2010 FIAT DUCATO power steering fluid

213
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
CHECKING FLUID LEVELS
fig. 221 – 100 Multijet versions
fig. 222 – 120 Multijet – 130 Multijet versions
Never smoke while
working in the engine
compartment: gas and
inflammable vapours may be
present, with the risk of fire.
WARNING
Be careful, when
topping up not to
confuse the various
types of fluids: they are all
incompatible with one another
and could seriously damage the
vehicle.
1. Engine coolant fluid
2. Power steering fluid
3. Windscreen washer fluid
4. Brake fluid
5. Engine oil
F0N0099m
F0N0100m
207-230 DUCATO LUM EN 7ed 6/21/10 2:17 PM Page 213

214
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Be careful, when
topping up not to
confuse the various
types of fluids: they are all
incompatible with one another
and could seriously damage the
vehicle.
1. Engine coolant fluid
2. Power steering fluid
3. Windscreen washer fluid
4. Brake fluid
5. Engine oil
fig. 223 – 160 Multijet versions
Never smoke while
working in the engine
compartment: gas and
inflammable vapours may be
present, with the risk of fire.
WARNING
F0N0210m
207-230 DUCATO LUM EN 7ed 6/21/10 2:17 PM Page 214

F0N0109mfig. 230
POWER STEERING FLUID fig. 230
Check that the liquid contained in the tank is at the
maximum level. This operation must be carried out with
the vehicle level and with the engine off and cold. Check
that the fluid level is up to the MAX mark on the
dipstick attached to the fuel cap (use the level shown on
the 20°C side of the dipstick to check when cold).
If the level of the fluid in the tank is lower than the
specified level, top up using only one of the products
indicated in the “Fluid and lubricants” table in the
“Technical specifications” section, proceeding as follows:
❒Start the engine and wait for the level of fluid in the
tank to stabilise.
❒With the engine running, turn the steering wheel
from right to left fully, several times.
220
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Power steering fluid consumption is very
low. If the fluid needs topping up a short
time after the last top-up, have the
system checked by a Fiat Dealership to ensure
there are no leaks.
Do not press the power steering end of
travel lock for longer than 8 consecutive
seconds with the engine running because
it will cause noise and risk damaging the system.
❒Top up the fuel to the MAX level and then retighten
the cap.
Prevent power steering fluid from
coming into contact with hot engine
parts: the liquid is flammable.
WARNING
207-230 DUCATO LUM EN 7ed 6/21/10 2:17 PM Page 220

267
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
100
Multijet
90 (*)
10/12
11 (▼)
5,88
6,38
2,4 (❏)
0,6
0,62
1,5
5,5
5,5120
Multijet
90 (*)
10/12
11 (▼)
5,9
6,5
2,7 (❏) (❍)
2,9 (■) (●)
0,6
0,62
1,5
5,5
5,5130
Multijet
90 (*)
10/12
11 (▼)
5,9
6,5
2,7 (❏)
0,6
0,62
1,5
5,5
5,5160
Multijet
90 (*)
10/12
11 (▼)
8
9,1
2,9 (■)
0,6
0,62
1,5
5,5
5,5Prescribed fuels
Original products
Diesel fuel for motor vehicles
(EN 590 standard)
Mixture of 50% distilled water
and PARAFLU
UP(
▲)
SELENIA WR P.E.
TUTELA CAR EXPERYA (❏)
TUTELA CAR MATRYX (■)
TUTELA TOP 4
TUTELA CAR GI/E
Mixture of water and
TUTELA
PROFESSIONAL SC 35
CAPACITIES
litres litres litres litres
Fuel tank:
including a reserve of:
Engine cooling
system:
Engine sump:
Engine sump and filter:
Gearbox casing/
differential:
Hydraulic brakes circuit
with ABS:
ASR/ESP:
Hydraulic power steering:
Windscreen
washer fluid reservoir:
with headlamp washers:
(*) It is possible to request a 120 litre capacity tank on all versions.
On „Recreational versions“, a 60 litre capacity tank may be ordered.
(▼) With Webasto: 11.15 l - Underseat heater 600 cc: 11.6 l - Rear heater 900 cc: 11.9 l
(▲) When the vehicle is used in particularly harsh weather conditions, we recommend using a mixture of 60% PARAFLU
UP
and 40% distilled water.
(❍) MLGU gearbox
(●) M38 gearbox
231-276 DUCATO LUM EN 9ed 15-04-2011 8:21 Pagina 267

268
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
According to
Scheduled
Servicing Plan
Manual gearbox
and differential
Manual gearbox
and differential
Wheel side
constant velocity
joints
Differential side
constant velocity
joints
Differential side
constant velocity
joints
Hydraulic power
steering
Lubricants
(▲)
For diesel engines, in the event of an emergency in which the original products are not available, lubricants with at least ACEA C2
performance are acceptable; however, in this case optimum engine performance is not guaranteed and the lubricants should be replaced
with recommended products as soon as possible at a Fiat Dealership.
The use of products with lower specifications than ACEA C2 could cause damage to the engine not covered by the warranty.
For particularly harsh climate conditions, ask a Fiat Dealership for the appropriate product from PETRONAS LUBRICANTS.
SAE 5W-30 grade synthetic base lubricant.
FIAT 9.55535-S1 certification.
Synthetic base lubricant, SAE 75W-80 grade
that exceeds API GL-4 specifications
Synthetic base lubricant, SAE 75W-85 grade
that exceeds API GL-4 specifications
Lithium soap grease with molybdenum
disulphide. NI.GI. 2 consistency
Lithium-based grease
NI.GI. 0 consistency
Poly-urea synthetic-based grease suitable for
high temperatures. NI.GI. 2 consistency
Lubricant for power steering and automatic
transmissions. Exceeds
ATF DEXRON IIISELENIA WR P.E.(▲)
Contractual Technical
Reference No. 510.D07
TUTELA CAR EXPERYA
Contractual Technical
Reference No. F178.B06
TUTELA CAR MATRYX
Contractual Technical
Reference No. F108.F02
TUTELA STAR 500
TUTELA MRM ZERO
TUTELA STAR 325
Contractual Technical
Reference No. F301.D03
TUTELA GI/E
Contractual Technical
Reference No. F001.C94Diesel engine
lubricants
Lubricants
and greases
for motion
transmission
FLUIDS AND LUBRICANTS
SPECIFICATIONS AND RECOMMENDED PRODUCTS
Use Quality specifications of fluids and lubricants Genuine lubricants Replacement for correct vehicle operation and fluids interval
231-276 DUCATO LUM EN 9ed 15-04-2011 8:21 Pagina 268

278
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– positioning
the restraint systems
on the seats ................137-140
– preparation for “Isofix
Universale” child seat ........ 138
Central door
locking/unlocking system ..... 102
Changing a wheel ..................... 174
Chassis (marking) .................... 233
Checking the levels ................. 213
– brake fluid ............................ 219
– engine coolant .................... 217
– engine oil ............................. 215
– power steering fluid .......... 220
– washer fluid for
windscreen/rear
window/headlamps ............ 218
Cigar lighter ............................... 94
Cleaning and maintenance
– bodywork ............................ 227
– engine compartments ....... 229– front headlights .................. 229
– interiors ............................... 229
– leather upholstery ............. 230
– paintwork ............................ 228
– plastic parts ......................... 230
– rubber tubes ....................... 225
– seats and fabric parts ........ 230
– windows ............................... 229
– windows ................................ 229
CO
2emissions ......................... 271
Code card................................... 5
Compartment under front
passenger seat ........................ 92
Controls .................................... 85
Cruise Control (constant
speed regulator) .................... 80
Cup/can holder ........................ 93
Dashboard ................................ 3
Dashboard and controls ........ 3
Dead lock (device) .................. 105
Desk/bookrest .........................96
Digital display ............................ 18
Dimensions ............................... 241
Direction indicators
– bulb replacement ....... 190-192
– control ................................. 75
– front bulb replacement ..... 190
– rear bulb replacement ...... 192
Door lock .................................. 87
Door pockets ........................... 92
Doors ......................................... 102
DPF
(diesel particulate filter) ....... 128
EBD (system) ...........................114
Electric windows ...................... 109
Electricity supply and fuel
cutoff switch ........................... 88
277-284 DUCATO LUM EN 9ed 15-04-2011 8:32 Pagina 278