2009 OPEL MERIVA fuel cap

88 Instruments, Controls
Picture no: 17906s.tif
Coolant temperature display
Coolant temperature display For physical reasons, the engine
temperature gauge shows the coolant
temperature only if the coolant level is
adequate.
During operation the system is pressurised.
The temperature may therefore rise briefly
to over 100 C.
Picture no: 17907s.tif
Fuel gauge
Fuel tank level display.
If the fuel level is too low, a warning lamp
lights up
Y. When the light flashes, refuel as
soon as possible.
Never run the tank dry!
Because of the fuel remaining in the tank,
the amount of fuel required to fill the
tank may be less than the specified tank
capacity.
Pointer in zone at
left
= Engine operating
temperature not yet
reached.
Pointer between
the zones = Normal operating
temperature.
Pointer in zone at
right (warning
zone) = Temperature too
high: Stop vehicle
and switch off
engine. Danger to
engine. Check
coolant level
immediately 3 213.

140 Driving and operationFuel filler cap
Only a Opel Genuine fuel filler cap provides
full functionality. Diesel-engined vehicles
have special fuel filler caps.
Picture no: 15829t.tif
Refuelling
9 Warning
Before refuelling, switch off engine and
any external heaters with combustion
chambers 3 (identified by sticker on
tank flap). Switch off any mobile
phones.
Follow the operating and safety
instructions of the filling station when
refueling.
9 Warning
Fuel is flammable and explosive. No
smoking. No naked flames or sparks.
If you can smell fuel in your vehicle, have
the cause of this rectified immediately
by a workshop.

141
Driving and operation
Picture no: 14191s.tif
Fuel filler neck at right rear side of vehicle.
The tank flap is locked together with the
doors 330.
Open tank flap.
Unscrew the fuel filler cap, remove and
suspend from the tank flap.
The fuel tank has a limiting system which
prevents overfilling of the tank. Correct filling depends to a large extent on
proper operation of
the fuel dispensing
pump:
1. Fully insert the pump nozzle and switch it on.
2. After automatically switching off, the specified tank capacity is achieved by
means of metered re fuelling (twice).
Insert fuel dispensing pump as far as
possible.
To close, place fuel filler cap in position and
turn, overcoming the resistance until the
ratchet on the cap engages audibly. Close fuel tank cover.
Caution
Wipe off any overflowing fuel
immediately.

154 Driving and operationFitting new tyres
Fit tyres in pairs or in sets, which is even
better. Ensure that tyres on one axle are
zthe same size
z the same design
z the same make
z and have the same tread pattern
Fit directional tyres such that they roll in the
direction of travel. The rolling direction is
indicated by a symbol (e.g. an arrow) on
the sidewall.
Tyres fitted opposing the rolling direction
(such as when changing a tyre) should be
refitted as soon as possible. This is the only
way to benefit fully from the design
properties of the tyre.
Pay attention to legal requirements when
disposing of tyres.
Picture no: 14194s.tif
Tyre pressure
Check tyre pressure, including the spare
wheel, at least every 14 days and prior to
any long journey; the tyres should be
checked when cold. Do n’t forget to check
the spare wheel 3.
Remove the valve cap key from the tank
flap and use it to unscrew the valve cap.
Tyre pressure 3228 and on the adhesive
label 3 on the inside of the tank flap.
The tyre pressure data is for cold tyres. It
applies to both summer and winter tyres. Always inflate the spare wheel
3 to the
pressure specified for full load.
Do not reduce tyre pressure when the tyres
are warm. Otherwise the pressure may
drop below the permissible minimum when
the tyres cool down.
After having checked the tyre pressure,
tighten the valve caps using the valve cap
key.
Incorrect inflation pressures will impair
safety, vehicle handling, comfort and fuel
economy and will increase tyre wear.

218 Technical DataTechnical Data
Vehicle dataThe technical data is determined in
accordance with European Community
standards. We reserve the right to make
modifications. Specifications in the vehicle
documents always have priority over those
given in this manual.
Picture no: 14247s.tif
The identification plate is affixed to the
front right door frame.
Vehicle data ......................................... 218
Engine data.......................................... 220
Performance......................................... 222
Fuel consumption, CO
2 -emissions .....
224
Weights, payload and roof load ........ 226
Tyres ..................................................... 228
Capacities ............................................ 230
Dimensions ........................................... 231
Mounting dimensions of towing equipment 3...................................... 232

230 Technical DataCapacities Engine oil
Engine Z 14 XEP Z 16 XEP,Z 16 LETZ 18 XE Z 13 DTJ Z 17 DT,
Z 17 DTRZ 17 DTH
Including filter [I] 3.5 4.5 4.25 3.2 5.4 5.0
Between MIN and MAX [I] 1.0 1.0 1.0 1.0 1.0 1.0
Fuel tank
Petrol/diesel, nominal
capacity [l] 53 53 53 53 53 53

234 IndexIndex
AABS (Anti-lock Brake System) ................ 152
Accessories.............................................. 171
Accessory socket ...................................... 78
Adaptive brake lamp ............................. 152
Adaptive Forward Lighting ................... 106Bulb replacement ............................... 188
Driving abroad.................................... 110
Adaptive Forward Lighting (AFL) ......... 106 Bulb replacement ............................... 188
Driving abroad.................................... 110
Air conditioning system ......................... 114
Air intake ................................................. 127
Air recirculation system.................. 119, 126
Air vents .................................................. 115
Airbags ...................................................... 67
Alarm ......................................................... 36
Alarm system ............................................ 34
Alternator .................................................. 85
Antenna .......................................... 111, 196
Anti-corrosion service............................. 208
Antifreeze........................................ 208, 212
Antifreeze protection ..................... 212, 216
Anti-knock quality of fuel Octane number................................... 220
Anti-theft alarm system ........................... 34
Anti-theft lock Alloy wheels ........................................ 175
Anti-theft lockin g system ......................... 31
Towing equipment ............................. 160
Aquaplaning ........................................... 156
Armrest...................................................... 48
Ashtray ...................................................... 79 Automatic anti-dazzle interior mirror..... 39
AUX input ............................................... 112
Auxiliary heater ...................................... 127
BBattery ............................................ 136, 216
Interruption of power supply ....... 41, 134
Battery discharge protection ................ 110
Before starting off .................................... 15
Belt tensioners .......................................... 60
Bleeding, diesel fuel system .................. 165
Bonnet ..................................................... 165
Boot, see Luggage compartment..... 32, 53
Brake assist ............................................. 153
Brake fluid ............................................... 208
Brake lamp ............................................. 152
Brake system .......................................... 151
Brakes ABS ...................................................... 152
Brake assist ......................................... 153
Brake fluid ........................................... 214
Brake lamps ........................................ 191
Brake servo unit .................................. 135
Hand brake ......................................... 153
Bulb replacement ................................... 185
Bulbs ........................................................ 184CCapacities ............................................... 230
Car Pass .................................................... 26
Caravan/trailer towing........................... 135
Care ......................................................... 196
Catalytic converter ......................... 145, 166
Central locking system ....................... 28, 30

238 IndexRear seats.................................................. 51
Rear window washer system ...13, 101, 215
Refuelling................................................. 140Fuel filler cap ....................................... 141
Remote control Central locking system ......................... 28
Steering wheel ............................... 24, 111
Replacement keys .................................... 26
Reversing lamps...................................... 107 Bulb replacement................................ 191
Roof load .......................... 58, 135, 138, 226
Roof rack ...................................58, 138, 158
Roof racks ......................................... 58, 138
Running-in ............................................... 135 Brakes .................................................. 213SSafeguard against unauthorised use ..................15, 17, 27, 36
Safety accessories .................................. 171
Safety net .................................................. 56
Safety systems ........................................ 111
Saving energy ......................................... 136
Seat adjustment ............................. 2, 44, 51
Seat belts........................................... 62, 198
Seat height adjustment ........................ 3, 45
Seat occupancy recognition .................... 72
Seat position ................................... 2, 44, 45
Seats ...................................................... 2, 44 Extending the luggage
compartment .................................. 32, 53
heated ................................................... 46
Selector lever ........................................... 130
Self-diagnosis ..............................61, 72, 153 Self-help
Central locking ...................................... 31
Electric windows.................................... 40
Information display .............................. 92
Radio remote control ........................... 29
Self-help, care for your car .................... 165
Service interval display .......................... 208
Service intervals ...................................... 199 additional work ................................... 206
hard driving conditions ...................... 206
main inspection .................................. 199
Service work ............................................ 208
Side airbags .............................................. 69
Signal system ...................................... 11, 12
Spare wheel .................................... 172, 174
Speed............................................... 137, 138 Fuel consumption ....................... 137, 138
Speedometer ............................................ 87
Starting the engine.............15, 27, 130, 166 Self-help............................................... 166
Steam-jet cleaners.................................. 198
Steering column lock ................................ 15
Steering wheel adju stment ........................ 5
Steering wheel remote control ........ 24, 111
Stowage compartments .......................... 80
Sun roof ..................................................... 42 Fault....................................................... 43
Sun shade ................................................. 43
Sun visors .................................................. 81
System settings ......................................... 94
TTables ........................................................ 81
Tachometer............................................... 87 Tail lamps ............................................... 102
Bulb replacement ............................... 191
Tank Fuel gauge ............................................ 88
Technical data ....................................... 218
Telephone, see Mob ile telephone ......... 113
Temperature regulation ........................ 123
Tempomat, see cruise control ............... 148
Temporary spare wheel ................. 158, 173
The first 1000 km .................................... 135
Tightening torque .......................... 177, 228
Time........................................................... 92
Toll systems ............................................ 112
Tools ........................................................ 171
Towing equipment ................................. 158
Towing eye ..................................... 168, 170
Transmission ............................................. 14 Manual transmission .......................... 134
Transmission, Easytronic ....................... 129 Driving programmes .......................... 131
fault ..................................................... 133
Interruption of power supply ............. 134
Kickdown............................................. 132
Selector lever................................. 15, 130
Winter programme ............................. 132
Travel Assistant ............................ 22, 48, 49
Tread depth ............................................ 155
Trip computer ..................................... 23, 97
Trip odometer ........................................... 87
Triple information display ....................... 90
Turn signal lamps ............................. 11, 103
Turn signals Bulb replacement ....................... 190, 191
Twin Audio ........................................ 24, 112