2010 FIAT PUNTO EVO screen

F0U0291mfig. 213
SPRAY NOZZLES
Windscreen washer fig. 214
If the jet is not coming out, firstly check that there is flu-
id in the reservoir (see “Checking levels” in this section).
Then check that the nozzle holes are not clogged; use
a needle to unblock them if necessary.
230
F0U0290mfig. 212
Replacing the windscreen wiper blades fig. 212
How to remove the blade:
❒lift the arm A off the windscreen;
❒turn blade B 90° around pin C, located at the end of the
wiper arm;
❒ remove the blade from the pin C.
How to insert the blade:
❒fit pin C into the hole located in the middle of the
blade B;
❒refit the arm with the blade on the windscreen.
Changing the rear window wiper blade fig. 213
Proceed as follows:
❒raise the cover A and remove the arm from the car,
slackening the nut B that fastens it to the pivot pin;
❒fit the new arm, positioning it correctly, and fully tight-
en the nut;
❒ lower the cover.
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
211-234 PUNTO FL EN 4ed 18-01-2010 12:28 Pagina 230

233
INTERIOR
Check regularly that water is not trapped under the mats
(due to drops from shoes, umbrellas, etc.), as this could
cause the sheet metal to rust.
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
Detergents cause water pollution. The ve-
hicle should be washed only in areas
equipped for collecting and purifying the
liquids used in the washing process.
Windows
Use specific detergents to clean the windows.
Also use clean cloths to avoid scratching the glass or al-
tering the transparency.
IMPORTANT Wipe the rear window gently with a cloth
in the direction of the filaments to avoid damaging the heat-
ing device.
Engine compartment
Wash the engine compartment thoroughly at the end of
every winter. Be careful not to direct the jet of water on-
to electronic control units. Adequately protect the up-
per air vents to prevent damage to the windscreen wiper
motor. Have this operation performed at a specialised
workshop.
IMPORTANT The washing should take place with the en-
gine cold and the ignition key in the STOP position. After
the wash, make sure that the various protective devices
(e.g. rubber caps and guards) have not been removed or
damaged.
Front headlights
IMPORTANT Never use aromatic substances (e.g. petrol)
or ketenes (e.g. acetone) for cleaning the plastic lenses of the
front headlights.
Never use flammable products, such as
petroleum ether or modified petrol, to
clean inside the car. The electrostatic charges
which are generated by rubbing during cleaning
may cause a fire.
WARNING
Do not keep aerosol cans in the vehicle:
these could explode. Aerosol cans must
not be exposed to temperatures exceeding 50°C.
When the vehicle is exposed to sunlight, the tem-
perature inside can greatly exceed this value.
WARNING
211-234 PUNTO FL EN 4ed 18-01-2010 12:28 Pagina 233

KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
250
1.3
Multijet
75HP
–
–
45
5 ÷ 7
7.4 (E4)
6.7 (E5)
–
–
3.0
3.2
1.7 (
▲)
0.5
2.2
4.5
1.4
45
5 ÷ 7
–
–
5.3
2.4
2.6
–
–
1.5 (
▲)
0.5
2.2
4.5
1.2
45
5 ÷ 7
–
–
5.3
2.4
2.6
–
–
1.5 (
▲)
0.5
2.2
4.5
1.3
Multijet
90HP-95HP
–
–
45
5 ÷ 7
7.4 (E4)
6.7 (E5)
–
–
3.0
3.2
1.7 (
▲)
2.0 (❍) (*)
0.5
2.2
4.5
1.6
Multijet
120HP
–
–
45
5 ÷ 7
5.6
–
–
4.3
4.6
2.0 (
❍)
0.5
2.2
4.5
1.4Multi Air
45
5 ÷ 7
–
–
5.3
3.1
3.4
–
–
1.65 (
▲)
0.5
2.2
4.5
1.4 Turbo
Multi Air
45
5 ÷ 7
–
–
6.0
3.1
3.5
–
–
1.7 (
▲)
0.5
2.2
4.5
Recommended fuels
and original lubricants
Unleaded petrol with no less
than 95 R.O.N.
(EN 228 Specification)
Diesel for motor vehicles
(EN590 Specification)
50-50 mixture of water and
PARAFLU
UPliquid (❒)
SELENIA K P.E.
SELENIA WR P.E.
TUTELA CAR
TECHNYX(▲)
TUTELA CAR
MATRYX (
❍)
TUTELA TOP 4
Mixture of water and
TUTELA
PROFESSIONAL SC 35
CAPACITIES
Fuel tank: litres
including a reserve of: litres
Fuel tank: litresincluding a reserve of: litres
Engine cooling
system: litres
Engine sump: litresEngine sump and filter: litres
Engine sump: litres
Engine sump and filter: litres
Gearbox/differential
casing: kg
Hydraulic brake circuit: kg
Windscreen/rear window
washer fluid reservoir: litres
with headlight washers: litres
(*) Version with six-speed gearbox
(
❒) For particularly harsh climate conditions, a mixture of 60% PARAFLUUPand 40% distilled water is recommended.
235-258 PUNTO FL EN 4ed 18-01-2010 12:28 Pagina 250

KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
252
Lubricants and
greases
for drive
transmission
system
Brake liquid
Fuel additive
Windscreen/
rear window
washer fluid
Mechanical gearbox
and differential (petrol
versions and 1.3
Multijet 75HP version)
Mechanical gearbox
and differential (1.3
Multijet 90HP and
1.6 Multijet versions)
Wheel side
constant-velocity
joints
Differential side
constant-velocity
joints (1.6 Multijet
versions excluded)
Differential side
constant-velocity joints
(1.6 Multijet versions)
Hydraulic brakes
and hydraulic clutch
controls
Cooling circuits.
Mixture: 50% water
and 50%
PARAFLU
UP(❒)
Mix 25cc per 10 litres
of diesel
To be used diluted or
undiluted in windscreen/
rear window washer/
wiper systems
SAE 75W-85 grade synthetic base lubricant.
FIAT 9.55550-MX3 certification
SAE 75W-85 grade synthetic base lubricant.
FIAT 9.55550-MZ1 certification
Molybdenum disulphide grease, for use at
high temperatures.
FIAT 9.55580 certification. NL.GI. 1-2 consistency
Grease for constant-velocity joints with low
friction coefficient.
FIAT 9.55580 certification. NL.GI. 0-2 consistency
Polyeura-based synthetic grease for high temperatures.
FIAT 9.55580 certification. NL.GI. 2 consistency
Synthetic fluid FMVSS n° 116 DOT 4, ISO 4925
SAE J1704, CUNA NC 956- 01.
FIAT 9.55597 certification
Red protective with antifreeze action, based on inhibited
monoethyl glycol with organic formula. Exceeds CUNA
NC 956-16, ASTM D 3306 specifications.
FIAT 9.55523 certification
Additive for diesel antifreeze, protecting
diesel engines
Mixture of alcohol, water and surfactants CUNA NC
956-II
FIAT 9.55522 certification.TUTELA CAR
TECHNYX
Contractual Technical
Reference N° F010.B05
TUTELA CAR
MATRYX
Contractual Technical
Reference N° F108.F02
TUTELA ALL STAR
Contractual Technical
Reference N° F702.G07
TUTELA STAR 700
Contractual Technical
Reference N° F701.C07
TUTELA STAR 325
Contractual Technical
Reference N° F301.D03
TUTELA TOP 4
Contractual Technical
Reference N° F001.A93
PARAFLU
UP(*)
Contractual Technical
Reference N° F101.M01
TUTELA DIESEL ART
Contractual Technical
Reference N° F601.L06
TUTELA
PROFESSIONAL SC 35Contractual Technical
Reference N° F201.D02
Radiator
protection Use Quality specifications of fluids and lubricants Original Applications
for correct car operation fluids and lubricants
(*) IMPORTANT Do not use fluids with other specifications for topping up or mixing.
(❒) When the vehicle is used in particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLUUPand distalled water.
235-258 PUNTO FL EN 4ed 18-01-2010 12:28 Pagina 252

259
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
– extending the boot ....................... 94
– parcel shelf (removing) ................ 96
– removing the parcel shelf ............ 96
– unlocking with remote control..6
Boot courtesy light .............................. 197
Brake Assist system............................ 104
Brake fluid
– checking and topping up .............. 224
– specifications.................................. 252
Brake lights
– bulb replacement ...............193-194
Brakes
– brake fluid (type)........................... 252
– checking and topping
up fluid level .................................. 224
– handbrake ....................................... 152
– technical specifications................. 241
Bulbs
– bulb types......................186-187-188
– general information on
replacing.......................................... 186
Capacities
– technical specifications
(quantities)...................................... 250
Capacity for installing child seats........ 138
Car dimensions .................................... 246
Car identification data ........................ 235
Carrying children ................................ 134
Catalytic converter ............................ 128
Central locking .................................... 73Changing a wheel ................................ 176
– general information and
warnings.......................................... 176
– tyre inflation pressure ................ 245
– tyre and rim types ....................... 244
Changing bulbs
– bulb types ...................................... 186
– general information ..................... 186
– inside .............................................. .195
– outside ........................................... 189
Chassis (marking) ............................... 236
Checking engine oil ............................ 220
– consumption ................................. 220
– engine oil specifications .............. 251
Checking levels ................................... 217
– brake fluid ...................................... 224
– engine cooling fluid ...................... 222
– engine oil ....................................... 220
– windscreen/rear window
washer fluid ................................... 223
Child safety .......................................... 84
Child safety device ............................. 87
Child seats ............................................ 138
– capacity for installing child
seats ................................................ 138
– suitability for using child seats..... 137
Children (carrying them safely) ........ 134
– acity for installing an Isofix
child seat ........................................ 138
Cigarette lighter .................................. 78 ABS ....................................................... 103
ABS system .......................................... 103
Additional brake light
– bulb replacement ......................... 194
Adjusting the lighting inside the car 18
Adjusting the mirrors ....................... 44
Adjusting the seats ......................39-41
Adjusting the steering wheel ............ 43
Air conditioning controls ............ 52-56
Air filter ................................................ 225
Air recirculation ....................51-55-58
Air vents................................................ 48
Ashtray................................................... 78
ASR function / system ....................... 107
Automatic climate control................. 56
Battery
– jump starting .................................. 175
– maintenance................................... .225
– replacement .................................. 226
– tips for extending life ................... 226
Bodywork
– bodywork version codes............. 237
– cleaning, care and maintenance.. 231
Bodywork codes ................................. 237
Bodywork versions ............................ 237
Bonnet
– opening/closing ...............97-98-99
Boot ........................................................ 92
– emergency unlocking from
the inside......................................... 94
CONTENTS
259-268 PUNTO FL EN 4ed 18-01-2010 12:29 Pagina 259

260
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
Cleaning and maintenance
– bodywork ...................................... 231
– engine compartment ................... 233
– fabric seats .................................... 234
– interiors ......................................... 233
– leather upholstery ....................... 234
– windows ......................................... 233
– plastic parts ................................... 234
Climate control ................................... 53
– air vents ..................................47-48
Clock
– adjusting ......................................... 30
Clutch
– technical specifications ............... 240
CO
2emissions at exhaust ................ 254
CODE card .......................................... 5
Control buttons .................................. 71
Cruise Control .................................... 66
Dashboard ....................................3-265
Deactivating airbags .....................36-143
Dead lock ............................................. 86
Defrosting/demisting
– rear window ....................51-55-72
– windscreen and front
side windows ..................50-54-57
Demisting/defrosting
– rear window ....................51-55-72
– windscreen and front
side windows....................50-54-57
– wing mirrors.....................51-55-58
Digital display ........................................ 17
– control buttons ............................ 18
– setup menu ................................... 18
– standard screen ............................ 17Dipped beam headlights
– bulb replacement ........................ 190
– switching on ................................. 61
Dipped beam headlights
– bulb replacement ........................ 190
– switching on ................................. 61
Direction indicators
– switching on ................................. 62
– front bulb replacement ............. 191
– rear bulb replacement ................ 193
Direction indicators
– switching on ................................. 62
– front bulb replacement ............. 191
– rear bulb replacement ................ 193
Direction Indicators
– switching on ................................. 62
– front bulb replacement ............. 191
– side bulb replacement ................. 192
– rear bulb replacement ............... 193
Disposing of the car ........................... 255
Door locks ........................................... 73
Doors
– central locking .............................. 73
– child safety device ........................ 87
– locking/unlocking
from the inside ......................73-84
– remote control ............................ 6
– remote locking/unlocking ........... 6
DPF (particulate filter) ....................... 128
Driving economically ......................... 154
Electrical/electronic devices ............ 124
Emergency rear door locking
device ................................................. 88Emergency starting ............................. 175
– bump starting ................................ 176
– jump starting ................................. 175
End of vehicle life ................................ 255
Engine
– engine immobiliser (Fiat CODE) .. 4
– identification codes ..................... 237
– marking .......................................... 236
– technical specifications ............... 238
Engine codes ........................................ 237
Engine compartment
– checking levels .............................. 217
– opening/closing the bonnet ....... 97
– washing ......................................... 233
Engine coolant
– checking levels and topping up ... 222
– specifications ................................. 252
Engine coolant
– checking and topping up ............. 222
– specifications ................................. 252
– temperature gauge and
warning light .................................. 16
Engine coolant temperature
gauge ................................................... 16
– type of coolant ............................. 222
Engine cooling
– checking levels and topping up ... 222
– specifications ................................. 252
Engine immobiliser (Fiat CODE) ...... 4
Engine marking .................................... 236
Engine oil
– checking levels and topping up ... 220
– consumption ................................. 220
– specifications ................................. 251
259-268 PUNTO FL EN 4ed 18-01-2010 12:29 Pagina 260

262
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
Installing electrical/electronic
devices ................................................ 124
– radio transmitters
and mobile phones ...................... 125
Installing the tow hook ...................... 157
Instrument panel ...................13-266-267
Interior lighting ................................... 68
Interiors (cleaning) ............................. 233
Internal equipment ............................. 74
Internal features .................................. 74
Isofix (child seat)
– capacity for installing child
seats ................................................ 138
– suitability for the child seats ...... 140
Jack
– usage ............................................... 178
– warnings ......................................... 177
Keys ...................................................... 5
– key with remote control ............ 6
– key without remote control ..... 9
– opening/closing doors remotely ... 6
– requesting additional remote
control keys .................................. 8
– replacing remote control
battery ............................................ 8
Knowing your vehicle.................. 3
Lights
(controls to switch on) ............ 61-71
Load limiters ........................................ 131
Long periods of inactivity .................. 160
Lubricant specifications ..........251-252Main beam headlights
– bulb replacement ......................... 190
– switching on .................................. 61
Main beam headlights
– bulb replacement ......................... 190
– flashing ............................................ 61
– switching on .................................. 61
Manual climate control ...................... 52
Maximum speeds ................................ 247
Mirrors
– rear-view ....................................... 44
– wing ................................................ 45
MSR system ......................................... 108
Multifunctional display ....................... 23
– setup menu .................................. 26
Nozzles
– windscreen/rear window/
headlamp washer ......................... 230
Number plate lights
– bulb replacement ......................... 194
Odometer ............................................ 15
On-board computer (trip) ................ 37
On-board instruments (panel) .......... 13
P
aintwork (maintenance) ................. 232
– bodywork colour plate ............... 236
Paintwork plate ................................... 236
ParafluUP
– checking levels and topping up ... 222
– specifications ................................. 252
Parking sensors ................................... 120
Particulate filter (DPF) ....................... 128Performance ........................................ 247
Pollen filter ........................................... 225
Protecting the environment ............. 127
– particulate filter (DPF) ................ 128
Protecting the environment ............. 127
Punctures
– changing a wheel .......................... 176
– Fix& Go automatic quick tyre
repair kit ........................................ 181
– general information ..................... 176
Quick tyre repair kit (Fix&Go) ....... 181
Radio transmitters and mobile
phones ................................................ 125
Raising the car
– with the jack ................................. 177
– with the lift arms .......................... 207
– with the workshop lift ................ 208
Rear ceiling lights ................................ 68
– bulb replacement ......................... 196
Rear fog light ....................................... 72
– bulb replacement ......................... 194
– switching on .................................. 72
Rear light clusters
– bulb replacement ......................... 193
Rear seats
– cleaning .......................................... 234
– headrests ....................................... 43
Rear window washer ......................... 65
– activating ........................................ 65
– checking levels and topping up ... 252
– nozzle ............................................. 231
Rear window wiper
– activating ........................................ 65
259-268 PUNTO FL EN 4ed 18-01-2010 12:29 Pagina 262

263
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
– blade replacement ....................... 230
– rear window washer fluid
specifications ................................. 252
Reconfigurable multifunctional
display ................................................. 24
– control buttons ............................ 25
– setup menu ................................... 26
– standard screen ............................ 24
Regular checks .................................... 216
Remote control .................................. 6
– additional remote controls ........ 8
– battery replacement .................... 7
– opening/closing doors
remotely ........................................ 6
– opening the tail gate .................... 6
Replacing battery of key with
remote control ................................. 7
Rev counter ......................................... 15
Reverse light
– bulb replacement ......................... 194
Right hand drive version ................... 265
Roof bar attachments ........................ 99
Roof rack/ski rack (capacity for) ..... 99
Rubber tubes ....................................... 229
Safety ................................................... 129
Satellite navigation socket ................. 124
SBR system .......................................... 130
Scheduled servicing plan ......... 212-214
Scrappage ............................................. 255
Seat belt pretensioners ..................... 131
– load limiters .................................. 131
Seat belts .............................................. 129
– carrying children safely ............... 134– general information ..................... 132
– load limiters .................................. 131
– maintenance .................................. 225
– pretensioners ................................ 131
– SBR ................................................. 130
– using the seat belts ...................... 129
Seat heating .......................................... 41
Servicing and care......................... 211
– checking fluid levels ..................... 217
– heavy-duty use of the car ........... 216
– regular checks .............................. 216
– scheduled servicing plan..... 212-214
Setting the clock ..........................21-30
Side bags
–
side bag / window bag ... 144-145-146
– general information ..................... 147
Side lights/taillights
– front bulb replacement ............... 189
– rear bulb replacement ................ 193
– switching on .................................. 61
Smart washing
(windscreen wipers) ........................ 64
Snow chains ......................................... 159
Sockets .................................................. 80
Spare wheel ......................................... 176
– technical specifications ............... 244
Spark plugs (type) .....................238-239
Speedometer ....................................... 15
– standard screen ............................ 23
Start&Stop system .............................. 115
Starting and driving...................... 149
Starting the engine ............................. 149
– emergency starting ...................... 175
– ignition switch .............................. 11
– procedure for diesel versions.... 150– procedure for petrol versions .... 149
– stopping the engine ..................... 151
– warming the engine ..................... 151
Steering lock ........................................ 12
Steering system
– technical specifications ............... 241
–
steering wheel adjustment lever.... 43
Steering wheel
– adjustment lever .......................... 43
– turning circle ................................. 241
Steering wheel stalks ................... 61-63
Stereo (wiring)..................................... 122
Storage compartments ...................... 74
Sun visors ............................................. 79
Suspensions .......................................... 241
Switching ceiling lights on/off ........... 68
Symbols ................................................. 4
Tail gate
– emergency unlocking from
the inside ....................................... 94
– unlocking with remote control .. 6
Technical specifications.............. 235
Third brake light ................................. 194
Topping up engine oil ........................ 220
– specifications ................................. .251
Tow hook
– installing ........................................ 207
Towing the car .................................... 208
Towing trailers .................................... 156
Trailer (towing) ................................... 156
– installing the tow hook ............... 157
Transmission
– technical specifications ............... 240
Trip computer ..................................... 37
259-268 PUNTO FL EN 4ed 18-01-2010 12:29 Pagina 263