2010 VOLVO S80 headlight bulb

06 Maintenance and specifications
Replacing bulbs
06
222* Option/accessory, for more information, see Introduction.
Introduction
All bulb specifications are listed on page 228.
The following bulbs should only be replaced by
a trained and qualified Volvo service techni-
cian:
•Dome lighting
•Reading lights
•Glove compartment lighting
•Turn signals in the door mirror
•Approach lighting in the door mirror
•Brake/fog/taillights
•Rear side parking lights
•Active Bending Lights and LED bulbs
NOTE
For information regarding any other bulbs
not mentioned in this section, please con-
tact your Volvo retailer or a trained and
authorized Volvo service technician.
WARNING
•Active Bending Lights* – due to the high
voltage used by these headlights, these
bulbs should only be replaced by a
trained and qualified Volvo service tech-
nician.
•Turn off the lights and remove the
remote key from the ignition before
changing any bulbs.
Headlight housing
WARNING
•The engine should not be running when
changing bulbs.
•When changing in the headlight hous-
ing, if the engine has been running just
prior to replacing bulbs, please be
aware that components in the engine
compartment will be hot.
The entire headlight housing must be lifted out
when replacing all front bulbs (except for the
fog lights).
CAUTION
Never touch the glass of bulbs with your fin-
gers. Grease and oils from your fingers
vaporize in the heat and will leave a deposit
on the reflector, which will damage it.

06 Maintenance and specifications
Replacing bulbs
06

223
NOTE
•Always switch off the ignition before
starting to replace a bulb.
•The optional Active Bending Light bulbs
contain trace amounts of mercury.
These bulbs should always be disposed
of by a trained and qualified Volvo serv-
ice technician.
Removing the headlight housing1. Switch off the ignition by pressing quickly
on the START/STOP ENGINE button and
remove the remote key from the ignition
slot
1.
2. (Upper illustration under "Headlight hous-
ing")
Withdraw the headlight housing's lock-
ing pins.
Pull the headlight housing straight out .
CAUTION
When disconnecting the connector, pull on
the connector itself and not on the wiring.
3. (Lower illustration under "Headlight hous-
ing")
Unplug the wiring connector by holding
down the clip with your thumb.
Pull out the connector with the other
hand.
4. Lift out the housing and place it on a soft
surface to avoid scratching the lens.
5. Replace the defective bulb(s).
Reinserting the headlight housing1. Plug in the connector until it clicks into
place.
2. Reinstall the headlight housing and locking
pins. Check that they are correctly
inserted. The headlight housing must be
properly inserted and secured in place
before the lighting is switched on or the
remote key is inserted into the ignition slot.
3. Check that the lights function properly.
Removing the cover to access the
headlights and parking lights
G021745
NOTE
Before starting to replace a bulb, see
page 222.
1. Open the retaining clamp by pressing it to
the side.
2. Press down the clips on the upper edge of
the cover and remove it.
Reinstall the cover in the reverse order.
1Does not apply to vehicles with the optional keyless drive.

06 Maintenance and specifications
Replacing bulbs
06
224
Low beam, Halogen
G021746
1. Remove the headlight housing from the
vehicle (see page 222).
2. Remove the cover over the bulbs.
3. Detach the bulb by pressing the upper sec-
tion of the retaining spring downward and
to the side.
4. Unplug the connector from the bulb.
5. Replace the bulb and reinsert it into the
headlight housing.
6. Put the cover back into position and rein-
stall the headlight housing.
High beam, Halogen
G021747
1. Remove the headlight housing from the
vehicle (see page 222).
2. Remove the cover over the bulbs (see
page 223).
3. Pull the bulb holder out of the headlight
housing.
4. Turn the defective bulb counterclockwise
and pull it out of the socket.
5. Press the new bulb into the socket until it
snaps into place. It can only be secured in
one position.
6. Return the bulb holder into position in the
headlight housing.7. Put the cover back into position and rein-
stall the headlight housing.
Extra high beam2
G021748
1. Remove the headlight housing from the
vehicle (see page 222).
2. Remove the cover over the bulbs (see
page 223).
3. Remove the bulb by pressing the holder
downward.
4. Remove the connector from the bulb.
5. Insert a new bulb in the connector until it
snaps in place. It can only be inserted in
one way.
2Models with optional Active Bending Lights only.

06 Maintenance and specifications
Replacing bulbs
06

225
6. Return the bulb holder into position in the
headlight housing.
7. Put the cover back into position and rein-
stall the headlight housing.
Parking lights
G021749
1. Remove the headlight housing from the
vehicle (see page 222).
2. Remove the cover over the bulbs (see
page 223).
3. To access the bulb, first remove the high
beam bulb.
4. Pull the wire to withdraw the bulb holder.
5. Remove the burned out bulb and install a
new one. It can only be secured in one
position.6. Press the bulb holder into the socket and
press until it clicks into place.
7. Put the cover back into position and rein-
stall the headlight housing.
Turn signals
G021750
1. Remove the headlight housing from the
vehicle (see page 222).
2. Remove the round cover by pulling the tab
until the cover comes off.
3. Pull out the holder to access the bulb.
4. Remove the burned out bulb by pressing it
in slightly and turning out before pulling it
out. Press a new bulb into the socket.
5. Press the bulb holder into the socket and
press until it clicks into place.6. Press the cover until it clicks into position.
7. Reinstall the headlight housing.
Side marker lights
G021751
NOTE
Before starting to replace a bulb, see
page 222.
1. Remove the headlight housing from the
vehicle (see page 222).
2. Remove the round cover.
3. Pull the wire to withdraw the bulb holder.
4. Pull out the burned out bulb and install a
new one. It can only be secured in one
position.

07 Index
07
282
1, 2, 3 ...
12-volt sockets........................................ 191
A
ABS (anti-lock brake system).................. 114
Accessory installation warning.................. 10
Active chassis system.............................158
Active yaw control................................... 156
Adaptive cruise control.................... 167, 169
Airbags
disconnecting the front passenger’s
side.................................................24, 25
front...................................................... 20
inflatable curtain................................... 30
side impact........................................... 28
Air conditioning........................................ 130
Air distribution.......................................... 127
Air distribution table................................. 132
Air vents................................................... 128
All Wheel Drive......................................... 113
Anti-freeze.......................................198, 220Anti-lock brake system............................ 114
warning light......................................... 74
Anti-lock Brake System (ABS)................. 114
Approach lighting................................54, 95
Audio system
audio functions................................... 134
CD player/changer.............................. 144
HD digital radio................................... 138
overview.............................................. 133
radio functions.................................... 135
Sirius satellite radio............................141
sound settings.................................... 134
steering wheel keypad........................ 133
USB/iPodŸ connector........................ 136
Auto-dim rearview mirror......................... 101
Automatic locking retractor....................... 35
Automatic transmission
Geartronic................................... 111, 112
general description.....................111, 112
oil........................................................ 278
shiftlock override................................ 112
Axle weight.............................................. 252
B
Battery
changing............................................. 233
maintenance...............................232, 233
remote key, replacing........................... 57
specifications...................................... 279
warning symbols................................. 232
Black box.............................................9, 214
Blind Spot Information System
(BLIS)....................................... 185, 186, 187
Bluetooth cell phone connection............. 147
Booster cushions....................................... 42
Brake lights................................................ 92
Brake system
checking fluid level............................. 220
emergency brake assistance.............. 115
fluid..................................................... 278
general information............................. 114
warning light......................................... 76
Bulbs
footwell lighting................................... 227
headlights...........................222, 223, 224
introduction......................................... 222
license plate lights.............................. 227
side marker lights...............................225

07 Index
07
284
Emergency starting.................................. 109
Emergency towing...........................209, 210
Emission inspection readiness................ 215
Engine
overheating........................................... 76
specifications...................................... 276
starting................................................ 107
switching off....................................... 109
Engine compartment overview................217
Engine oil
checking............................................. 218
low pressure warning light.............. 75, 76
specifications...................................... 276
volumes.............................................. 277
Environment............................................... 11
Eyelets for anchoring loads..................... 204
F
Federal Clean Air Act............................... 214
Fluid specifications.................................. 278
Fog lights
front...................................................... 75
front/rear............................................... 92
Four C (active chassis system)................158Front airbags.............................................. 20
disconnecting passenger’s side air-
bag.................................................. 24, 25
Front fog lights..................................... 75, 92
Front park assist.............................. 182, 184
Front seats..................................... 82, 84, 87
heated................................................. 129
lumbar support (S80 Executive only).... 87
massage function (S80 Executive only) 87
moving passenger's seat (S80 Execu-
tive only)................................................ 88
Fuel filler cap........................................... 202
Fuel filler door, opening........................... 202
Fuel level warning light.............................. 75
Fuel requirements............................ 200, 201
Fuel tank volume.....................................278
Fuses............................... 235, 236, 239, 242G
Gasoline requirements............................. 201
Gas tank volume...................................... 278
Gauges...................................................... 73
Geartronic................................................ 112Geartronic automatic transmission.. 111, 112
Generator warning light............................. 76
Glossary of tire terminology..................... 252
Grocery bag holder.................................. 205
Gross vehicle weight...............................252
H
Hazard warning flashers............................ 93
HD digital radio........................................ 138
Headlights
Active Bending Lights........................... 91
changing bulbs...........................223, 224
high/low beams.................................... 90
high beam flash.................................... 90
Headlight washers..................................... 97
Heartbeat sensor (alarm system).........55, 56
Heated front seats................................... 129
Heated oxygen sensors........................... 203
Heated rear seats.................................... 129
High beams................................................ 90
indicator light........................................ 75
Hoisting the vehicle.................................215
Home safe lighting..................................... 94