2010 OPEL COMBO oil pressure

170 Opel Service, maintenance⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
Visually inspect steering bellows, track rods and axle drive x x x x x
Check track-rod ends and suspension ball joints x x x x x
⊕
Change brake and clutch fluid (manual transmission automated) every 2 years
Undo wheel mounting and tighten to 110 Nm torque
xx During assembly, lightly lubricate wheel bolt tapers with grease or oil
Check tyre condition; check and correct tyre pressures (including the spare wheel)
With tyre inflation system, check the set to make sure that it is complete and not
out of date. Replace sealant bottle every 4 years
⊕
Annual service check when the annual mileage is more than 20,000 km
Visually inspect the first-aid kit (present and stowed in the right place, intact and
not out of date), lashing eyes and warning triangleevery 2 years
Check and correct headlamp aiming (including auxiliary headlamps) x x
⊕o
Lubricate door hinges, door brakes, lock cylinders, strikers, bonnet closure and
tailgate hinges.xx
Road test, final inspection (check steering column lock, ignition switch, instruments
and control indicators, entire brake system, steering, air conditioning system, engine,
body and chassis), reset service interval display using TECH 2xxxxx
⊕
Carry out gas system test (GAP) and note it in the Service and Warranty Booklet First after 3 years and then every
2 years thereafter
With commercial passenger transport, taxis, ambulances, hired vehicles, etc. annually

181
Opel Service, maintenance
Laying the vehicle up for a long
period of time If the vehicle is to be laid up for several
months, the following work should be
undertaken to prevent damage.
zWash and wax the vehicle 3161.
zHave the wax in the engine
compartment and underbody checked.
zClean and preserve rubber seals.
zChange engine oil.
zCheck anti-freeze and corrosion
protection 3177.
zCheck the coolant level; top up
anti-freeze if necessary 3178.
zDrain the windscreen washer system.
zIncrease tyre pressure to the value
specified for full load 3121, 3191. zPark the vehicle in dry and
well-ventilated place. With manual
transmission select first or reverse gear;
with manual transmission automated 3
move the selector lever to the centre
position before switching the ignition off.
Use chocks or the like to prevent the
vehicle from rolling.
zDo not apply hand brake.
zDisconnect the clamp from the negative
terminal of the vehicle battery.
Putting the vehicle back into
servicePerform the following work before
recommissioning the vehicle:
zConnect the clamp to the negative
terminal of the vehicle battery.
zCheck tyre pressure 3121, 3191.
zTop up the windscreen washer system
3180.
zCheck engine oil level 3175.
zCheck coolant level 3178.
zFit the number plate if necessary.

195 Technical data
CapacitiesEngine oil
EngineZ 14 XEP Z 13 DTJ Z 17 DTH
Incl. filter [l] 3.5 3.5 5.0
Between MIN and MAX [l] 1.0 1.0 1.0
Fuel tank
EngineZ 14 XEP Z 13 DTJ Z 17 DTH
Petrol/diesel, nominal capacity [l] 52 52 52
Engine oil
EngineZ 16 YNG
Incl. filter [l]3.5
Between MIN and MAX [l]1.0
Fuel tank
EngineZ 16 YNG
Natural gas, nominal capacity [kg]
petrol, nominal capacity [l]17.5
1)
14
1)17.5 kg (average fill limit), corresponding to a tank volume of 108 l. Fill weight in kg is dependent on outside temperature, filling pressure and type of
tank system.

200 IndexFFan ............................................................ 94
Fault .......................................................... 37
Filling station
Capacities ........................................... 195
Engine oil level ................................... 175
Fuel ............................................. 110, 184
Opening the bonnet .......................... 128
Tyre pressure ...................................... 191
Vehicle data ............................... 182, 183
Windscreen washer system ............... 180
First-aid kit ............................................. 133
Flat tyre .................................................. 142
Fog lamps ................................................ 86
Bulb replacement ............................... 156
Fog tail lamp ............................................ 86
Bulb replacement ............................... 157
Foot brake ...................................... 118, 120
Front passenger airbag .......................... 56
Fuel ................................................. 110, 184
Fuel consumption ......... 108, 110, 185, 186
Fuel filter ................................................. 177
Fuel gauge ......................................... 73, 74
Fuel level ................................................... 73
Fuel selection button ............................. 113
Fuel system, diesel ................................. 128
Fuse remover ......................................... 145
Fuses ....................................................... 145
GGas type
H gas .......................................... 110, 188
L gas ................................................... 110
Gears ................................................ 15, 105
Generator, see Alternator ....................... 69
Genuine Opel Parts and Accessories ... 174
Glasses compartment ............................. 63
Glove compartment ................................ 63
Graphical information display ............... 76
Gross vehicle weight .............................. 189
Gross vehicle weight rating .................. 189HHalogen headlamp system .................. 151
Hand brake ................................ 16, 17, 120
Hazard warning lamps ........................... 86
Head restraints .................................. 40, 41
Headlamp flash ....................................... 85
Headlamp range adjustment ................. 87
Headlamp switch ................................ 6, 84
Headlamp washer system ........ 13, 83, 180
Headlamps ................................................ 6
Daytime running lights ........................ 84
Driving abroad ..................................... 89
Fog lamps ............................................ 86
Reversing lamps .................................. 85
Warning device .................................... 82
Headlights
Changing bulbs ......................... 151, 155
Heated exterior mirrors ............... 14, 35, 37Heated front seats .................................. 40
Heated rear window ......................... 14, 37
Heating .............................................. 92, 95
Seats ..................................................... 40
With the air conditioning system ....... 92
Height adjustment
Seat belts ............................................. 52
Steering wheel ........................................6
High pressure jet cleaner ...................... 163
Horn .......................................................... 13
IIdentification plate ........................ 182, 183
Idling ...................................................... 105
Ignition logic ............................................ 82
Ignition switch .......................................... 16
Ignition system .............................. 174, 180
Immobiliser .............................................. 21
Information display ................................. 76
Infotainment system ......................... 76, 90
Instrument illumination ........................... 87
Bulb replacement .............................. 159
Instrument panel ........................................9
Instruments .............................. 9, 66, 71, 72
Interior mirror ....................................... 6, 35
Interruption of power supply
Easytronic ........................................... 105
Electric windows .................................. 37JJack ................................................ 136, 139
Jump leads ............................................. 129

201
Index
KKey
Extending ............................................. 20
Ignition lock .......................................... 16
Locking doors ...........................20, 23, 24
Remove ................................................. 17
Starting ........................................... 16, 21
Starting the engine .............................. 16
Keys ...................................................... 2, 20LLanguage selection ................................. 80
Lashing eyes ............................................ 44
Leaf doors ...................................... 3, 22, 29
Light switch ................................................ 6
Lighting ................................................ 6, 84
Driving abroad ..................................... 89
Load compartment
Loading ................................................ 47
Load compartment grille ........................ 46
Loading ............................................ 47, 126
Loading the vehicle ................................. 47
Locking doors ..............................20, 23, 24
Locking from the inside ..................... 22, 25
Locking the doors .......................... 2, 22, 24
Locks ....................................................... 162
Lubricants .............................................. 175Luggage compartment .......................... 28
Bulb replacement .............................. 158
Cover .................................................... 44
Extension .............................................. 42
Lashing eyes ........................................ 44
Lighting ................................................ 88
Loading ................................ 47, 126, 189
Locking ................................................. 28
Luggage compartment cover ................ 44
MMain beam ........................................... 7, 85
Bulb replacement .............................. 152
Control indicator .................................. 68
Maintenance
Air conditioning system ....................... 99
Antifreeze protection ........................ 177
Brake fluid .......................................... 179
Brakes ................................................. 178
Catalytic converter ............................ 118
Engine oil ............................................ 175
Fuel consumption .............................. 109
Tyre pressure ...................................... 121
Tyres ........................................... 122, 123
Manual transmission ............................. 105
Manual transmission, see Transmission 15
Mirrors ............................................ 6, 34, 35
Misted windows ................................. 96, 98
Mobile telephone ..................................... 91
Muffler, see Exhaust system ................. 116
NNatural gas .............................. 74, 110, 113
Number plate lamps
Bulb replacement .............................. 158
Number plate lighting .......................... 158OOctane numbers .................................... 184
Odometer ................................................. 71
Oil ........................................................... 172
Additives ............................................ 172
Topping up ........................................ 172
Viscosity ............................................. 172
Oil consumption ............................ 175, 184
Oil level ................................................... 175
Oil pressure .............................................. 67
Opel Service ........................................... 164
Operating temperature ........................ 107
Outside temperature gauge .................. 76
Overrun .......................................... 107, 109