2010 FIAT DUCATO ignition

F0N0094mfig. 209
REPLACING FUSES
GENERAL INFORMATION
Fuses protect the electric system: they cut in (i.e. they
blow) in the event of a failure or improper action on the
system.
Check the state of the corresponding fuse when
a device does not work: the filament A-fig. 209 must be
intact. If it is not, replace the blown fuse with another
with the same amperage (same colour).
B intact fuse;
C fuse with damaged filament.
198
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Never replace a blown fuse with metal
wires or other recovered material.
Never replace a fuse with another of
higher amp rating; FIRE HAZARD.
WARNING
If a general protection fuse (MEGA-
FUSE, MIDI-FUSE, MAXI-FUSE) is
blown, contact a Fiat Dealership. Before
replacing a fuse, make sure that the ignition key
has been removed and that all the other
services are switched off and/or disengaged.
WARNING
If the replaced fuse blows again, contact
a Fiat Dealership.
WARNING
173-206 DUCATO LUM EN 8ed 27-10-2010 15:45 Pagina 198

202
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
USERSFUSE AMPERE
Radio, Driver side window, Controls on instrument panel,
Alarm control unit, rain sensor (+key) F49 7,5
Airbag (+key) F50 7,5
A/C control, Cruise control, Tachograph (+key) F51 7,5
Optional control unit relay F52 7,5
Instrument panel, rear fog light (+battery) F53 7,5
Engine compartment fusebox fig. 212-213
USERSFUSE AMPERE
ABS pump (+battery) F01 40
Preheating glow plugs (+battery) F02 50
Ignition switch (+battery) F03 30
Webasto control unit (+battery) F04 20
Passenger compartment ventilation with Webasto (+battery) F05 20
Engine cooling high speed fan (+battery) F06 40/60
Engine cooling low speed fan (+battery) F07 40/50
Passenger compartment fan (+key) F08 40
Windscreen washer pump F09 20
HornF10 15
i.e. system (secondary services) F11 15
Right main beam headlamp F14 7,5
Left main beam headlamp F15 7,5
i.e. system (+key) F16 7,5
173-206 DUCATO LUM EN 8ed 27-10-2010 15:45 Pagina 202

223
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
If the vehicle must remain unused for
a long time at very low temperatures,
remove the battery and take it to a warm
place to avoid freezing.
USEFUL ADVICE FOR EXTENDING
THE LIFE OF YOUR BATTERY
To avoid draining your battery and make it last longer,
observe the following instructions:
❒when you park the vehicle, ensure that the doors,
tailgate and bonnet are closed properly to avoid the
ceiling lights remain on;
❒the ceiling lights must be off. The vehicle is however
provided with an automatic system for switching off
internal lights;
❒do not keep accessories (e.g. sound system, hazard
warning lights, etc...) switched on for a long time
when the engine is not running;
❒before performing any operation on the electrical
system, disconnect the negative battery cable;
❒battery terminals should always be completely
tightened.
IMPORTANT If the charge level remains under 50% for
a long time, the battery is damaged by sulphation,
reducing its capacity and starting attitude.The battery will also be more at risk of freezing (this can
happen as early as −10°C). Refer to the paragraph
“Vehicle inactivity” in “Starting and driving” if the car is
left parked for a long time.
If, after buying the vehicle, you want to install electric
accessories which require permanent electric supply
(alarm, etc.) contact a Fiat Dealership whose qualified
personnel, in addition to suggesting the most suitable
devices from the Lineaccessori Fiat, will evaluate the
overall electric absorption, checking whether the
vehicle’s electrical system is capable of withstanding the
load required, or whether it should be integrated with
a more powerful battery.
Since these devices continue absorbing energy even
when the ignition key is off, they gradually run down the
battery.
IMPORTANT If a tachograph is fitted, if the vehicle is
parked for a long period of 5 days, it is advisable to
disconnect the negative battery terminal to maintain its
charge.
If the vehicle is equipped with a battery disconnection
function (disconnector), see the description of the
procedure in the „Controls“ paragraph in the
„Dashboard and controls“ section.
207-230 DUCATO LUM EN 7ed 6/21/10 2:17 PM Page 223

229
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
INTERIORS
Periodically check that water is not trapped under the
mats (due to water dripping off shoes, umbrellas, etc.)
which could cause oxidisation of the sheet metal.
Detergents pollute the environment.
The vehicle should be washed in areas
equipped for collecting and purifying the
liquid used in the washing process.
Glasses
To clean glasses, use specific window cleaner products.
Also use clean cloths to avoid scratching the glass or
damaging the transparency.
IMPORTANT Wipe the rear window inside gently with
a cloth in the direction of the filaments to avoid
damaging the heating device.
Engine compartment
Wash the engine compartment thoroughly at the end of
every winter. Be careful not to direct the jet of water
onto electronic control units. Adequately protect the
upper air vents to prevent damage to the windscreen
wiper motor. Have this operation performed at a
specialised workshop.
IMPORTANT The washing should take place with the
engine cold and the ignition key in the STOP position.
After the washing operation, make sure that the various
protections (e.g. rubber caps and guards) have not been
removed or damaged.
Front headlights
IMPORTANT Never use aromatic substances (e.g.:
petrol) or ketones (e.g.: acetone) for cleaning the front
headlight plastic lenses.
Never use flammable products, such as
petrol, ether or rectified petrol, to clean
the vehicle interior. The electrostatic charges
which are generated by rubbing during the
cleaning operation may cause a fire.
WARNING
Do not keep aerosol cans in the vehicle:
risk of explosion Aerosol cans must not
be exposed to a temperature exceeding 50 °C.
When the vehicle is exposed to sunlight, the
internal temperature can greatly exceed this
value.
WARNING
207-230 DUCATO LUM EN 7ed 6/21/10 2:18 PM Page 229

280
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Gearbox
– using the manual
gearbox ................................ 150
General warnings ..................... 2
Glove compartment ................ 91
Handbrake ................................149
Handbrake lever ...................... 149
Hazard lights ............................. 85
Headlight alignment
corrector ................................ 113
Headlight washers
– control ................................. 79
– maintenance ........................ 227
Headlights ..................................113
– adjusting headlights
abroad .................................. 114
– beam orientation ............... 113
– bulb replacement ............... 188
– headlight alignment
corrector ............................. 113Headlights
(warning for cleaning) ........... 229
Headrests .................................. 46
Heated rear window ............... 86
Heating and ventilation ........... 51
– automatic climate
control ................................. 60
– controls ................................ 52
– front window rapid
defrosting/demisting .. 54-57-65
– heated rear window
and external rear view
mirror defrosting/
demisting .....................54-59
– interior air recirculation ... 55
– passenger compartment
air vents ............................... 52
– manual climate control ...... 55
Heavy use of the vehicle
servicing ................................... 212
Hill Holder system .................. 117
Identification plates ................. 233
– body paintwork .................. 232
– identification data ............... 234
Ignition switch .......................... 12
– steering lock ........................ 13
In an emergency ....................... 173
Installation of electrical/
electronic devices .................. 125
Installing the tow hook ...........155
– assembly diagrams ..... 157-158
Instrument panel ...................... 14
Interior fittings ......................... 90
Interiors (maintenance) .......... 222
Isofix (child seat) ...................... 138
Keys ........................................... 5
– Code card ........................... 5
– key with remote control .. 6
– key without remote
control ................................. 8
– replacing the battery ......... 8
277-284 DUCATO LUM EN 9ed 15-04-2011 8:32 Pagina 280

283
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Shelf above the cab ................. 96
Side air bags .............................. 143
Side lights
– control ................................. 74
– front bulb replacement ..... 189
– rear bulb replacement ...... 192
– side bulb replacement ....... 196
Ski rack ...................................... 112
Sliding side door ...................... 106
Sliding side window ................. 106
Snow chains .............................. 159
Speed block ............................... 102
Speedometer ............................ 15
Starting the engine ................... 147
– bump starting ...................... 174
– emergency starting ............ 173
– ignition switch ..................... 12
– jump starting ....................... 173
– procedure ............................ 147
– stopping the engine ........... 148
– warming up the engine
once started ........................148Starting up and driving ............ 147
Steering lock ............................. 13
Steering wheel
(adjustment) ........................... 47
Steering
– technical specifications ...... 236
– turning circle ....................... 236
Storage compartments ..... 90-91
Sun visors .................................. 95
Supply (specifications) ............. 235
Suspension (specifications) .... 235
Symbols ...................................... 4
Tachograph ..............................101
Technical specifications .......... 231
Telepass (preparation) ............ 126
Third brake light ...................... 195
Towing the vehicle .................. 205
Trailer (towing) ....................... 154
– installing the tow hook ..... 155
– warnings ...............................155Transmission
(specifications) ....................... 235
Trip computer .......................... 35
TV camera system and rear
visibility display ....................... 98
Tyre inflation pressure ........... 240
Tyres
– changing a wheel ................ 174
– maintenance ........................ 224
– provided ...............................239
– reading tyre markings ....... 237
– Rim Protector .................... 238
– snow ..................................... 159
– tyre inflation pressure ....... 240
Under-seat compartment ..... 42
Vehicle identification data ...... 231
Vehicle inactivity ...................... 160
Ventilation ................................. 51
277-284 DUCATO LUM EN 9ed 15-04-2011 8:32 Pagina 283