2010 OPEL COMBO fuel cap

73
Instruments
Picture no: 11688s.tif
Coolant temperature display
Coolant temperature gauge. For physical reasons, the engine
temperature gauge shows the coolant
temperature only if the coolant level is
adequate.
During operation the system is pressurised.
The temperature may therefore rise briefly
to over 100 C.
Picture no: 11689s.tif
Fuel gauge

Control indicator Y illuminates when the
level is low. Refuel immediately if the
control indicator begins to flash.
Never run the tank dry!
Because of the fuel remaining in the tank,
the amount of fuel required to fill the tank
may be less than the specified tank
capacity. Pointer in zone
at left= Engine operating
temperature not yet
reached
Pointer between
the zones= Normal operating
temperature
Pointer in right
zone (warning
zone)= Temperature too
high: Stop the
vehicle and switch
off the engine.
Danger to engine.
Check coolant level
immediately 3177.

111
Driving and operation
Picture no: 15829t.tif
Fuel filler cap
Only a Opel Genuine fuel filler cap provides
full functionality. Diesel-engined vehicles
have special fuel filler caps.
Refuelling Fuel filler neck at right rear side of vehicle.
Picture no: 11628s.tif
With the central locking system3, the tank
flap is unlocked together with the doors3
324.
Open the tank flap. To prevent damage,
the right-hand sliding door cannot be fully
opened if the tank flap is open.
Unlock the fuel filler cap with the ignition
key 3, unscrew and suspend from tank
flap.
The fuel tank has a limiting system which
prevents overfilling of the tank.
6
9 Warning
Before refuelling, switch off engine and
any external heaters with combustion
chambers 3 (identified by sticker on
tank flap). Switch off any mobile
phones.
Follow the operating and safety
instructions of the filling station when
refueling.
9 Warning
Fuel is flammable and explosive. No
smoking. No naked flames or sparks.
If you can smell fuel in your vehicle, have
the cause of this rectified immediately
by a workshop.

112 Driving and operationCorrect filling depends to a large extent on
proper operation of the fuel dispensing
pump:
1. Fully insert the pump nozzle and switch it
on.
2. After the automatic cut-off, the nominal
capacity of the fuel tank can be
obtained by topping up with two doses
of fuel. Make sure the nozzle is fully
inserted.
To close, place fuel filler cap in position and
turn, overcoming the resistance until the
ratchet on the cap engages audibly. Lock
the fuel filler cap with the ignition key 3.
Close fuel tank cover. Refuelling, natural gas 3
The fuel tank filler neck for natural gas and
petrol is located on the right rear side of the
vehicle.
Picture no: 12292t.tif
Remove the cap from the natural gas filler
neck.
The tank action must be fully completed,
e.g. bleeding the filler neck.
After refuelling, refit the cap. Caution
Wipe off any overflowing fuel
immediately.
9 Warning
Care must be taken when handling
natural gas!
Before refuelling, be sure to switch off
the engine and any auxiliary heater with
combustion chamber.
Natural gas is flammable and explosive.
Therefore, avoid naked flames and
sparks when handling or in the vicinity of
natural gas. Do not smoke! This also
applies where natural gas can only be
detected by its characteristic smell.
If there is a smell of natural gas in the
vehicle, have cause established
immediately by a workshop that is
authorised to maintain natural gas
vehicles and have the problem
remedied.
9 Warning
When refuelling vehicles with natural
gas, be sure to follow the operational
and safety regulations of the filling
station.
The gas tank must only be replenished
at filling stations that refuel with
temperature compensation with a
maximum output pressure of 250 bar.

122 Driving and operationAlways inflate the spare wheel 3 to the
pressure specified for full load.
Do not reduce tyre pressure when the tyres
are warm. Otherwise the pressure may
drop below the permissible minimum when
the tyres cool down.
After having checked the tyre pressure,
tighten the valve caps using the valve cap
key.
Incorrect inflation pressures will impair
safety, vehicle handling, comfort and fuel
economy and will increase tyre wear.
Picture no: 9358t.tif Picture no: 15941s.tif
Tyre condition, wheel condition
Drive over edges slowly and at right angles
if possible. Driving over sharp edges can
cause tyre and wheel damage. Do not trap
tyres on the kerb when parking.
Regularly check the wheels for damage.
Seek the assistance of a workshop in the
event of damage or unusual wear.
9 Warning
If the pressure is too low, this can result
in considerable tyre warm-up and
internal damage, leading to tread
separation and even to tyre blow-out at
high speeds.

182 Technical dataTechnical data
Picture no: 11679s.tif
Vehicle data The technical data is determined in
accordance with European Community
standards. We reserve the right to make
modifications. Specifications in the vehicle
documents always have priority over those
given in this Owner’s Manual.
The identification plate is affixed to the
front right door frame.
Picture no: 11724s.tif
In other versions the type plate is attached
to the right spring strut dome in the engine
compartment. Vehicle data ......................................... 182
Engine data.......................................... 184
Performance......................................... 185
Fuel consumption, CO
2-emissions ......
186
Fuel consumption, natural gas........... 186
Weights, payload and roof load ........ 189
Tyres ..................................................... 191
Capacities ............................................ 195
Dimensions ........................................... 196
Mounting dimensions of towing
equipment with fixed coupling
ball bar............................................... 197

195 Technical data
CapacitiesEngine oil
EngineZ 14 XEP Z 13 DTJ Z 17 DTH
Incl. filter [l] 3.5 3.5 5.0
Between MIN and MAX [l] 1.0 1.0 1.0
Fuel tank
EngineZ 14 XEP Z 13 DTJ Z 17 DTH
Petrol/diesel, nominal capacity [l] 52 52 52
Engine oil
EngineZ 16 YNG
Incl. filter [l]3.5
Between MIN and MAX [l]1.0
Fuel tank
EngineZ 16 YNG
Natural gas, nominal capacity [kg]
petrol, nominal capacity [l]17.5
1)
14
1)17.5 kg (average fill limit), corresponding to a tank volume of 108 l. Fill weight in kg is dependent on outside temperature, filling pressure and type of
tank system.

199
Index
CCapacities .............................................. 195
Car Pass .................................................... 20
Caravan/trailer towing .................. 106, 125
Care ........................................................ 160
Catalytic converter ............... 114, 118, 129
Central locking system ...................... 23, 24
Centre console lighting ........................... 88
Changeover inhibitor ............................. 114
Changing the remote control battery .... 24
Changing tyre/wheel type ..................... 121
Changing wheels ................................... 137
Child restraint system .............................. 53
Child safety locks ..................................... 27
Cigarette lighter ....................................... 61
Clock ......................................................... 72
Clutch operation ............................ 105, 107
CO
2 emissions ........................................ 186
Coin holder ............................................... 65
Cold start ................................................ 107
Contrast .................................................... 81
Control indicator
ABS (Anti-lock Braking System) ........ 119
Airbag ................................................... 59
Engine electronics .............................. 116
Exhaust ............................................... 115
Immobiliser ........................................... 21
Control indicators .............................. 12, 66
Belt tensioners ...................................... 50
EPS (Electric Power Steering) .............. 70
Coolant ................................................... 177Coolant level .......................................... 178
Coolant temperature display ................. 73
Coolant thermometer .............................. 73
Correcting time ........................................ 80
Coupling socket load ............................ 126
Courtesy lamp ......................................... 88
Courtesy lamps
Bulb replacement ...................... 158, 159
DDashboard, see Instrument panel ........... 9
Data .................................................. 20, 182
Date .......................................................... 77
Daytime running lights ............................ 84
Decommissioning .................................. 181
Demisting and defrosting
Windows ............................................... 96
With the air conditioning system ........ 98
Diesel fuel filter ...................................... 177
Diesel fuel system .................................. 128
Diesel particle filter ............37, 68, 107, 116
Dimensions ............................................. 196
Dipped beam ............................................. 7
Bulb replacement ...................... 151, 155
Display .............................................. 76, 100
Display instruments ................................. 71
Display mode ........................................... 82
Door locks ........................................ 20, 162
Driving abroad .............................. 110, 164
Headlamps ........................................... 89
Driving hints ........................................... 106
EEasytronic ................................................ 15
Driving programmes ......................... 102
Fault ................................................... 104
Interruption of power supply ............ 105
Kickdown ............................................ 103
Selector lever ....................................... 15
Winter programme ............................ 103
Economical driving ................................ 108
Electric power steering .................... 70, 106
Towing ................................................ 131
Electric windows ...................................... 36
Electrical system .................... 145, 180, 195
Electronic components .......................... 180
Electronic immobiliser ............................. 21
Ellipsoidal headlamp system ................ 155
Engine code ........................................... 184
Engine control indicator ....................... 116
Engine oil ....................................... 172, 175
Additives ............................................ 172
Topping up ........................................ 172
Viscosity ............................................. 172
Engine oil consumption ........ 106, 175, 184
Engine oil level ....................................... 175
Engine speed ......................................... 107
Engine wash ................................... 162, 163
Environmental protection ..................... 160
EPS .................................................... 70, 106
Exhaust control indicator ..................... 115
Exhaust gases ........................................ 116
Exhaust system ...................................... 106
Exterior mirrors ........................ 5, 34, 35, 37

200 IndexFFan ............................................................ 94
Fault .......................................................... 37
Filling station
Capacities ........................................... 195
Engine oil level ................................... 175
Fuel ............................................. 110, 184
Opening the bonnet .......................... 128
Tyre pressure ...................................... 191
Vehicle data ............................... 182, 183
Windscreen washer system ............... 180
First-aid kit ............................................. 133
Flat tyre .................................................. 142
Fog lamps ................................................ 86
Bulb replacement ............................... 156
Fog tail lamp ............................................ 86
Bulb replacement ............................... 157
Foot brake ...................................... 118, 120
Front passenger airbag .......................... 56
Fuel ................................................. 110, 184
Fuel consumption ......... 108, 110, 185, 186
Fuel filter ................................................. 177
Fuel gauge ......................................... 73, 74
Fuel level ................................................... 73
Fuel selection button ............................. 113
Fuel system, diesel ................................. 128
Fuse remover ......................................... 145
Fuses ....................................................... 145
GGas type
H gas .......................................... 110, 188
L gas ................................................... 110
Gears ................................................ 15, 105
Generator, see Alternator ....................... 69
Genuine Opel Parts and Accessories ... 174
Glasses compartment ............................. 63
Glove compartment ................................ 63
Graphical information display ............... 76
Gross vehicle weight .............................. 189
Gross vehicle weight rating .................. 189HHalogen headlamp system .................. 151
Hand brake ................................ 16, 17, 120
Hazard warning lamps ........................... 86
Head restraints .................................. 40, 41
Headlamp flash ....................................... 85
Headlamp range adjustment ................. 87
Headlamp switch ................................ 6, 84
Headlamp washer system ........ 13, 83, 180
Headlamps ................................................ 6
Daytime running lights ........................ 84
Driving abroad ..................................... 89
Fog lamps ............................................ 86
Reversing lamps .................................. 85
Warning device .................................... 82
Headlights
Changing bulbs ......................... 151, 155
Heated exterior mirrors ............... 14, 35, 37Heated front seats .................................. 40
Heated rear window ......................... 14, 37
Heating .............................................. 92, 95
Seats ..................................................... 40
With the air conditioning system ....... 92
Height adjustment
Seat belts ............................................. 52
Steering wheel ........................................6
High pressure jet cleaner ...................... 163
Horn .......................................................... 13
IIdentification plate ........................ 182, 183
Idling ...................................................... 105
Ignition logic ............................................ 82
Ignition switch .......................................... 16
Ignition system .............................. 174, 180
Immobiliser .............................................. 21
Information display ................................. 76
Infotainment system ......................... 76, 90
Instrument illumination ........................... 87
Bulb replacement .............................. 159
Instrument panel ........................................9
Instruments .............................. 9, 66, 71, 72
Interior mirror ....................................... 6, 35
Interruption of power supply
Easytronic ........................................... 105
Electric windows .................................. 37JJack ................................................ 136, 139
Jump leads ............................................. 129