Page 113 of 203
1 0
CHECKS
Diesel additive level
(Diesel engine with particle
emission filter)
A low additive level is indicated by light-
ing of the service warning lamp, accom-
panied by an audible warning and a
message on the multifunction screen.
Topping up
This additive must be topped up by a
CITROËN dealer without delay.
Used products Avoid prolonged contact of used
o i l o r fl u i d s w i t h t h e s k i n .
M o s t o f t h e s e fl u i d s a r e h a r m f u l t o
health or indeed very corrosive.
D o n o t d i s c a r d u s e d o i l o r fl u i d s
into sewers or onto the ground.
Take used oil to a CITROËN
dealer (France) or an authorised
waste disposal site. CHECKS
Unless otherwise indicated, check
these components in accordance with
the Warranty and Maintenance Record
and according to your engine.
Otherwise, have them checked by a
CITROËN dealer.
B a t t e r y The battery does not require
any maintenance.
H o w e v e r , c h e c k t h a t t h e t e r -
minals are clean and correctly
tightened, particularly in summer
and winter.
When carrying out work on the battery,
refer to the "Practical information" sec-
tion for details of the precautions to be
taken before disconnecting the battery
and following its reconnection.
Air filter and passenger
compartment filter
Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
vals for these components.
Depending on the environ-
ment (e.g. dusty atmosphere) and the
use of the vehicle (e.g. city driving),
replace them twice as often if neces-
s a r y (refer to the "Engines" section).
A c l o g g e d p a s s e n g e r c o m p a r t m e n t fi l t e r
may have an adverse effect on the per-
formance of the air conditioning system
and generate undesirable odours. Oil filter
R e p l a c e t h e o i l fi l t e r e a c h t i m e
the engine oil is changed.
Refer to the Warranty and
Maintenance Record for details
of the replacement interval for
this component.
Particle emission filter (Diesel)
It is imperative that the maintenance of
t h e p a r t i c l e e m i s s i o n fi l t e r i s c a r r i e d o u t
by a CITROËN dealer.
Following prolonged operation
of the vehicle at very low speed
or at idle, you may, in excep-
tional circumstances, notice the
emission of water vapour at the
exhaust on acceleration. This
does not affect the behaviour of
the vehicle or the environment.
Page 114 of 203
1 0
CHECKS
Diesel additive level
(Diesel engine with particle
emission filter)
A low additive level is indicated by light-
ing of the service warning lamp, accom-
panied by an audible warning and a
message on the multifunction screen.
Topping up
This additive must be topped up by a
CITROËN dealer without delay.
Used products Avoid prolonged contact of used
o i l o r fl u i d s w i t h t h e s k i n .
M o s t o f t h e s e fl u i d s a r e h a r m f u l t o
health or indeed very corrosive.
D o n o t d i s c a r d u s e d o i l o r fl u i d s
into sewers or onto the ground.
Take used oil to a CITROËN
dealer (France) or an authorised
waste disposal site. CHECKS
Unless otherwise indicated, check
these components in accordance with
the Warranty and Maintenance Record
and according to your engine.
Otherwise, have them checked by a
CITROËN dealer.
B a t t e r y The battery does not require
any maintenance.
H o w e v e r , c h e c k t h a t t h e t e r -
minals are clean and correctly
tightened, particularly in summer
and winter.
When carrying out work on the battery,
refer to the "Practical information" sec-
tion for details of the precautions to be
taken before disconnecting the battery
and following its reconnection.
Air filter and passenger
compartment filter
Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
vals for these components.
Depending on the environ-
ment (e.g. dusty atmosphere) and the
use of the vehicle (e.g. city driving),
replace them twice as often if neces-
s a r y (refer to the "Engines" section).
A c l o g g e d p a s s e n g e r c o m p a r t m e n t fi l t e r
may have an adverse effect on the per-
formance of the air conditioning system
and generate undesirable odours. Oil filter
R e p l a c e t h e o i l fi l t e r e a c h t i m e
the engine oil is changed.
Refer to the Warranty and
Maintenance Record for details
of the replacement interval for
this component.
Particle emission filter (Diesel)
It is imperative that the maintenance of
t h e p a r t i c l e e m i s s i o n fi l t e r i s c a r r i e d o u t
by a CITROËN dealer.
Following prolonged operation
of the vehicle at very low speed
or at idle, you may, in excep-
tional circumstances, notice the
emission of water vapour at the
exhaust on acceleration. This
does not affect the behaviour of
the vehicle or the environment.
Page 115 of 203
1 0
CHECKS
Manual gearbox The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the Maintenance and
Warranty Guide for the details
of the level checking interval
for this component.
Automatic gearbox The gearbox does not re-
quire any maintenance (no oil
change).
Refer to the Maintenance and
Warranty Guide for details of
the level checking interval for
this component. Brake pads
Brake wear depends on the
style of driving, particularly in
the case of vehicles used in
town, over short distances. It
may be necessary to have the
condition of the brakes checked, even
between vehicle services.
Unless there is a leak in the circuit, a
d r o p i n t h e b r a k e fl u i d l e v e l i n d i c a t e s
that the brake pads are worn.
Brake disc wear
For information relating to
checking the brake disc wear,
contact a CITROËN dealer.
Parking brake If a loss of effectiveness of this
system is noticed, the parking
brake must be checked, even
between two services.
This system must be checked
by a CITROËN dealer. Only use products recommend-
ed by CITROËN or products of
e q u i v a l e n t q u a l i t y a n d s p e c i fi c a -
tions.
In order to optimise the operation
of units as important as the brak-
ing system, CITROËN selects
a n d o f f e r s v e r y s p e c i fi c p r o d u c t s .
To avoid damaging the electrical
units, the use of a high pressure
washer in the engine compart-
ment is strictly
prohibited .
Page 116 of 203
11
PRACTICAL INFORMATION
The speed limit sticker I must be
a f fi x e d t o t h e v e h i c l e ' s s t e e r i n g
w h e e l t o r e m i n d y o u t h a t a w h e e l
i s i n t e m p o r a r y u s e .
D o n o t e x c e e d a s p e e d o f
5 0 m p h ( 8 0 k m / h ) w h e n d r i v i n g
w i t h a t y r e r e p a i r e d u s i n g t h i s
t y p e o f k i t .
TEMPORARY PUNCTURE
REPAIR KIT
C o m p l e t e s y s t e m c o n s i s t i n g o f a c o m -
p r e s s o r a n d a s e a l a n t c a r t r i d g e w h i c h
permits temporary repair o f t h e t y r e
s o t h a t y o u c a n d r i v e t o t h e n e a r e s t g a -
r a g e .
I t i s d e s i g n e d t o r e p a i r m o s t p u n c t u r e s
w h i c h c o u l d a f f e c t t h e t y r e , l o c a t e d o n
t h e t y r e t r e a d o r s h o u l d e r .
T h i s k i t i s i n s t a l l e d i n t h e s t o r a g e b o x ,
u n d e r t h e b o o t fl o o r . Description of the kit
A. " S e a l a n t " o r " A i r " p o s i t i o n s e l e c t o r .
B. O n "I" / o f f "O" s w i t c h .
C. D e fl a t i o n b u t t o n .
D. P r e s s u r e g a u g e ( i n b a r o r p . s . i . ) .
E. C o m p a r t m e n t h o u s i n g :
- a c a b l e w i t h a d a p t o r f o r 1 2 V s o c k e t ,
- v a r i o u s i n fl a t i o n a d a p t o r s f o r a c c e s s o r i e s , s u c h a s b a l l s ,
b i c y c l e t y r e s . . .
F. S e a l a n t c a r t r i d g e .
G. W h i t e p i p e w i t h c a p f o r r e p a i r .
H. B l a c k p i p e f o r i n fl a t i o n .
I. S p e e d l i m i t s t i c k e r .
Access to the kit
Page 117 of 203
11
PRACTICAL INFORMATION
A v o i d r e m o v i n g a n y f o r e i g n b o d i e s
w h i c h h a v e p e n e t r a t e d i n t o t h e t y r e .
Repair procedure
S w i t c h o f f t h e i g n i t i o n .
T u r n t h e s e l e c t o r A t o t h e
" S E A L A N T " p o s i t i o n .
Check that the switch B i s i n
p o s i t i o n "O" .
1. Sealing
U n c o i l t h e w h i t e p i p e G f u l l y .
U n s c r e w t h e c a p f r o m t h e w h i t e
p i p e .
C o n n e c t t h e w h i t e p i p e t o t h e v a l v e
o f t h e t y r e t o b e r e p a i r e d .
C o n n e c t t h e c o m p r e s s o r ' s e l e c t r i c
p l u g t o t h e v e h i c l e ' s 1 2 V s o c k e t .
S t a r t t h e v e h i c l e a n d l e a v e t h e
e n g i n e r u n n i n g .
T a k e c a r e , t h i s p r o d u c t i s h a r m f u l
( e . g . e t h y l e n e - g l y c o l , c o l o p h o n y . . . )
i f s w a l l o w e d a n d c a u s e s i r r i t a t i o n
t o t h e e y e s .
K e e p i t o u t o f r e a c h o f c h i l d r e n .
Page 118 of 203
11
PRACTICAL INFORMATION
S w i t c h o n t h e c o m p r e s s o r b y m o v -
i n g t h e s w i t c h B t o p o s i t i o n "I" u n t i l
t h e t y r e p r e s s u r e r e a c h e s 2 . 0 b a r s .
T h e s e a l a n t i s i n j e c t e d i n t o t h e t y r e u n d e r p r e s s u r e ; d o n o t d i s c o n n e c t
t h e p i p e f r o m t h e v a l v e d u r i n g t h i s
o p e r a t i o n ( r i s k o f s p l a s h i n g ) .
R e m o v e t h e k i t a n d s c r e w t h e c a p
b a c k o n t h e w h i t e p i p e .
T a k e c a r e t o a v o i d s t a i n i n g y o u r v e - h i c l e w i t h t r a c e s o f fl u i d . K e e p t h e k i t
t o h a n d .
D r i v e i m m e d i a t e l y f o r a p p r o x i m a t e -
l y t h r e e m i l e s ( fi v e k i l o m e t r e s ) , a t
r e d u c e d s p e e d ( b e t w e e n 1 5 a n d
3 5 m p h [ 2 0 a n d 6 0 k m / h ] ) , t o p l u g
t h e p u n c t u r e .
S t o p t o c h e c k t h e r e p a i r a n d t h e t y r e
p r e s s u r e u s i n g t h e k i t .
I f a f t e r a r o u n d 5 t o 7 m i n u t e s
t h e p r e s s u r e i s n o t a t t a i n e d , t h i s
i n d i c a t e s t h a t t h e t y r e i s n o t r e -
p a i r a b l e ; c o n t a c t a C I T R O Ë N
d e a l e r f o r a s s i s t a n c e .
Page 119 of 203
11
PRACTICAL INFORMATION
V i s i t a C I T R O Ë N d e a l e r a s
s o o n a s p o s s i b l e .
Y o u m u s t i n f o r m t h e t e c h n i c i a n t h a t y o u h a v e u s e d t h i s k i t .
A f t e r i n s p e c t i o n , t h e t e c h n i c i a n
w i l l i n f o r m y o u w h e t h e r t h e t y r e
c a n b e r e p a i r e d o r m u s t b e r e -
p l a c e d .
2 . I n fl a t i o n
T u r n t h e s e l e c t o r A t o t h e
" A I R " p o s i t i o n .
U n c o i l t h e b l a c k p i p e H f u l l y .
C o n n e c t t h e b l a c k p i p e t o
t h e v a l v e o f t h e w h e e l .
C o n n e c t t h e c o m p r e s s o r ' s e l e c t r i c
p l u g t o t h e v e h i c l e ' s 1 2 V s o c k e t .
S t a r t t h e v e h i c l e a g a i n a n d l e a v e t h e
e n g i n e r u n n i n g .
A d j u s t t h e p r e s s u r e u s i n g t h e c o m -
p r e s s o r ( t o i n fl a t e : s w i t c h B i n p o -
s i t i o n "I" ; t o d e fl a t e : s w i t c h B i n
p o s i t i o n "O" a n d p r e s s b u t t o n C ) , i n
a c c o r d a n c e w i t h t h e v e h i c l e ' s t y r e
p r e s s u r e l a b e l ( l o c a t e d o n t h e l e f t
h a n d d o o r a p e r t u r e ) .
A l o s s o f p r e s s u r e i n d i c a t e s t h a t t h e p u n c t u r e h a s n o t b e e n f u l l y p l u g g e d ;
c o n t a c t a C I T R O Ë N d e a l e r f o r a s -
s i s t a n c e .
R e m o v e a n d s t o w t h e k i t .
D r i v e a t r e d u c e d s p e e d ( 5 0 m p h
[ 8 0 k m / h ] m a x ) l i m i t i n g t h e d i s t a n c e
t r a v e l l e d t o a p p r o x i m a t e l y 1 2 0 m i l e s
( 2 0 0 k m ) .
Page 120 of 203
11
PRACTICAL INFORMATION
Removing the cartridge
C o n n e c t t h e c o m p r e s s o r ' s e l e c t r i -
c a l c o n n e c t o r t o t h e v e h i c l e ' s 1 2 V
s o c k e t .
S t a r t t h e v e h i c l e a n d l e t t h e e n g i n e
r u n .
A d j u s t t h e p r e s s u r e u s i n g t h e c o m -
p r e s s o r ( t o i n fl a t e : s w i t c h B i n p o -
s i t i o n "I" ; t o d e fl a t e : s w i t c h B i n
p o s i t i o n "O" a n d p r e s s b u t t o n C ) ,
a c c o r d i n g t o t h e v e h i c l e ' s t y r e p r e s -
s u r e l a b e l o r t h e a c c e s s o r y ' s p r e s -
s u r e l a b e l .
R e m o v e t h e k i t t h e n s t o w i t .
S t o w t h e b l a c k p i p e .
D e t a c h t h e a n g l e d b a s e f r o m t h e
w h i t e p i p e .
S u p p o r t t h e c o m p r e s s o r v e r t i c a l l y .
U n s c r e w t h e c a r t r i d g e f r o m t h e b o t t o m .
B e w a r e o f d i s c h a r g e s o f fl u i d .
T h e e x p i r y d a t e o f t h e fl u i d i s i n -
d i c a t e d o n t h e c a r t r i d g e
T h e s e a l a n t c a r t r i d g e i s d e s i g n e d
f o r s i n g l e u s e ; e v e n i f o n l y p a r t l y
u s e d , i t m u s t b e r e p l a c e d .
A f t e r u s e , d o n o t d i s c a r d t h e c a r -
t r i d g e i n t o t h e e n v i r o n m e n t , t a k e
i t t o a n a u t h o r i s e d w a s t e d i s p o s a l
s i t e o r a C I T R O Ë N d e a l e r .
D o n o t f o r g e t t o o b t a i n a n e w
s e a l a n t c a r t r i d g e , a v a i l a b l e f r o m
C I T R O Ë N d e a l e r s . Checking tyre pressures/
inflating accessories
Y o u c a n a l s o u s e t h e c o m p r e s s o r , w i t h o u t
i n j e c t i n g a n y p r o d u c t , t o :
- c h e c k o r a d j u s t t h e p r e s s u r e o f y o u r
t y r e s ,
- i n fl a t e o t h e r a c c e s s o r i e s .
T u r n t h e s e l e c t o r A t o t h e
" A i r " p o s i t i o n .
U n c o i l t h e b l a c k p i p e H f u l l y .
C o n n e c t t h e b l a c k p i p e t o
t h e v a l v e o f t h e w h e e l o r a c c e s s o r y .
I f n e c e s s a r y , fi t o n e o f t h e a d a p t o r s s u p p l i e d w i t h t h e k i t fi r s t .
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
131
132
133
134
135
136
137
138
139
140
141
142
143
144
145
146
147
148
149
150
151
152
153
154
155
156
157
158
159
160
161
162
163
164
165
166
167
168
169
170
171
172
173
174
175
176
177
178
179
180
181
182
183
184
185
186
187
188
189
190
191
192
193
194
195
196
197
198
199
200
201
202