2010 Lancia Delta wiper fluid

CARE AND MAINTENANCE215
5
Scheduled maintenance ................................................................. 216
Scheduled maintenance plan ......................................................... 217
Periodic checks .............................................................................. 221
Demanding use of the car............................................................... 221
Checking fluid levels ..................................................................... 223
Air filter ........................................................................................ 230
Pollen filter ................................................................................... 230
Diesel fuel filter ............................................................................. 230
Battery .......................................................................................... 231
Wheels and tyres ........................................................................... 234
Rubber hoses ................................................................................ 236
Windscreen wiper/rear wiper ......................................................... 236
Bodywork...................................................................................... 239
Interiors ......................................................................................... 242
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 215

CARE AND MAINTENANCE217
5
SCHEDULED SERVICING PLAN
Petrol versions
Thousands of kilometres
Check tyre condition/wear and adjust pressure if required
Check lighting system operation (headlights, direction indicators, hazard lights,
passenger compartment lights, boot lights, instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check the position/wear of the windscreen/rearscreen wiper blades
Check condition and wear of front disc brake pads and
brake pad wear indication
Check rear disc brake pad condition and wear
Visually inspect the condition of: bodywork, underbody
protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of bonnet and boot locks and
linkage cleanness and lubrication;
Check and top up, if required, fluid levels (engine coolant, brake/hydraulic
clutch fluid, windscreen washer fluid, battery fluid, etc)
Check the handbrake lever stroke and adjust it, if necessary
visually inspect the condition of the accessory drive belt
Visually inspect the condition of the toothed timing drive belt30 60 90 120 150 180
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●● ●●●
●●
●●
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 217

CARE AND MAINTENANCE219
5
Diesel versions
Thousands of kilometres
Check tyre condition/wear and adjust pressure if required
Check lighting system operation (headlights, direction indicators, hazard lights,
passenger compartment lights, boot lights, instrument panel warning lights, etc.)
Check windscreen wiper/washer operation
Check the position/wear of the windscreen/rearscreen wiper blades
Check condition and wear of front disc brake pads and
brake pad wear indication
Check rear disc brake pad seal condition and wear
Visually inspect the condition of: bodywork, underbody
protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.)
Check cleanness of bonnet and boot locks and
linkage cleanness and lubrication
Check and top up, if required, fluid levels
(engine coolant, brake/hydraulic clutch fluid, windscreen washer fluid, battery fluid, etc)
Check the handbrake lever stroke and adjust it, if necessary
Check and if necessary adjust the auxiliary
drive belts (excluding engines equipped with automatic tensioners)
Check exhaust fumes/emissions
Visually inspect the condition of the auxiliary drive belt35 70 105 140 175
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●●
●● ● ● ●
●●
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 219

CARE AND MAINTENANCE221
5
REGULAR INSPECTIONS
Every 1,000 km or before long journeys, check and top
up if required:
❍engine coolant fluid level;
❍brake fluid level;
❍windscreen washer fluid level;
❍tyre pressure and condition;
❍operation of lights (headlights, direction indicators,
hazard lights, etc.);
❍operation of the windscreen wiper/washer system, po-
sition and wear of windscreen/rearscreen wiper blades.
Every 3,000 km check the following and top-up, if re-
quired: engine oil level.
You are recommended to use PETRONAS LUBRICANTS
products, designed and produced specifically for Lancia
cars (see table “Capacities” in chapter “6”).
DEMANDING USE OF THE CAR
If you use the vehicle mainly under one of the following
especially heavy conditions:
❍trailer or caravan towing;
❍dusty roads;
❍repetitive short distances (less than 7-8 km) with ex-
ternal temperatures below zero;
❍frequently idling the engine or long distances at low
speed driving (e.g. door-to-door deliveries) or long term
inactivity;
❍urban routes.
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 221

236CARE AND MAINTENANCE
RUBBER HOSES
With regards to the maintenance of the brake system and
fuel system rubber hoses, carefully follow the “Sched-
uled Service Plan” in this section.
Ozone, high temperatures and prolonged lack of fluid in
the system may cause hardening and cracking of the hoses,
with possible leaks. Careful inspections are therefore nec-
essary.
WINDSCREEN/REARSCREEN
WIPERS
BLADES
Periodically clean the rubber part using special products;
TUTELA PROFESSIONAL SC35 is recommended.
Replace the blades if the rubber edge is deformed or worn.
In all cases, it is advisable to replace them approximate-
ly once a year.
A few simple precautions can reduce the possibility of
damage to the blades:
❍make sure that the rubber part is not stuck to the wind-
screen at sub-zero temperatures. Use an antifreeze
product to release it if required;
❍remove any snow from the window: this will avoid
overstressing the electrical motor in addition to pro-
tecting the blades;
❍do not operate the windscreen and the rear screen
wipers on dry glass.
Driving with worn wiper blades is a serious
hazard, because visibility is reduced in bad
weather.
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 236

238CARE AND MAINTENANCE
SPRAY NOZZLES
Windscreen washer fig. 7
If the jet of fluid is inadequate, firstly check that there is
fluid in the reservoir: see “Checking fluid levels” in this
section).
Then check that the nozzle holes are not clogged, if nec-
essary use a needle.
The windscreen jets are directed by adjusting the angle
of the nozzles.
Fluid jets should be directed at about 1/3 height from
the window upper edge.
IMPORTANT In versions with a sunroof, make sure that
the sunroof is closed before operating the front jets.
fig. 7L0E0099m
Rear window wiper fig. 8
Rear window washer jets are fixed.
The nozzle holder is on the rear window.
fig. 8 L0E0100m
215-242 Delta 3ed gb 11-11-2009 12:14 Pagina 238

Gearboxes and
differentials manual
(1.6 Multijet versions)
Manual gearboxes and
differentials (petrol ver-
sions and diesel versions
excluding 1.6 Multijet)
Constant velocity joints
differential-side
Constant velocity joints
wheel-side
Hydraulic brakes and
hydraulically operated
clutches
Cooling circuits propor-
tions of use: 50% water
50% PARAFLU UP (
❑)
To be mixed with diesel
(25 cc per 10 litres)
To be used diluted or
undiluted in wind-
screen/rear window
washer/wiper systems
TECHNICAL DATA263
6
Synthetic lubricant grade SAE 75W-85.
Exceeds API GL-4 PLUS specifications.
FIAT Classification 9.55550-MX3
Synthetic-based lubricant, grade SAE 75W-85.
Exceeds API GL-4 specifications.
FIAT Classification 9.55550-MZ1
Grease for constant velocity joints with low
friction coefficient. Consistency N.L.G.I. 0-1.
FIAT Classification 9.55580
Molybdenum disulphide grease, for use at
high temperatures. Consistency N.L.G.I. 1-2.
FIAT Classification 9.55580
Synthetic fluid for braking and clutch systems
Exceeds specifications: FMVSS n° 116 DOT 4, ISO
4925,SAE J 1704. FIAT Classification 9.55597
Red, protective with antifreeze action, based on inhib-
ited monoethyl glycol with organic formula. Exceeds
CUNA NO 956-16, ASTM D 3306 specifications.
Additive for diesel fuel, protecting Diesel engines.
Mixture of alcohols and surfactants.
Exceeds CUNA NC 956-11 specification.
FIAT Classification 9.55522TUTELA CAR TECHNYX Contractual Technical
Reference N° F010.B05
TUTELA CAR MATRYX Contractual Technical
Reference N°F108.F02
TUTELA STAR 700
Contractual Technical
Reference N°F701.C07
TUTELA ALL STAR
Contractual Technical
Reference N°F702.G07
TUTELA TOP 4
Contractual Technical
Reference N°F001.A93
PARAFLU UP (
●)
Contractual Technical
Reference N°F101.M01
TUTELA DIESEL ARTContractual Technical
Reference N°F601.L06
TUTELA
PROFESSIONALSC 35
Contractual Technical
Reference N° F201.D02 Brake
fluid
Protective
for radiators
Additive for
diesel fuel
Liquid for
windscreen
and rearscreen
washers
(●) IMPORTANT Do not use fluids with different specifications for topping up or mixing.
(❑) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP and demineralised water.
Lubricants
for petrol
engines Use Qualitative specifications of fluids and lubricants Fluids and lubricants Applications
for correct vehicle operation original
243-266 Delta 3ed gb 11-11-2009 12:16 Pagina 263