2010 Peugeot Boxer Dag fuel
[x] Cancel search: fuelPage 3 of 167
2271
FAMILIARISATION
7
Familiarisation
Opening
Pull the handle towards you.
Closing
To close, start with the left-hand door then
close the right-hand door. Rear doors
Opening to 180°
Press the button, located on the door trim
panel, to widen the angle of opening of the
door. Fuel tank
Opening the fuel filler flap.
Hooking the fuel filler cap.
Capacity of the fuel tank: approximately
90 litres.
24
ACCESS
24
130
Page 31 of 167
Instruments and controls
3 4
FUEL GAUGE
T h e f u e l l e v e l i s t e s t e d e a c h t i m e t h e k e y i s
t u r n e d t o t h e " r u n n i n g " p o s i t i o n .
T h e g a u g e i s p o s i t i o n e d o n :
- F (Full): t h e f u e l t a n k i s f u l l ,
a p p r o x i m a t e l y 9 0 l i t r e s .
- E (Empty): t h e r e s e r v e i s n o w b e i n g
u s e d , t h e w a r n i n g l a m p c o m e s o n
continuously.
T h e r e s e r v e w h e n t h e w a r n i n g f i r s t c o m e s
o n i s a p p r o x i m a t e l y 1 1 l i t r e s .
F u e l t a n k s o f d i f f e r e n t c a p a c i t i e s ( 6 0 a n d
1 2 5 l i t r e s ) a r e a v a i l a b l e a s a n o p t i o n .
COOLANT TEMPERATURE
The needle is positioned between
C (Cold) and H (Hot): normal operation.
I n a r d u o u s c o n d i t i o n s o f u s e o r h o t c l i m a t i c
c o n d i t i o n s , t h e n e e d l e m a y m o v e c l o s e t o
t h e r e d g r a d u a t i o n s . - w a i t f o r t h e e n g i n e t o c o o l d o w n i n
o r d e r t o c h e c k t h e l e v e l a n d t o p i t u p i f
n e c e s s a r y . F o l l o w t h i s a d v i c e :
t h e c o o l i n g s y s t e m i s p r e s s u r i s e d . I n o r d e r t o a v o i d a n y r i s k o f s c a l d i n g ,
u n s c r e w t h e c a p b y t w o t u r n s t o a l l o w
t h e p r e s s u r e t o d r o p .
W h e n t h e p r e s s u r e h a s d r o p p e d , c h e c k t h e
l e v e l a n d r e m o v e t h e c a p t o t o p u p .
I f t h e n e e d l e r e m a i n s i n t h e r e d z o n e ,
c o n t a c t a P E U G E O T d e a l e r .
R e f e r t o t h e " L e v e l s " s e c t i o n o f c h a p t e r 7 .
R e f e r t o t h e " F u e l " s e c t i o n o f c h a p t e r 7 .
What you should do if the needle enters the
red zone, or if the warning
lamp
comes on:
- s t o p i m m e d i a t e l y , s w i t c h o f f t h e i g n i t i o n . T h e f a n m a y c o n t i n u e t o o p e r a t e f o r
a c e r t a i n t i m e u p t o a p p r o x i m a t e l y
10 minutes.
EMISSION CONTROL
E O B D ( E u r o p e a n O n B o a r d D i a g n o s i s ) i s
a d i a g n o s t i c s s y s t e m w h i c h c o m p l i e s w i t h ,
a m o n g o t h e r s , t h e s t a n d a r d s c o n c e r n i n g
a u t h o r i s e d e m i s s i o n s o f :
- C O ( c a r b o n m o n o x i d e ) ,
- H C ( u n b u r n t h y d r o c a r b o n s ) ,
- N O x ( n i t r o g e n o x i d e s ) o r p a r t i c l e s , d e t e c t e d b y o x y g e n s e n s o r s p l a c e d
u p s t r e a m a n d d o w n s t r e a m o f t h e
catalytic converters.
T h e r e f o r e , t h e d r i v e r i s w a r n e d o f a n y
m a l f u n c t i o n o f t h i s e m i s s i o n c o n t r o l
s y s t e m b y t h e l i g h t i n g o f t h i s s p e c i fi c
w a r n i n g l a m p o n t h e i n s t r u m e n t p a n e l .
T h e r e i s a r i s k o f d a m a g e t o t h e c a t a l y t i c
c o n v e r t e r . H a v e i t c h e c k e d b y a P E U G E O T
d e a l e r .
Page 55 of 167
57
3
EASE OF USE AND COMFORT
Ventilation
Cancelling the programming
Press this button briefly to clear
the programmed start time.
The scren illumination and the
pre-selection number (e.g. 1) are
switched off.
Good practice
To avoid any risk of poisoning or
asphyxiation, the additional heating must
not be used, even for short periods, in
an enclosed space such as a garage or
workshop which is not fitted with an exhaust
gas extraction system.
The additional heating is supplied by the
vehicle's fuel tank. Ensure that the fuel
gauge indicator lamp is not at reserve.
Always switch off the additional heating
when filling with fuel to avoid any risk of fire
or explosion.
Do not park the vehicle on an inflammable
surface (dry grass, dead leaves, paper…),
there is a risk of fire.
The temperature near the heater must not
exceed 120 °C. A temperature higher than
this (for example in the case of painting in
an oven) could damage the components of
the electronic circuits.
The additional heating system is fitted with
a temperature limiter which cuts off the
combustion in the event of overheating due
to a lack of coolant. Top up the coolant,
then press the programme selection control
before switching the heating on again. Have the additional heating system
checked at least once a year at the
beginning of winter. Maintenance and
repairs should only be carried out by a
PEUGEOT dealer.
Use only genuine replacement parts.
Recalling one of the pre-selected start times
Press this button as many times
as necessary until the number
corresponding to the required
pre-selected start time (e.g. 2)
appears.
After ten seconds, the time is cleared but
remains stored for as long as the number
(e.g. 2) and the screen remain lit.
Switching off the heating
Press this button.
The heating cycle indicator and
the screen are switched off.
Two different types of equipment
The additional heating is separate and
programmable. Before you enter the vehicle,
it gradually increases the temperature of the
engine to make starting easier. This also
facilitates passenger compartment heating,
demisting and defrosting.
The additional passenger compartment
heating system supplements the
standard equipment. Its operation may be
independent of the engine. Switching on of
the heating may be programmable.
Page 70 of 167
72
Trip computer
The TRIP button, located at the end of the
wiper stalk, provides access to the following
information:
- Ambient
temperature
This indicates the temperature outside the vehicle.
- Range
This indicates the distance that can still be travelled with the fuel remaining in
the tank on the basis of the average
consumption over the last few miles
(kilometres) travelled. -
Average speed A
This is the average speed calculated since the last trip computer zero reset
(with the ignition on).
- Trip duration A
This indicates the total time since the last trip recorder zero reset.
-
Distance A
This indicates the distance travelled since the last trip computer zero reset.
- Average
fuel
consumption A
This is the average quantity of fuel consumed since the last trip computer
zero reset.
- Current
fuel
consumption A
This is the average quantity of fuel consumed during the last few seconds.
TRIP COMPUTER
If TRIP B is activated on the MODE menu:
- Distance B
- Average fuel consumption B
- Average speed B
- Trip duration B
Page 73 of 167
75
4
TECHNOLOGY ON BOARD
Mode
Menu… Press... Sub-menu… Press... Select…
Confirm
and exit
Enables you to...
8 Measurement
unit (Unit) Distance
Km
Select the distance display unit.
Miles
Fuel
onsumption km/l
Select the fuel consumption
display unit.
l/100 km
9 Languages List of
languages
available Select the display language.
10 Volume of
announcements
(Buzz) Increase Increase/decrease the volume
of the announcements or of the
audible warning.
Decrease
11 Volume of
the buttons Increase
Increase/decrease the volume of
the buttons.
Decrease
12 Service Service
(Miles/km before
oil change) Display the miles/kilometres
remaining before the next oil
change.
Oil Display the oil level.
13 Passenger
airbag
(BAG P) ON
Yes
Activate the passenger airbag.
No
OFF Yes
Deactivate the passenger
airbag.
No
14 Exit from
menu Exit from the menu. Press the
arrow at the bottom to go to the
first menu.
Page 131 of 167
130
Fuel
Low fuel level
When the fuel tank level E
(Empty) is reached, this warning
lamp comes on. At this moment,
you have enough fuel left to
drive approximately 30 miles (50 km) ,
depending on the driving conditions, the
engine and the profile of the road. Fill up
without delay to avoid running out of fuel. The fuel tank must be filled
with the engine
off.
- Open the fuel filler flap.
- Support the cap with one hand.
- With the other hand, insert the key, then turn it anticlockwise.
- Remove the cap and hook it onto the clip located on the inside of the flap.
A label affixed to the inside of the flap
reminds you of the type of fuel to be used.
When filling the fuel tank, do not continue
after the 3rd cut-off of the nozzle. This could
cause malfunctions.
The capacity of the fuel tank is
approximately 90 litres.
- After filling the fuel tank, lock the cap and close the flap.
Fuel tanks of different capacities, 60 and
125 litres, may be fitted.
FUEL SYSTEM
CUT-OFF
In the event of a serious collision, a device
automatically cuts off the fuel supply to the
engine and the vehicle's electrical supply.
FILLING WITH FUEL
Check that there is no smell or leak of fuel
outside the vehicle.
Restore the supply by pressing:
- the first button, located under the glove box.
- the second button, located in the battery compartment under the driver's floor.
In low temperatures
In mountainous and/or cold areas, it is
advisable to use a "winter" type fuel suited
to low or minus temperatures.
Page 146 of 167
QUICK HELP
8
Changing a fuse
FUSES IN THE ENGINE COMPARTMENT
- Remove the nuts and tilt the box to access the fuses.
Fuses A (amps) Allocation
1 40 ABS/ESP pump supply
2 50 Diesel pre-heat unit
3 30 Ignition switch
4 20 Programmable additional heating burner
5 20 Programmable additional heating controls rela y
6 40/60 Fan assembly (high speed)
7 40/50 Fan assembly (low speed)
8 40 Air conditioning
9 20 Windscreen wash pump
10 15 Horn
11 15 Diesel pre-heat unit and relay
14 7.5 Right-hand main beam headlamp
15 7.5 Left-hand main beam headlamp
16 7.5 Engine control unit
17 10 Engine control unit
18 7.5 Engine control unit
19 7.5 Air conditioning compressor
20 30 Headlamp wash pump
21 15 Fuel pump supply
22 20 Engine control unit
23 30 ABS/ESP electrovalves supply
24 - Not used
30 15 Front foglamps
Page 157 of 167
157
9
TECHNICAL DATA
Diesel engines
Diesel engines and gearboxes
2.2 HDi 100 2.2 HDi 120 3 HDi 160
Gearbox Manual Manual
Gears 5 6 6
Power (hp) 100 120 156
EU standard maximum power (kW) 74 88 115
Cubic capacity (cc) 2 198 2 198 2 999
Bore x stroke (mm) 86 x 94.6 86 x 94.6 95.8 x 104
Max power engine speed (rpm) 2 900 3 500 3 500
EU standard max torque (daNm) 25 32 40
Max torque engine speed (rpm) 1 500 2 000 1 700
Fuel Diesel Diesel Diesel
Catalytic converter Yes Yes Yes
Engine oil capacity (in litres) 6.4 6.4 -