2010 FIAT QUBO drive

Thousands of kilometres 30 60 90 120 150 180
Top up fluid levels (engine coolant, brake fluid, battery, wind-
screen washer, etc.)●●●●●●
Check engine control system operation (through diagnostic inter-
face)●●●●●●
Check mechanical gearbox fluid●●
Check cleanliness of sliding side door lower guides (or every 6
months)●●●●●●
Change engine oil and replace oil filter (or every 24 months)●●●●●●
Change brake fluid (or every 24 months)●●●
Change pollen filter (or 12 months)●●●●●●
Change engine oil and filter every 12 months if the vehicle is driven mainly in towns.
169
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

REGULAR CHECKS
Every 1,000 km or before long journeys, check and, if
necessary, top up:
❒engine coolant level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre inflation pressure and condition;
❒operation of lighting system (headlamps, direction
indicators, hazard warning lights, etc.);
❒operation of screen wash/wipe system and
positioning/wear of windscreen/rear window wiper
blades.
Check and top up, if required, the engine oil level
every 3,000 km.
You are recommended to use PETRONAS
LUBRICANTS products, which have been designed
and produced specifically for Fiat vehicles (see
“Capacities” table in the “Technical specifications”
section).
HEAVY USAGE OF THE VEHICLE
Should prevailing use of the vehicle be under one of
the following specially heavy conditions:
❒towing a trailer or caravan;
❒dusty roads;
❒short, repeated journeys (less than 7-8 km) at
sub-zero outside temperatures;
❒engine often idling, or driving long distances at low
speed (e.g. door to door deliveries) or long period
of idleness;
❒urban trips;
perform the following inspections more frequently
than shown on the Scheduled Servicing Plan:
❒check front disc brake pad condition and wear;
❒check cleanliness of bonnet and boot locks,
cleanliness and lubrication of linkage;
❒visually inspect the conditions of: engine, gearbox,
transmission, pipes and tubes (exhaust - fuel -
brakes), rubber parts (boots, sleeves, bushes, etc.);
❒check battery charge status and fluid (electrolyte)
level (refer to "Battery - Check state of charge
and electrolyte level" paragraph in this chapter);
❒visually inspect condition of the auxiliary drive
belts;
170
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

ENGINE CODES - BODYWORK
VERSIONS
Version Engine code
1.3 Multijet199A2000
The following body version code and key are an
example that may be applied to all body version
codes.
Example:
225BXB1AAX
Key :
225Model
BBody
XBEngine
1Traction
ATransmission
AXVersionBODY
AQubo M1 (5 seat)
CQubo N1 (4 seats)
ENGINES
XA1.4 petrol Euro 4
XB1.3 Multijet 75 HP Euro 4
XCMethane
XD1.3 Multijet 75 HP Euro 5
XE1.3 Multijet 95 HP Euro 5
XF1.4 petrol Euro 5
DRIVE
1Front
TRANSMISSION
AMechanical gearbox
1Comfort/Dualogic gearbox
190
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

FUEL SYSTEM
Versions Fuel system
1.3 Multijet 75 HPElectronically controlled Common Rail Multijet direct injection with turbocharger and
intercooler
WARNING
Modifications or repairs to the fuel supply system that are not carried out properly or do not
tak
e the technical specifications of the system into account can cause malfunctions leading
to the risk of fire.
TRANSMISSION
Versions Gearbox Clutch Traction
1.3 Multijet 75 HPFive forward speed plus
reverse with synchronizers
for the engagement of the
forward speedsHydraulic drive Front
192
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

WEIGHTS
Weights (kg)1.3 Multijet 75 HP Euro 4 class 1
(o)
N1
"Minimum"
versions (4
seats)N1 "Maximum" versions (4 seats) M1 versions
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1205 1300 1200
Payload
(*)including the driver:550 455 510
Payload
(*)excluding the driver:475 - 440
Maximum permitted loads
(**)
- front axle: 950 950 950
- rear axle: 950 950 950
- total: 1755 1755 1710
Towable loads
- trailer with brakes: 600 600 600
- trailer without brakes: 400 400 400
(o)For versions/markets, where provided
(*)N1 CATEGORY: for the full optional versions (110 kg) the payload is gradually reduced to 500 kg.
(**)Loads not to be exceeded. The user is responsible for arranging goods in the boot and/or on the load carrying platform within the
maximum permitted loads.
201
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

Weights (kg)1.3 Multijet 75 HP Euro 4 class 2
N1 "Minimum"
versions (4 seats)N1 "Maximum" versions (4 seats)
Unladen weight (with all fluids, fuel
tank filled to 90% and without
optional equipment)1235 1355
Payload
(*)including the driver:565 445
Payload
(*)excluding the driver:490 370
Maximum permitted loads
(**)
- front axle: 950 950
- rear axle: 960 960
- total: 1800 1800
Towable loads
- trailer with brakes: 600 600
- trailer without brakes: 400 400
Maximum load on the roof (with roof
rack bars)
(***)100 100
Maximum load on ball joint (trailer
with brake):60 60
(*)N1 CATEGORY: for the full optional versions (120 kg) the payload is gradually reduced to 445 kg.
(**)Loads not to be exceeded. The user is responsible for arranging goods in the boot and/or on the load carrying platform within the
maximum permitted loads.
(***)Including weight of any carrying systems fitted (Lineaccessori Fiat bars/box).
NoteTrekking versions have the same capacities as the other versions.
203
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICA
TIONS
INDEX

Conditions of use ...................... 117
Controls........................................ 53
Coupling the tow ring............... 164
Cylinder replacement ............... 142
Dashboard ................................... 3
Dead lock ..................................... 8
Dead Lock .................................... 8
Dimensions ................................. 199
Dipped beam headlights ............ 45
Dipped/main beam
headlights (changing a bulb)... 147
Dipped/main beam
headlights ................................... 147
Direction indicators
(changing a bulb) .............. 147-149
Direction indicators ............ 46-147
– Left direction indicator
warning light .......................... 130
– Right-hand indicator
warning light .......................... 130
Door open .................................. 124
Doors (unlocking/locking) ........ 58
Double rear swing doors .......... 63
DPF (particulate filter) .............. 90
DPF (particulate trap)
cleaning underway warning
light ............................................. 125DPF (particulate trap)
(cleaning underway
warning light) ............................ 125
Driver's seat arm rest ................ 54
Driving style ................................ 116EBD fault warning light............ 123
EBD (fault warning light) .......... 123
EBD system .................................. 76
Emergency starting.................... 112
Engine bay fuse box ................... 156
Engine codes ............................... 190
Engine compartment fuse
box table .................................... 159
Engine coolant fluid ................... 174
Engine coolant fluid
(warning light)........................... 122
Engine coolant fluid warning
light ............................................. 122
Engine coolant temperature
gauge............................................ 14
Engine ........................................... 191
Engine marking ........................... 189
Engine oil ..................................... 173
Engine oil (low pressure
warning light) ............................ 123
EOBD system .............................. 81
ESP (system) ................................ 77ESP/Traction Plus fault
warning light.............................. 123
ESP/Traction Plus (fault
warning light) ............................ 123
Extending the boot .................... 66
Exterior light fault warning
light ............................................. 128
Exterior lights .............................. 45
Exterior lights (warning
light) ............................................ 128
Fiat CODE system .................... 5
Fiat CODE vehicle
protection system fault
warning light.............................. 127
Fiat CODE (vehicle
protection system fault
warning light) ............................ 127
Fix&Go automatic quick
tyre repair kit ........... 138-140-142
Flashing the headlights ............... 46
Fluids and lubricants.................. 205
Fog lights (changing a bulb)...... 148
Fog lights ................................ 54-148
– Warning light ......................... 129
Fog lights warning light ............. 129
Follow Me Home ........................ 47
Front airbags ............................... 105
– Front airbag driver's side .... 106
223
KNOW YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN EMERGENCY
SERVICING AND
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX