Emission Warranty Parts List 23
Emission Warranty Parts List
The emission parts listed here are
covered under the Emission Control
System Warranty. The terms are
explained previously in this section
under the“Federal Emission Control
System Warranty” and the
“California Emission Control System
Warranty”.
Important: Certain parts may be
covered beyond these warranties if
shown with asterisk(s) as follows:
.(*) 7 years/70,000 miles,
whichever comes first, California
Emission Control System
Warranty coverage.
.(**) 8 years/80,000 miles,
whichever comes first, Federal
Emission Control System
Warranty coverage. (Also
applies to California certified
light duty and medium duty
vehicles.)
.(*) and (**) are 8 years/
100,000 miles, whichever comes
first, for California LEV2 vehicles
equipped with option code NUA.
All listed parts 15 years/
150,000 miles, whichever comes
first, on California PZEV (NU6)
vehicles registered in a PZEV state.
The Emission Control System
Warranty obligations do not apply to
conditions resulting from tampering,
abuse, neglect, or improper
maintenance; or any other item
listed under “What Is Not Covered”
under New Vehicle Limited Warranty
on page 4. The “Other Terms”
presented under New Vehicle
Limited Warranty on page 4 also
apply to the emission related
warranties.
Powertrain Control System
ABS Control Module **
Camshaft Position Actuator *
Camshaft Position Actuator Valve
Coolant Level Sensor Data Link Connector
Engine Control Module (ECM) **
Engine Coolant Temperature Sensor
Fuel Control Module **
Intake Air Temperature Sensor
Malfunction Indicator Lamp
Manifold Absolute Pressure Sensor
Mass Air Flow Sensor
Oil Pressure Sensor Active Fuel
Management™
(AFM) only
Oxygen Sensor(s)
Powertrain Control Module (PCM) **
Throttle Position Sensor
Vehicle Control Module (VCM) **
Vehicle Speed Sensor
Wheel Speed Sensor
24 Emission Warranty Parts List
Transmission Controls and
Torque Management
GMLAN (CAN) Communications
Circuit
Manual Transmission Clutch Switch
Park/Neutral Switch
Torque Converter Clutch Solenoids
Torque Converter Clutch Switch
Transmission Control Module **
Transmission Fluid Temperature
Sensor
Transmission Gear Selection Switch
(Diesel)
Transmission Internal Mode Switch *
Transmission Pressure Control
Solenoids *
Transmission Pressure Switches *
Transmission Shift Solenoids *
Transmission Speed Sensor
(Input) *
Transmission Speed Sensor
(Output)Fuel Management System
Common Rail Assembly (6.6L
DURAMAX
®Diesel) *
Diesel Fuel Injection Pump *
Diesel Fuel Injector Control
Module –EDU (6.6L DURAMAX
®
Diesel) *
Direct Fuel Injector Assembly
(6.6L DURAMAX
®Diesel) *
Fuel Injector
Fuel Pressure Regulator
Fuel Pressure Sensor
Fuel Rail Assembly *
Fuel Temperature Sensor
Function Block (6.6L DURAMAX
®
Diesel)
High Pressure Fuel Pump (SIDI) *
Air Management System
Active Air Shutters
Air Cleaner
Air Cleaner Resonator
Air Intake Ducts Charge Air Control Actuator
Charge Air Control Solenoid Valve
Charge Air Control Valve
Charge Air Cooler *
Charge Air Cooler Fan
Idle Air Control Valve
Idle Speed Control Motor
Intake Air Heater
Intake Manifold *
Intake Manifold Gasket (7/70 Only
with 3.5L LZE or 3.9L LGD *)
Intake Manifold Heater
Intake Manifold Tuning Valve
Supercharger Assembly *
Throttle Body * (Replacement Only)
Throttle Body Heater
Turbocharger Assembly *
Turbocharger Boost Sensor
Turbocharger Oil Separator
Vacuum Pump (6.6L DURAMAX
®
Diesel)
Emission Warranty Parts List 25
Ignition System
Camshaft Position Sensor(s)
Crankshaft Position Sensor(s)
Glow Plug(s) (Diesel)
Glow Plug Controller (Diesel)
Ignition Coil(s)
Ignition Control Module
Knock Sensor
Spark Plug Wires
Spark Plugs
Catalytic Converter System
Catalytic Converter(s) and Muffler if
attached as assembly * **
Diesel Exhaust Temperature and
Pressure Sensors
Diesel Particulate Filter (DPF) *
Diesel Exhaust (DPF) Indirect Fuel
Injector
Diesel Exhaust Emission Reduction
Fluid Injector
Diesel Exhaust Emission Reduction
Fluid TankDiesel Exhaust NOx Sensors
Exhaust Manifold *
Exhaust Manifold with Catalytic
Converter attached as assembly * **
Exhaust Manifold Gasket
Exhaust Pipes and/or Mufflers
(when located between catalytic
converters and exhaust manifold)
Positive Crankcase Ventilation
(PCV) System
Oil Filler Cap
PCV Filter
PCV Oil Separator
PCV Valve
Exhaust Gas Recirculation (EGR)
System
EGR Feed and Delivery Pipes or
Cast-in Passages
EGR Valve
EGR Valve Cooler
(6.6L DURAMAX
®Diesel) *
EGR Vacuum Pump Assembly
(6.6L DURAMAX
®Diesel)
Secondary Air Injection System
Air Pump
Check Valves
Evaporative Emission Control
System (Gasoline Engines)
Canister
Canister Purge Solenoid Valve
Canister Vent Solenoid
Fuel Feed and Return Pipes and
Hoses
Fuel Filler Cap
Fuel Level Sensor
Fuel Limiter Vent Valve *
Fuel Tank(s) *
Fuel Tank Filler Pipe (with restrictor)
Fuel Tank Vacuum or Pressure
Sensor
