2010 FIAT LINEA RHD engine

CONDITIONS OF USE
Cold starting
Short distances and frequent cold start-ups
will prevent the engine from reaching op-
timal running temperature. Consequently,
both consumption (from +15 to +30% on
urban cycle ) and emissions will increase.
Traffic and
road conditions
Rather high consumption is caused by
heavy traffic, for instance when travelling
in a queue with frequent use of low gears
or in cities with many traffic lights. Moun-
tain and rough roads also have a negative
effect on consumption.Traffic hold-ups
During prolonged hold-ups (level crossings)
the engine should be switched off. Top speed
Fuel consumption considerably increases
as speed increases. Keep your speed as
even as possible,
avoiding unnecessary
braking and acceleration which cause ex-
cessive fuel consumption and increase
emissions.
Acceleration
Sudden acceleration has a very negative
effect on consumptions and emissions: ac-
celerate gradually and do not go over the
maximum torque ratio.
99
CORRECT USE
OF THE CAR
WARNING
IN AN
CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
LIGHTS AND
EMERGENCY
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 99LINEA Owner HAND BOOK RHD.pdf 998/21/09 2:16:14 PM8/21/09 2:16:14 PM

CAR INACTIVITY
If the car is to be left inactive for longer
than a month, the following precautions
should be noted:
park the car in covered, dry and if pos-
sible well-ventilated premises;
engage a gear;
check that the handbrake is not en-
gaged;
disconnect the negative battery termi-
nal and check battery charge (see para-
graph “Charge level check”
in chapter
“Maintenance and care”). Repeat this
check once every three months dur-
ing storage. Recharge the battery if nec-
essary (see paragraph “If the battery is
flat” in chapter “In an emergency”);
clean and protect the painted parts us-
ing protective wax;
clean and protect the shiny metal parts
using special compounds readily avail-
able;
sprinkle talcum powder on the rubber
windscreen and rear window wiper
blades and lift them off the glass;
slightly open the windows;
cover the car with a fabric or perfo-
rated plastic terrapin. Do not use com-
pact plastic sheets which do
not allow
humidity to evaporate from the surface
of the car;
inflate tyres to +0.5 bar above the nor-
mal specified pressure and check it at
intervals;
if you don’t disconnect the battery from
the electric system, check its charge
every month (see paragraph “Charge
level check” in chapter “Maintenance
and care”);
recharge the battery if necessary (see
paragraph “If the battery is flat” in chap-
ter “In an emergency”);
do not drain the engine cooling system.
IMPORTANT Where relevant, switch off
the car alarm with the remote control.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
WARNING
LIGHTS AND
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
MESSAGES
100
LINEA Owner HAND BOOK RHD.pdf 100LINEA Owner HAND BOOK RHD.pdf 1008/21/09 2:16:14 PM8/21/09 2:16:14 PM

GENERAL WARNINGS ..................................................... 102
LOW BRAKE FLUID ............................................................ 102
HANDBRAKE ON................................................................ 102
AIR BAG FAILURE ................................................................ 103
HOT
ENGINE COOLANT ........................................................... 103
LOW BATTERY CHARGE ................................................. 104
LOW ENGINE OIL PRESSURE .......................................... 104
INCOMPLETE DOOR LOCKING.................................... 105
SEAT BELTS NOT FASTENED .......................................... 105
EBD SYSTEM FAILURE ........................................................ 105
INJECTION SYSTEM FAILURE
(DIESEL VERSIONS) ............................................................ 106
EOBD SYSTEM FAILURE (PETROL VERSIONS) ......... 106
FRONT PASSENGER AIRBAG DEACTIVATED ........... 107
ABS SYSTEM FAILURE ......................................................... 107
FUEL RESERVE ....................................................................... 107
GLOW PLUG WARMING ................................................ 108
GLOW PLUG WARMING FAILURE ............................... 108
WATER IN DIESEL FUEL FILTER ..................................... 108FIAT CODE PROTECTION
SYSTEM FAILURE .................................................................. 108
EXTERNAL LIGHTS FAILURE........................................... 109
REAR FOG LIGHTS.............................................................. 109
GENERIC FAILURE INDICATION ................................. 109
SIDELIGHTS AND LOW BEAMS ..................................... 110
FOLLOW ME HOME ........................................................... 110
FRONT FOG LIGHTS ........................................................ 110
LEFT-HAND DIRECTION INDICATOR ........................ 110
RIGHT-HAND DIRECTION INDICATOR .................... 110
MAIN BEAM HEADLIGHTS............................................... 110
WW W
A A
R R
N N
I I
N N
G G
L L
I I
G G
H H
T T
S S
A A
N N
D D
M M
E E
S S
S S
A A
G G
E E
S S
101
CORRECT USE
OF THE CAR
CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 101LINEA Owner HAND BOOK RHD.pdf 1018/21/09 2:16:14 PM8/21/09 2:16:14 PM

103
AIR BAG FAILURE
(red)
Turn ing the ignit ion key to
MARthe warning ligh t turns on, but it
should go off after few seconds.
The warning light stays on steady if there
is a failure in the airbag system.
On certain versions the dedicated message
is displayed.
If when turning the key to
MAR the warning light
does not turn on or if it stays on when
travelling (together with the message
on the multifunctional display, where
provided) there could be a failure in
safety systems; in this event air bags
or pretensioners may not be deployed
in case of impact or, in a minor num-
ber of cases, they be deployed acci-
dentally. Contact Fiat Dealership
immediately to have the system checked.
WARNING
Failure of warning light
(warning light off) is indicat-
ed by warning light which will
blink for longer than the normal 4
seconds indicating that the front pas-
senger airbag is off.
WARNING
HOT ENGINE
COOLANT (red)
Turn ing the igni tion key to
MARthe warning light turns on, but it
should go off after few seconds.
The warning light turns on when the en-
gine is overheated.
If the warning light comes on, proceed as
follows:
during normal travel: s t o p t h e c a r,
stop the engine and check that the wa-
ter level in the vessel is not under the
MINline. In this case, wait for a few
minutes for the engine to cool down
when slowly and carefully open the
cap, top-u p with coolant and check
that the level is between the MINand
MAXreferences on the vessel itself.
Also check for leakages. Go to a Fiat
Dealership if the warning should
come on when the engine is started
again.CORRECT USE
OF THE CAR
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES
IN AN
LINEA Owner HAND BOOK RHD.pdf 103LINEA Owner HAND BOOK RHD.pdf 1038/21/09 2:16:15 PM8/21/09 2:16:15 PM

LOW ENGINE OIL
PRESSURE (red)
Turning the ignition key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started.
On certain versions the dedicated message
is displayed.
If the warning light
turns on when the car is trav-
elling (on cer tain versions together
with the message on the display) stop
the engine immediately and contact
a Fiat Dealership.
WARNING
In the case of demanding use (e.g.
towing traile rs uphill or car at full
load): slow down and stop the car if
the warning light stays on. Stand for
2 or 3 minutes with the engine running
and slightly accelerated to promote a
better circulation of coolant.
Then
stop the engine. Check correct liquid
level as described above.
IMPORTANT Under severe use of the
car, keep the engine on and slightly accel-
erated for few minutes before switching it
off.
On certain versions the dedicated message
is displayed.LOW BATTERY
CHARGE (red)
Turning the igni tion key to
MARthe warning light turns on, but it
should go out as soon as the engine is
started (with the engine running at idle
speed a brief delay in going out is allowed).
Go to a Fiat Dealership immediately
if the warning light stays on either ste-
ady or blinking.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
104
LINEA Owner HAND BOOK RHD.pdf 104LINEA Owner HAND BOOK RHD.pdf 1048/21/09 2:16:15 PM8/21/09 2:16:15 PM

105
INCOMPLETE DOOR
LOCKING (red)
On certain versions the warn-
ing ligh t turns on when one or more
doors or the tailgate are not properly
shut.
On certain versions the dedicated message
is displayed.
A buzzer will sound when doors/tailgate
are open and the car is moving.EBD FAILURE
(red) (amber)
Warning lights and lit at the same
time with the engine running indicates an
EBD system failure or that the system is
not available.
Early locking of the rear
wheels may occur in the event of violent
braking causing the car to swerve.
Drive
very carefully to a Fiat Dealership to
have the system inspected.
On certain versions
the dedicated message
is displayed.
SEAT BELTS NOT
FA S T E N E D
(red)
The warning light on the display
will light up when the car is moving and the
driver’s seat belt is not correctly fastened.
The warning light will blink and a buzzer will
sound if the front seat belts are not cor-
rectly fastened. The buzzer of the S.B.R.
(Seat Belt Reminder) system may
only be
switched off by a Fiat Dealership. On
some versions the system may be reac-
tivated from the setup menu.
CORRECT USE
OF THE CAR
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES WARNING
LIGHTS AND
MESSAGES
IN AN
LINEA Owner HAND BOOK RHD.pdf 105LINEA Owner HAND BOOK RHD.pdf 1058/21/09 2:16:15 PM8/21/09 2:16:15 PM

106
Go to a Fiat Dealership
as soon as possible if warning
light either does not light
up when the key is turned to
MAR to if while travelling the warning
lights comes on either steady or blink-
ing (along with a message on the dis-
play).
If the light flashes, release the accelerator
pedal to lower the speed of the engine un-
til the warning light stops flashing; contin-
ue the journey at moderate speed, trying
to avoid driving conditions that may cause
further flashing and contact Fiat
Dealership as soon as possible. EOBD ENGINE CONTROL
SYSTEM FAILURE
Under normal conditions, turning the ig-
nition key to MAR, the warning light turns
on
but it should go off after engine starting.
This indicates that the warning light is
working correctly. If the warning light
ei-
ther stays on or comes on while travelling:
steady light: a fault in the supply/ignition
system which could cause high emis-
sions at the exhaust, possible lack of
performance, poor handling and high
consumption levels.
On certain versions the dedicated mes-
sage is displayed.
In these conditions, you may continue
travelling at moderate speed without de-
manding excessive effort from the engine.
Prolonged use of the car with the warn-
ing light on may cause damage.
Go to a
Fiat Dealership as soon as possible.
if warning light will go out after the
fault goes away but it will be stored in the
system.
blinking: indicates the possibility of
damage to the catalyser (see “EOBD
system” in section “Dashboard
and
controls”). INJECTION SYSTEM
FA I L U R E
(Multijet versions -
amber)
EOBD SYSTEM
FAILURE (petrol
versions - amber)
Injection system failure
Under normal conditions, turning the
ig-
nition key to MAR, the warning light turns
on but it should go off after engine start-
ing.
If the warning light stays on or turns
on
when travelling, means a fault in the sup-
ply/ignition system which could cause high
emissions at the exhaust, possible lack of
performance, poor handling and high
con-
sumption levels.
On certain versions the dedicated message
is displayed.
In these conditions, you may continue
travelling at moderate speed without
de-
manding excessive effort from the engine.
Go to a Fiat Dealersh ip as so on as
possible.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 106LINEA Owner HAND BOOK RHD.pdf 1068/21/09 2:16:15 PM8/21/09 2:16:15 PM

108
GLOW PLUG
WA R M I N G
(Multijet versions - amber)
GLOW PLUG
WARMING FAILURE
(Multijet versions - amber)
Glow plug warming
The warning light will go on when the key
is turned to MAR. It will go out as soon
as the glow plugs have
reached a prede-
termined temperature. Start the engine as
soon as the warning light goes out.
IMPORTANT With hot ambient temper-
ature, warning light stays on for very short
time.
Glow plug warming failure
The warning light will blink in the event
of a failure to the glow plug heating sys-
tem. Go to a Fiat Dealership as soon
as possible.
On certain
versions the dedicated message
is displayed.
WATER IN DIESEL
FUEL FILTER
(Multijet versions - amber)
Turning the ignition key to MARthe
warning light turns on, but it should go off
after few seconds.
The warning light turns on when there is
water in the diesel fuel filter.
On certain
versions the dedicated message
is displayed.
The presence of water in the
feeding circuit may cause se-
vere damage to the injection
system and irregular engine
operation. If warning light lights up
(on some versions with the message on
the display), go to a Fiat Dealership
as soon as possi bl e to hav e the
system bled. Water may have been intro-
duced in the tank if this appears imme-
diate ly afte r refu ellin g: in this case ,
stop the engine immediately and cont-
act a Fiat Dealership.
CAR PROTECTION
SYSTEM FAILURE -
FIAT CODE (amber)
Turning the key to MARthe warning light
shall flash only once and then go off.
If with the ignition key at MAR, the warn-
ing light stays on, this indicates a possible
failure (see “Fiat Code system” in section
“Dashboard and controls”).
IMPORTANT Warning lights and
will come on at the same time to indicate
a Fiat CODE system failure.
If with the engine running the warning light
flashes, this means that the car is not
protected by the engine inhibitor device
(see “Fiat Code system” in section “Dash-
board and controls”).
Contact Fiat Dealership to have all the
key stored.
CORRECT USE
OF THE CAR
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
WARNING
LIGHTS AND
MESSAGES
LINEA Owner HAND BOOK RHD.pdf 108LINEA Owner HAND BOOK RHD.pdf 1088/21/09 2:16:15 PM8/21/09 2:16:15 PM