2010 OPEL COMBO service indicator

118 Driving and operationMaintenance
Have all maintenance work carried out at
the specified intervals. We recommend
that you entrust this work to your Opel
Partner, who has proper equipment and
trained personnel available. Electronic
testing systems permit rapid diagnosis and
remedy of faults. This way you can be
certain that all components of the vehicle’s
electrical, injection and ignition systems
operate correctly, that your vehicle has a
low level of pollutant emission and that the
catalytic converter system will have a long
service life.
You are thereby making an important
contribution towards keeping the air clean
and compliance with emissions legislation.
Checking and adjustment of the fuel-
injection and ignition systems is part of the
scope of inspection. For this reason you
should have all maintenance work carried
out at the intervals specified in your Service
and Warranty Booklet.
Picture no: 11629s.tif
Hydraulic brake system The foot brake comprises two independent
brake circuits.
If a brake circuit fails, the vehicle can still be
braked using the other brake circuit.
However, the brake pedal must be
depressed a considerable way before any
braking effect occurs, and much more
force is required. The braking distance is
longer. Contact a workshop for assistance
before continuing to drive. To ensure the full pedal travel can be
utilised, especially in case of a fault in one
of the brake circuits, there must be no mats
in the vicinity of the pedals 3107.
When the engine is not running, the
support of the brake servo unit disappears
once the brake pedal has been depressed
once or twice. Braking effect is not
reduced, but braking requires significantly
greater force. This is especially important
to bear in mind when towing.
The brake fluid level should be checked
regularly. If the brake fluid level is too low
and the hand brake is not applied, control
indicator R on the instrument panel lights
up 369.

167 Opel Service, maintenance
⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
302
603
904
1205
150
Visually inspect steering bellows, track rods and axle drive xxxxx
Check track-rod ends and suspension ball joints xxxxx
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not out
of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and not
out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
For Germany only: carry out emissions inspection (AU), general inspection (HU) First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually

170 Opel Service, maintenance⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
Visually inspect steering bellows, track rods and axle drive x x x x x
Check track-rod ends and suspension ball joints x x x x x
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not
out of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and
not out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually

201
Index
KKey
Extending ............................................. 20
Ignition lock .......................................... 16
Locking doors ...........................20, 23, 24
Remove ................................................. 17
Starting ........................................... 16, 21
Starting the engine .............................. 16
Keys ...................................................... 2, 20LLanguage selection ................................. 80
Lashing eyes ............................................ 44
Leaf doors ...................................... 3, 22, 29
Light switch ................................................ 6
Lighting ................................................ 6, 84
Driving abroad ..................................... 89
Load compartment
Loading ................................................ 47
Load compartment grille ........................ 46
Loading ............................................ 47, 126
Loading the vehicle ................................. 47
Locking doors ..............................20, 23, 24
Locking from the inside ..................... 22, 25
Locking the doors .......................... 2, 22, 24
Locks ....................................................... 162
Lubricants .............................................. 175Luggage compartment .......................... 28
Bulb replacement .............................. 158
Cover .................................................... 44
Extension .............................................. 42
Lashing eyes ........................................ 44
Lighting ................................................ 88
Loading ................................ 47, 126, 189
Locking ................................................. 28
Luggage compartment cover ................ 44
MMain beam ........................................... 7, 85
Bulb replacement .............................. 152
Control indicator .................................. 68
Maintenance
Air conditioning system ....................... 99
Antifreeze protection ........................ 177
Brake fluid .......................................... 179
Brakes ................................................. 178
Catalytic converter ............................ 118
Engine oil ............................................ 175
Fuel consumption .............................. 109
Tyre pressure ...................................... 121
Tyres ........................................... 122, 123
Manual transmission ............................. 105
Manual transmission, see Transmission 15
Mirrors ............................................ 6, 34, 35
Misted windows ................................. 96, 98
Mobile telephone ..................................... 91
Muffler, see Exhaust system ................. 116
NNatural gas .............................. 74, 110, 113
Number plate lamps
Bulb replacement .............................. 158
Number plate lighting .......................... 158OOctane numbers .................................... 184
Odometer ................................................. 71
Oil ........................................................... 172
Additives ............................................ 172
Topping up ........................................ 172
Viscosity ............................................. 172
Oil consumption ............................ 175, 184
Oil level ................................................... 175
Oil pressure .............................................. 67
Opel Service ........................................... 164
Operating temperature ........................ 107
Outside temperature gauge .................. 76
Overrun .......................................... 107, 109