2009 TOYOTA TUNDRA steering

5
When trouble arises
575
5-2. Steps to take in an emergency
If the engine will not star t
If the engine still does not start after following the correct starting
procedure ( P. 177) or releasing the steering lock (P. 178), confirm
the following points.
■ The engine will not start even when the starter motor oper-
ates normally.
One of the following may be the cause of the problem.
●There may not be sufficient fuel in the vehicle’s tank.
Refuel the vehicle. (
P. 103)
Flex-fuel vehicles: The type of fuel may be different. When
refueling, add the same type of fuel, if available.
After adding a different type of fuel, the engine may run
roughly and driving performance may be reduced for a while
when the engine is first started. In this case, wait until the
engine runs normally.
● The engine may be flooded.
Try to restart the engine once more following correct starting
procedures.
● There may be a malfunction in the engine immobilizer system.
(  P. 108)
■ The starter motor turns over slowly, the interior lights and
headlights are dim, or the horn does not sound or sounds at
a low volume.
One of the following may be the cause of the problem.
●The battery may be discharged. ( P. 581)
● The battery terminal connec tions may be loose or corroded.

614 6-1. Specifications
Brakes
*1: Minimum pedal clearance when depressed with a force of 110 lbf (490 N,50 kgf) with the engine running.
*2: Parking brake pedal travel when depressed with a force of 67.1 lbf (300 N,30.6 kgf).
Chassis lubrication
Steering
Pedal clearance *14.1 in. (104 mm) Min.
Pedal free play 0.04  0.20 in. (1  5 mm)
Brake pad wear limit 0.04 in. (1.0 mm)
Parking brake lining wear limit 0.04 in. (1.0 mm)
Parking brake pedal travel *26 — 9 clicks
Fluid type FMVSS No. 116 DOT 3 or SAE J1703
Propeller shafts Spider
Slide yokeLithium base chassis grease, NLGI No.2
Molybdenum — disulfide lithium base
chassis grease, NLGI No.2 or lithium
base chassis grease, NLGI No.2
Free playLess than 1.2 in. (30 mm)
Power steering fluid type
Automatic transmission fluid DEXRON® II
or III

627
6-1. Specifications
6
Vehicle specifications
Warning: The temperature grades for this tire are established for a
tire that is properly inflated and not overloaded.
Excessive speed, underinflation,
or excessive loading, either
separately or in combination, can cause heat buildup and possible
tire failure.
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation
pressure
Tire pressure when the vehicle has been
parked for three hours or more, or has not
been driven more than 1 mile or 1.5 km under
that condition
Maximum inflation
pressureThe maximum cold inflated pressure to which a
tire may be inflated, s hown on the sidewall of
the tire
Recommended
inflation pressureCold tire inflation pressure recommended by a
manufacturer
Accessory weight
The combined weight (in excess of those
standard items which may be replaced) of
transmission, power steering, power brakes,
power windows, power seats, radio and heater,
to the extent that these items are available as
factory-installed equipment (whether installed
or not)
Curb weight
The weight of a motor vehicle with standard
equipment, including the maximum capacity of
fuel, oil and coolant, and if so equipped, air
conditioning and additional weight optional
engine
Maximum loaded
vehicle weight
The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight

656
Alphabetical index
Alphabetical index
A/C ..................................... 276, 285
ABS ........................................... 230
Accessory meter ...................... 204
Active traction control system .................................... 230
Air conditioning filter............... 507
Air conditioning system Air conditioning filter .............. 507
Automatic air conditioning system ................................ 276
Manual air conditioning system ................................ 285
Airbags
Airbag operating conditions............................ 118
Airbag precautions for your
child .................................... 123
Airbag warning light............... 546
Curtain shield airbag operating conditions............ 119
Curtain shield airbag precautions ......................... 125
Front passenger occupant classification system ........... 131
General airbag
precautions ......................... 122
Locations of airbags .............. 115
Modification and disposal of airbags ............................ 126
Passenger airbag off switch .......................... 127, 146
Proper driving posture ........................ 113, 122
Roll sensing of curtain shield airbag off switch .................. 129
Side airbag operating conditions............................ 119
Side airbag precautions ........ 124
SRS airbags .......................... 115
Alarm ......................................... 110
Antenna..................................... 304
Anti-lock brake system ABS warning light .................. 546 Anti-lock brake system .......... 230
Armrest ..................................... 444
Ashtray ..................................... 429
Audio input ............................... 325
Audio remote controls ............ 327
Audio system A/V input adapter .................. 350
Antenna................................. 304
Audio input ............................ 325
Audio visual input .................. 350
AUX adapter ......................... 325
CD player/changer ................ 307
DVD player............................ 336
MP3/WMA disc ..................... 314
Optimal use ........................... 323
Portable music player ........... 325
Radio..................................... 301
Rear seat entertainment system ................................ 329
Steering wheel audio switch.................................. 327
Type ...................................... 298
Audio visual input.................... 350
AUTO LSD system ................... 227
Automatic light control system .................................... 208
Automatic transmission Automatic transmission ......... 180
If the shift lever cannot be
shifted from P ..................... 577
TOW/HAUL switch ................ 183
AUX adapter ............................. 325
Auxiliary boxes ....................... 419
A/V input adapter ..................... 350
Back-up lights Replacing light bulbs ............. 528
Wattage................................. 617
Back window Back window ........................... 96
Power back window ................ 97
Back window defogger............ 295A
B

660 Alphabetical index
I/M test....................................... 470
IdentificationEngine ................................... 604
Tire ........................................ 623
Vehicle .................................. 603
Ignition switch .......................... 177
Illuminated entry system ......... 393
Immobilizer system.................. 108
Indicator lights ......................... 194
Initialization Items to initialize.................... 636
Engine oil maintenance
data ..................................... 483
Moon roof .............................. 101
Tire pressure warning
system ........ ....................... 495
Inside rear view mirror ..............85
Interior lights
Interior lights.......... 393, 394, 395
Personal lights....... 393, 394, 395
Switch.................................... 394
Wattage ................................. 617
Instrument panel light
control .................................... 193
Intuitive parking assist ............ 217
Jack Positioning the jack ............... 568
Replacing the wheel .............. 558
Jack handle ...................... 564, 568
Keyless entry..............................44
Keys Engine switch ........................ 177
If you lose your keys ............. 580
Ignition switch........................ 177
Keyless entry...........................44
Key number .............................42
Keys ........................................42
Wireless remote control ..........44 License plate lights
Replacing light bulbs ............. 530
Switch ................................... 207
Wattage................................. 617
Light bulbs
Replacing .............................. 522
Wattage................................. 617
Lights
Automatic light off system ..... 208
Cargo lamp switch ................ 397
Emergency flasher switch.................................. 534
Fog light switch ..................... 210
Hazard light switch ................ 534
Headlight switch .................... 207
Instrument panel light control dial .......................... 193
Interior light switch ........ 394, 395
Outer foot lights..................... 393
Personal light switch ............. 395
Replacing light bulbs ............. 522
Turn signal lever ................... 185
Vanity lights........................... 425
Wattage................................. 617
Load capacity ........................... 244
Lock steering column.............. 178
Luggage storage box ...... 398, 422
Luggage compartment features .................................. 447
Maintenance Do-it-yourself maintenance ....................... 471
General maintenance............ 467
Maintenance data ................. 590
Maintenance requirements ... 465
Vehicle exterior ..................... 460
Vehicle interior ...................... 462
Malfunction indicator lamp ..... 546
Manual air conditioning system .................................... 285
Master warning light ........ 548, 554
Map holder................................ 406I
J
K
L
M

661
Alphabetical index
Meter
Accessory meter................... 204
Instrument panel light
control ................................ 193
Meters .................................. 188
Mirrors Inside rear view mirror ............ 85
Side mirror heaters ....... 293, 295
Side mirrors ............................ 88
Vanity mirrors ....................... 425
Moon roof................................... 99
MP3 disc................................... 314
Multi-information display ................................... 198
Odometer ................................. 188
Off-road precautions............... 236
Oil Engine oil.............................. 479
Warning light ................ 546, 548
Opener Hood ..................................... 475
Outside rear view mirrors Adjusting and folding .............. 88
Outside temperature
display ................................... 427
Overhead console ................... 413
Overheating, Engine ............... 585
Parking assist .......................... 217
Parking brake .......................... 186
Parking lights Replacing light bulbs ............ 525
Switch ................................... 207
Wattage ................................ 617
Passenger airbag off switch
Installing the child restraint system................................ 146
Passenger airbag off switch
precautions ........................ 141
Passenger airbag off switch ................................. 127 Passenger risk group ............128
Pen holder ................................409
Personal lights
Switch....................................395
Wattage .................................617
Power back window ...................97
Power outlet .....................432, 437
Power steering Fluid ..............................488, 614
Power windows ..........................94
Radiator ....................................486
Radio .........................................301
Rear seat Adjustment ..............................63
Folding down ...........................65
Raising the bottom cushion .....64
Rear seat entertainment system ....................................329
Rear seat entertainment system controller battery......333
Rear side marker lights
Replacing light bulbs .............528
Switch....................................207
Rear seat adjustment.................63
Rear seat adjustment
precautions ..............................66
Rear turn signal lights
Replacing light bulbs .............528
Switch....................................185
Wattage .................................617
Rear view mirror Anti-glare ...........................85, 92
Compass ...............................455
Rear window .........................96, 97
Replacing Fuses ....................................512
Light bulbs .............................522
Tires ......................................558
Wireless remote control
battery .................................510
Wheels ..................................505
Rear step bumper ......................56
O
P
R

663
Alphabetical index
Steering
Column lock release ............... 83
Steering wheel Adjustment ............................. 83
Audio switches ..................... 327
Steering wheel memory.......... 68
Telephone switches.............. 365
Stop lights
Replacing light bulbs ............ 528
Wattage ................................ 617
Storage feature ........................ 398
Storage precautions ............... 243
Stuck If your vehicle becomes
stuck................................... 588
Sun visors ................................ 424
Switch Cruise control switch ............ 214
Emergency flasher switch .... 534
Engine switch ....................... 177
Fog light switch..................... 210
Front-wheel drive control switch ................................. 223
Ignition switch ....................... 177
Light switches ....................... 207
Hazard light switch ............... 534
Headlights switch ................. 207
Passenger airbag off switch ................................. 127
Power back window switch..... 97
Power door lock switch........... 48
Power window switch ............. 94
Roll sensing of curtain shield airbag off switch ................. 129
Tire pressure warning
reset switch ........................ 495
TOW/HAUL switch ............... 183
Turn signal lights .................. 185
VSC OFF switch ... 227, 232, 233
Window lock switch ................ 95
Wiper and washer switch ..... 211 Tachometer...............................188
Tailgate
Removing the tailgate .............53
Tailgate ...................................52
Tail lights
Replacing light bulbs .............528
Switch....................................207
Wattage .................................617
Talk switch................................365
Telephone switch .....................365
Theft deterrent system Alarm .....................................110
Engine immobilizer system ... 108
Theft prevention labels............112
Tire inflation pressure .............501
Tire information Glossary ................................627
Size .......................................624
Tire identification number ......623
Uniform tire quality
grading ................................625
Tires Chains ...................................247
Checking ...............................494
Identification number .............623
If you have a flat tire ..............558
Inflation pressure...........501, 615
Information ............................622
Inflation pressure sensor .......495
Replacing ..............................558
Rotating tires .........................494
Size .......................................615
Snow tires .............................246
Tire pressure warning reset switch .........................495
Tire pressure warning system ........................494, 548
Warning light .........................548
Tissue pocket ...........................411
Tools .........................................558
Total load capacity...................244
TOW/HAUL switch ...................183T