2009 PORSCHE CAYMAN headlights

Practical Tips, Emergency Service
251
Changing bulb for low beam/high beam
Bi-Xenon headlights1. Unscrew the 3 screws A on the control unit and
remove the control unit. 2. Turn the plug counter-clockwise and pu
ll it off. 3. Disengage both fixing clips.
4. Replace defective bulb.When doing so, ensure bulb is seated properly.
5. Engage both fixing clips, push on plug and turn right as far as the stop.
6. Fit control unit and screw tight.
Closing the cover of the headlight housing
1. Push on cover until it is felt to engage.
2. Fasten cover with the 4 screws.

252
Practical Tips, Emergency Service
Changing bulb for additional high beam
Bi-Xenon headlights1. Turn housing cover counter-clockwise and take it off. 2. Pull off plug. 3. Disengage fixing clip.
4. Replace defective bulb.
5. Engage fixing clip, insert plug and close housing cover.

Practical Tips, Emergency Service
253
Changing bulb for turn signal light
Halogen/Bi-Xenon headlights1. Turn housing cover counter-clockwise and take it off. 2. Turn bulb holder counter-clockwise and
remove it (bayonet lock). 3. Replace the defective bulb (bayonet lock).
4. Insert the bulb holder and turn it clockwise.
5. Close the housing cover.

256
Practical Tips, Emergency Service
3. Remove side marker and undo bulb holder
(bayonet lock).
4. Remove the bulb from the holder and replace it. Insert holder.
Check operation of the light.
5. Insert the side marker’s retaining lugs A into
the side section at the front.
Push in side marker until the securing spring B
is felt to engage.
6. Press the cap into the wheel housing liner.
Number Plate LightChanging bulb1. Unscrew both screws A and take off the light
lens.
2. Remove defective bulb from between the contact springs and replace.
3. Reassemble in reverse order. Check operation of the light.
Changing Light-Emitting Diodes
and Long-Life BulbsThe following lights are equipped with light-
emitting diodes (LEDs) or long-life bulbs and
cannot be replaced individually. Replacement also
involves a greater amount of installation work.
– Side light, front,
– Daytime driving lights on vehicles with Bi-Xenon headlights,
– Tail lights and
– Additional brake lights
f Have the defective light replaced at an autho-
rized Porsche dealer.

Practical Tips, Emergency Service
257
Adjusting HeadlightsfPlease see the chapter “LIGHTS, REPLACING
BULBS” on Page 247.
Adjustment
The adjustment is made wi th the vehicle ready to
drive and the fuel tank completely filled.
The driver’s seat must be loaded by a person or a
165 lbs. (75 kg) weight and the tire pressures
must meet the prescribed values.
After being loaded, the car must be rolled a few
meters so that the suspension can settle.
For checking the headlight adjustment, the verti-
cal position of the cutoff of the lowbeam (see fig.)
has to be projected on a ve rtical screen (wall) in
distance of 24.6 ft. (7.5 m) from the front lens of
the headlamp.
The correct position of the cutoff is 2.0 in. (5 cm)
at 24.6 ft. or 7.5 m (0.4 °) below a horizontal line,
x cm from ground to the center of the headlamp
lens. Lateral adjustment of the
headlights should be
carried out at a specialist workshop with an optical
adjustment unit.
Distance
Visual aim shall be perf ormed at not less than
24.6 ft./7.5 m (this value is a rounded down con-
version from the 25-foot distance typical of field
aim using a screen). The 24.6 ft./7.5 m distance
is measured from the headlamp lens to the view-
ing screen.

Index
275
AABS (antilock brake system) .......................... 59
Warning light .......... .............................. 60
Adaptive sports seat ..................................... 33
Adjusting Headlights.... ................................ 257
Advanced Airbag......... .................................. 45
Air conditioning ........... ................................ 110
Air conditioning compressor ................ 113, 115
Air conditioning system .................... ........... 113
Air distribution ................ ............ 110, 113, 115
Air filter ...................... ................................ 201
Air intake.................... ................................ 116
Airbag ............................ .............................. 44
Cleaning covers ...... ............................ 208
Function ..................... .......................... 45
Warning light .......... .............................. 48
Air-conditioning compressor ........................ 112
Alarm system ................. ...................... 25, 103
Deactivating passenger compartment
monitoring .............. .............................. 26
Fault indication........ .............................. 26
Function indication ................................ 25
Not active .............. ............................ 236
Alcantara, cleaning . .................................... 209
Antenna ................. .................... 103, 104, 204
Antifreeze .................................................. 187
Antilock brake system (ABS) .......................... 59
Warning light .......... .............................. 60
Ashtray .......................... .............................. 89
Assembly aids for wheel changes................. 227
Audio operation .............. .................... 101, 102
Auto-button, air conditioning ........................ 113
Automatic Air conditioning system ....................... 113 Anti-glare mirrors .......................
...........30
Car washes .............. ..........................204
Door locking ............. ......................18, 24
Garage door ......... ................................76
Headlight adjustment .............................79
Speed control .........................86, 87, 124
Transmission ............ ..........................178
Automatic speed contro l..............................124
Indicator light ........ ..............................124
Average consumption .... ......................135, 165
Average speed ............. ......................135, 165
BBackrest
Adjustment ............... ............................32
Release .................... ............................32
Battery ......................... ..............................239
Care......................... ..........................240
Charge state......... ..............................239
Charging .................. ..........................240
Putting vehicle into operation ...............241
Remote control ..... ..............................244
Removing ................. ..........................242
Replacing ................. ..........................241
Warning light......... ..............................132
Winter operation.... ..............................241
Before driving off ...... ..................................8, 9
Belts ................ ............................................42
Cleaning ................... ..........................209
Tensioner ................. ............................42
Warning light......... ................................43
Blower adjustment ........ ......................110, 116
Blower speed adjustme nt ............................114 Brake
Break in ................... ............................ 10
Pads ....................... ............................ 58
Pedal....................... ............................ 57
Wear ....................... ............................ 58
Brake fluid Changing ................. .......................... 193
Checking level ...... .............................. 192
Level ....................... .......................... 192
Warning light ............ .......................... 193
Brake light .............. ................................... 256
Brake light, addition al ................................. 256
Brakes ........................ .............................. 192
Brake circuit division warning light ....... 193
Brake warning light ............................. 132
Fluid ............................ .............. 192, 271
Fluid warning light. .............................. 193
Function .................. ............................ 56
New brake pads or linings ..................... 58
Pads ....................... ............................ 10
Parking brake....... ................................ 55
Porsche Ceramic Composite Brake
(PCCB) .................................... .............. 4
Test stand ........... ................................ 65
Break in brakes ....... ..................................... 10
Break in hints .......... ..................................... 10
Bulbs Chart ....................... .......................... 247
Replacing ................ .......................... 247

Index
277
Stopping .............................................. 76
Engine compartment Blower ....................... .................. 76, 128
Blower fan .............. ............................ 128
Care .................................................. 205
Engine oil Change .............................................. 190
Consumption ............................... ......... 10
Performance class .. ............................ 191
Recommendation ........ ........................ 190
Topping off............. ............................ 189
Viscosity ................ ............................ 191
Exhaust Pipes ......................... ............................ 5
System ................................................ 55
Tailpipes, stainless st eel ...................... 207
External antenna ......... ................................ 104
FFiller flap .................................................... 195
Fire extinguisher ........................................... 85
Flat tire ...................... ................................ 229
Floor mats.................. ................................ 209
Fluids ......................................................... 201
FM reception .............................................. 101
Fog light ........................ .............................. 80
Fog light, rear................. ........................ 78, 80
Fog lights
Changing bulb......... ............................ 254
Footbrake ........................................... ......... 56
Footwell lights ............ .................................. 69
Fresh air intake ........... ................................ 116
Front lid ......................... ...................... 94, 100
Front luggage compartm ent .......................... 94 Fuel .....................
..............................130, 195
Containers ................ ......................4, 197
Economy .................. ..........................194
Evaporation control .............................197
Fuels containing etha nol.......................197
Level gage ............... ..........................130
Level warning light ..............................130
Recommendation ........................196, 197
Recommendations .... ..........................196
Tank ..................................................196
Function keys ........... ....................................40
Fuses, replacing ....... ..................................237
GGarage
Door ....................................................76
Door opener .......................................106
Lift ............... ......................... .............232
Gear display ................. ......................120, 122
Gear shift indicator ......................................127
Glove compartment... ....................................92
Gong.................... ..............14, 73, 78, 80, 137
Ground clearance...... ......................................4HHandbrake.................... ................................55
Hands-free microphone ...............................104
Head restraints ......... ....................................32
Headlights .................... ..............................248
Adjusting .................. ..................257, 258
Beam adjustment .. ................................79
Changing bulbs ......... ..................249, 251
Cleaning system ...................82, 200, 271 Flasher ................................................ 81
Removing ................
.......................... 248
Heated rear window ..................................... 31
Heated rear window/Door mirror heating ..... 117
Heater ......................... .............................. 113
Heating ........................................... .......... 110
High beam Indicator light ....... .............................. 127
Lever....................... ...................... 78, 80
High beam, additional Changing bulb ...... .............................. 251
High-pressure cleaning units........................ 203
Home mode..................... ...................... 79, 80
HomeLink .................... .............................. 106
Hoods ............................. .................... 94, 100
Horn ........................................... .......... 12, 21
Hot exhaust pipes ... ....................................... 5
IIgnition key ............. ..................................... 72
Emergency operation ........................... 74
Ignition lock ............ ..................................... 72
Withdrawing ignition key,
PDK transmission ..................... .......... 180
Immobilizer ...................................... ............ 15
Indicator lights ................. .................. 120, 122
INFO Warning message s ............................. 140
Instrument
Illumination........... .............................. 124
Lights ...................... ...................... 78, 80
Panel ........................... ...... 120, 122, 166
Interior ............................................ ............ 69
Interior lights .......... ..................................... 69
Interior mirror ......... ..................................... 30