................................ 110
External lights ........................... 68
Fiat CODE system .................. 4
Fix & Go automatic (quick tyre
repair kit) ................................ 176
Flashing the headlights ............ 69

279
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Number plate lights (bulb
replacement) .......................... 192
Official type approval for radio
frequency remote control .... 269
On-board instruments
(panel) ..............................14-15
– engine coolant
temperature gauge ............. 16
– engine oil gauge .................. 17
– fuel level gauge..................... 16
– multifunction display ......... 18
– rev counter ......................... 15
– speedometer........................ 15
– trip computer ..................... 29
Paintwork
– identification plate ............. 228
– maintenance ........................ 224
Bodywork version ................. 229
Parking lights
– control ......................... 69-80
Parking sensors ........................ 116Passenger compartment
air vents ................................... 46
Performance ............................. 240
Pollen filter ................................ 217
Portable navigator socket ....... 91
Power socket ........................... 89
Preparation for “Isofix”
child seat ................................. 134
Pretensioners............................. 127
Protecting
the environment..................... 124
Quick tyre repair kit
“Fix & Go automatic” ........... 176
Radio .......................................... 119
Radio frequency
remote control:
official type approval ............. 269
Radio transmitters and mobile
phones ..................................... 121
Rain sensor ............................... 73
Raising the vehicle ................... 203
Rear double swing door ......... 101Rear fog light
– bulb replacement ....... 189-191
– control ................................. 80
Rear partition ........................... 87
Rear view mirrors.................... 42
– defrosting/demisting .......... 44
– electric adjustment ............ 42
– external ................................ 42
– interior ................................. 42
Refrigerated compartment .... 84
– Speed block .......................... 96
Refuelling (quantity
and products) .................263-264
Refuelling the vehicle .............. 122
Rev counter .............................. 15
Reversing lights (bulb
replacement) .......................... 189
Rim Protector (tyres).............. 234
Rims
– reading rim markings ......... 235
Roof lights
– bulb replacement ....... 193-194
– control ................................. 76