2010 Acura TSX engine

µ
µÎ µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µÎ
Specif ications (6-cylinder Models)
492
Battery
Engine Fuses
Lights
Capacity 12 V
12 V 55 AH/5 HR
72 AH/20 HR
3.50 x 3.66 in (89.0 x 93.0 mm) 212 cu-in (3,471 cm
)
11.2 : 1
ILZKR7B11
SXU22HCR11 12 V 60 W
12 V 35 W
Type
BorexStroke
Displacement
Compression ratio
Spark plugs Interior
Under-hood See page
480or the fuse label
attached on the side panel.
See page 481or the fuse label
attached to the inside of the fuse
box door.
See page 479or the fuse box
cover.
On vehicles with high voltage discharge type headlights,
replacement of a headlight bulb should be done by your dealer.
Headlights
Fog lights
Front turn signal/
Front parking lights/
Side marker lights
Rear turn signal lights
Stop/Taillights
High-mount brake light
Back-up lights
Rear side marker lights
License plate lights
Ceiling light
Spotlights
Trunk light
Door courtesy lights
Vanity mirror lights
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V 12 V
12 V
12 V
12 V 55 W
21/5 W
21 W
21/5 W
21 W
21 W
3CP
5W
8W
8W
5W
3.8 W
2W
Water cooled 4-stroke,
SOHC VTEC 6-cylinder (V6), gasoline engine
NGK:
DENSO:
Driver’s side
Passenger’s side
High
Low
(D2S)
(H11) (HB3)
:
2010 TSX

Î
ÎThe burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx), and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas. The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive
crankcase ventilation valve routes
them from the crankcase back to theintake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
In Canada, Acura vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured. The Clean Air Act
Crankcase Emissions Control
System Evaporative Emissions Control
System
Onboard Ref ueling Vapor
Recovery
Emissions Cont rols
500
2010 TSX

The exhaust emissions controls
includethreeorfoursystems:
PGM-FI, ignition timing control,
exhaust gas recirculation (6-cylinder
models), and three way catalytic
converter. These systems work
together to control the engine’s
combustion and minimize the
amount of HC, CO, and NOx that
come out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine howmuch air is going into the engine. It
then controls how much f uel to inject
under all operating conditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion. The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
The emissions control systems are
designed and certif ied to work
together in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Acura replacement parts or their
equivalent f or repairs. Using lower
quality parts may increase the
emissions f rom your vehicle.
6-cylinder models
2
2
Exhaust Emissions Controls
Replacement Parts
Emissions Cont rols
PGM-FI SystemIgnit ion T iming Cont rol Syst em
Exhaust Gas Recirculat ion (EGR)Syst em Three Way Catalytic ConverterTechnical Inf ormation
501
2010 TSX

Always use unleaded gasoline.
Even a small amount of leaded
gasoline can contaminate the
catalyst metals, making the three
way catalytic converter inef f ective.
The three way catalytic converter
must operate at a high temperature
for the chemical reactions to take
place. It can set on f ire any
combustible materials that come
near it. Park your vehicle away from
high grass, dry leaves, or other
f lammables.
A defective three way catalytic
converter contributes to air pollution,
and can impair your engine’s per-
f ormance. Follow these guidelines to
protect your vehicle’s three way
catalytic converter.
The three way catalytic converter
contains precious metals that serve
as catalysts, promoting chemical
reactions to convert the exhaust
gasses without af f ecting the metals.
The catalytic converter is ref erred to
as a three-way catalyst, since it acts
on HC, CO, and NOx. A replacement
unit must be an original Acura part
or its equivalent.
Keep the engine well maintained.
Have your vehicle diagnosed and
repaired if it is misf iring, back-
f iring, stalling, or otherwise not
running properly.
Three Way Catalytic Converter
502
THREE WAY CATALYTIC CONVERTERS
4-cylinder models
6-cylinder models
2010 TSX

Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
If you take your vehicle f or an
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions. If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F (4° and 35°C). Keep the vehicle in Park
(automatic) or neutral (manual).
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes).
Without touching the accelerator
pedal, let the engine idle f or 20
seconds.
1.
2.
3. 4.
5.
6.
CONT INUED
T esting of Readiness Codes
Emissions T esting
Technical Inf ormation
503
2010 TSX

Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your dealer. Make sure the vehicle has been
parked with the engine of f f or 30
minutes.
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (automatic) or 5th (manual). Do
notusethecruisecontrol.When
traffic allows, drive for 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).
7.
8.
9.
Emissions T esting
504
2010 TSX

T he publications shown below can be purchased f rom Helm
Incorporated. You can order by phone or online:Call Helm Inc. at 1-800-782-4356 (credit card orders only)
Go online at
If you are interested in other years or models, contact Helm Inc.
at 1-800-782-4356.Covers maintenance and recommended procedures f or
repair to engine and chassis components. It is written
f or the journeyman mechanic, but it is simple enough
f or most mechanically inclined owners to understand.
Complements the Service Manual by providing in-depth
troubleshooting inf ormation f or each electrical circuit
in your vehicle.
Describes the procedures involved in the replacement
of damaged body parts.
Authorized Manuals
Purchasing Factory Authorized Manuals Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
(U.S. only)
Authorized Manuals
509
Form Description
2009-2010 Acura TSX Service Manual 2010 Acura TSX V6 Service Manual 2009-2010 Acura TSX
Electrical Troubleshooting Manual 2010 Acura TSX V6
Electrical Troubleshooting Manual
2009-2010 Acura TSX Body Repair Manual 2010 Acura TSX Owner’s Manual2010 Acura TSX NavigationSystem Owner’s Manual
2010 Acura TSX Maintenance Journal
2010 Acura TSX Advanced Technology Guide Order Form for Previous Years-
Indicate Year and Model Desired
Publication
Form Number 61TL201
61TP100
61TL201EL
61TP100EL 61TL230
31TL1610
31TL1810
31TL1M10 31TL1Q10 ACU-R
www. helminc. com
2010 TSX

CONT INUED
........................................
AAC .210, 271
....................................
Accessories .357
ACCESSORY ............
(Ignition Key Position) . 122
............
Accessory Power Sockets . 156
................
Active Head Restraints . 137
................
AcuraLink
(U.S. only) . 328
....................
Additives, Engine Oil . 416
...........................
Advanced Airbags .27
...............................
Airbag (SRS) .9, 23
..........
Airbag System Components . 23
..............
Air Conditioning System . 166
.........................................
Usage .167
.......
Air Pressure, Tires . 447,490,493
......................................
Antif reeze .420
Anti-lock Brakes (ABS) ...............................
Indicator .62, 384
...................................
Operation .384
..............
Anti-thef t, Audio System . 288
Anti-thef t Steering Column ............................................
Lock .122
................................
Audio System .174
Auto Door Locking/ ..........................
Unlocking .100, 106 ...
Automatic Seat Belt Tensioners . 21
.............
Automatic Speed Control . 298
..............
Automatic Transmission . 373
..................
Capacity, Fluid . 488, 491
..........................
Paddle Shif ters .377
.......................................
Shif ting .373
Shif t Lever Position ...............................
Indicators .373
................
Shif t Lever Positions . 374
....................
Shif t Lock Release . 375
......................
Auxiliary Input Jack .287
Battery Charging System ...........................
Indicator .61, 471
............................
Jump Starting .466
..............................
Maintenance .453
....................
Specif ications .489, 492
..............................
Bef ore Driving .345
....................................
Belts,Seat .8,19
.........................
Beverage Holders .155
...................
Audio . 217,279
........
HandsFreeLink
. 304
..................................
Booster Seats .52 Brakes
...........
Anti-lock System (ABS) . 384
.............
Break-in, New Linings . 346
....................
Bulb Replacement .435
...........................................
Fluid .427
.......................................
Parking .153
.................
System Indicator . 61,473
........................
Wear Indicators .383
.............................
Braking System .383
.................
Break-in, New Vehicle . 346
Brightness Control, ...............................
Instruments .115
Bulb Replacement ..........................
Back-up Lights .436
..............................
Brake Lights .435
.................................
Fog Lights .439
................
Front Parking Lights . 434
.................................
Headlights .429
.........
High-mount Brake Light . 438
........................
Rear Lights .435, 436
....................
Specif ications .489, 492
............
Turn Signal Lights . 434,435
......................
Bulbs, Halogen .429, 439
Bluetooth
Bluetooth
Index
A
B
INDEX
I
2010 TSX