2010 OPEL COMBO wheel torque

141
Self-help, vehicle care
Picture no: 11647s.tif
7. Screw in the wheel bolts. Push the wheel
bolt wrench 3 on as far as possible and
tighten the wheel bolts slightly.
On some versions, the wheel trim must
be positioned before the wheel bolts
are tightened.
8. Lower vehicle. 9. Push the wheel bolt wrench 3 on as far
as possible and tighten crosswise.
Tightening torque is 110 Nm.
Alloy wheels 3: put hub cap on and
engage, inserting pin on rear of hub
cap into relevant hole in wheel.
Alloy wheels with anti-theft lock3: Put
hub cap on. Insert and tighten anti-
theft lock3.
10. Before refitting the wheel trim, clean the
wheel around the retaining clips. Valve
symbol 3 on back of wheel trim must
point towards valve on wheel.
Align and engage hub cap or wheel
trim 3 and wheel bolt caps 3.11. Stow the replaced wheel, tools and
warning triangle 3133, 3136.
12. Check the tyre pressure of the newly
mounted wheel.
13. Have the wheel bolt tightening torque
(110 Nm) checked.
14. Replace the faulty tyre on the wheel
that was removed.

167 Opel Service, maintenance
⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
302
603
904
1205
150
Visually inspect steering bellows, track rods and axle drive xxxxx
Check track-rod ends and suspension ball joints xxxxx
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not out
of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and not
out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
For Germany only: carry out emissions inspection (AU), general inspection (HU) First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually

170 Opel Service, maintenance⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
Visually inspect steering bellows, track rods and axle drive x x x x x
Check track-rod ends and suspension ball joints x x x x x
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not
out of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and
not out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually

191
Technical data
Tyres Not all tyres available on the market
currently meet the structural requirements.
We recommend that you consult an Opel
Partner concerning suitable tyre makes.
These tyres have undergone special tests
to establish their reliability, safety and
specific suitability for Opel vehicles.
Despite continuous market monitoring, we
are unable to assess these attributes for
other tyres, even if they have been granted
approval by the relevant authorities or in
some other form.
Further information 3121. Winter tyres
3
Tyre sizes 185/60 R 15, 185/65 R 15,
195/45 R 16 and 195/50 R 16 are not
permitted for winter driving.
Exception: Tyres of size 185/60 R 15 may be
used as winter tyres on the Combo
Tramp/Arizona. If winter tyres are in use, the spare wheel
may still be fitted with a summer tyre. Use
of the spare wheel may alter vehicle
handling. Obtain a replacement for the
faulty tyre as soon as possible, and have
the wheel balanced and fitted to the
vehicle.
Further information 3124.
Tyre chains
3
Tyre chains may be used on the front
wheels only.
We recommend the use of tyre chains with
a fine mesh that add no more than 10 mm
to the running surface and the insides of
the tyres (including chain lock).
Tyre chains are not permitted on the spare
wheel and tyres sizes 185/60 R 15,
185/65 R 15, 195/45 R 16 and 195/50 R 16.
Exception: Tyre chains on tyres of size
185/60 R 15 are permitted on Combo
Tramp/Arizona.
Tyre chains are generally permitted on
tyres of size 185/55 R 15.
Further information 3125. Wheels Wheel bolt tightening torque: 110 Nm.
Spare wheel
3
Depending on the version, the spare wheel
is designed for use as a temporary spare
wheel 3: the handling of the vehicle may
change if the spare wheel is used. Replace
a defective tyre as soon as possible,
balance the wheel and fit it to vehicle. Pay
attention to notes on this page and on
3125, 3135.
On vehicles with alloy wheels 3 the spare
wheel may have a steel rim.
The spare wheel can be fitted with a
smaller tyre
1) and a smaller rim than the
wheels fitted on the vehicle.
Tyre pressure (overpressure)The specified tyre pressure are valid for
cold tyres. The increased tyre pressure
resulting from extensive driving must not
be reduced. The tyre pressure specified on
the following pages apply to both summer
and winter tyres.
The spare wheel must always be filled with
the tyre pressure for a full load - see tables
on following pages.
Temporary spare wheel tyre pressure 3 –
see tables on the following pages.
Further information 3121 to 3125. 1)Country-specific version: The spare wheel is
only permitted for use as a temporary spare.

203
Index
Signal system ........................................... 13
Sliding doors ............................................ 27
Spare fuses ............................................. 145
Spare keys ................................................ 20
Spare wheel .................................... 134, 137
Speed .............................................. 108, 109
Fuel consumption ...................... 108, 109
Speedometer ............................................ 71
Starter switch ........................................... 16
Starting the engine ....................16, 21, 129
Self-help .............................................. 129
Steam jet cleaner ................................... 163
Steering column lock ......................... 16, 17
Steering wheel adjustment ....................... 6
Steering wheel remote control .......... 19, 90
Stowage compartments .............. 39, 63, 64
Sun visors .................................................. 65
System settings ........................................ 79TTachometer .............................................. 71
Tail lamps ................................................. 84
Bulb replacement ............................... 157
Tailgate ................................................ 2, 28
Technical data ....................................... 182
Telephone, see Mobile telephone .......... 91
Temperature regulation .......................... 94
Temporary spare wheel ................ 125, 135
The first 1000 km ................................... 106Tightening torque .......................... 141, 191
Time .......................................................... 77
Tools ....................................................... 136
Towing .................................................... 131
Towing equipment ................................ 126
Towing eye ..................................... 131, 133
Transmission, Easytronic
Driving programmes ......................... 102
Fault .................................................... 104
Interruption of power supply ............ 105
Kickdown ............................................ 103
Selector lever ........................................ 15
Winter programme ............................ 103
Transmission, manual ..................... 15, 105
Tread depth ........................................... 123
Trip odometer .......................................... 72
Triple information display ....................... 76
Turn signal lamps ................................ 7, 85
Turn signals
Bulb replacement ..............154, 156, 157
Tyre chains ............................................. 125
Tyre condition ........................................ 122
Tyre pressure ................................. 121, 191
Tyre repair kit ........................................ 142
UUnderbody wash ................................... 163
Units of measure ..................................... 81
Unleaded fuel ................................ 114, 184
VValve cap key ........................................ 121
Vehicle care ........................................... 160
Vehicle decommissioning ..................... 181
Vehicle identification number .............. 183
Vehicle keys, see Keys ............................ 20
Vehicle recommissioning ...................... 181
Vehicle tools .......................................... 136
Ventilation ............................................... 92
VIN,
see Vehicle Identification Number ..... 182