2009 OPEL CORSA service interval

237
Opel Service, maintenance
⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)Depending on what occurs first.
1
15 2
30 3
45 4
60 5
75
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to
bolt taper when fitting.
Check tyre condition and pressure (inclu ding spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20000 km.
Visually check the first aid kit (that it is wher e it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle every 2 years
Check headlamp settings (including auxi liary headlamps), adjust if necessary x x
⊕o
Lubricate door hinges, check arms, cylinder lo ck, door latch, bonnet catch, rear panel
hinge xx
OPC: check function of central locking system
clean door lock from outside and grease xxxxx
Test run, final check (check steering and ig nition lock, instrument and warning lamps,
entire brake system, steering, air conditioni ng system, engine, bodywork and chassis,
reset service/interval display with TECH 2. xxxxx
Back to overview

238 Opel Service, maintenanceAdditional service workAdditional work ⊕
Additional work is not always necessary at
each service, but can be carried out at the
same time as a regular service.
T h e c o s t o f th i s t y p e o f w o r k i s n o t i n c l ud e d
in the charge for a regular service and will
be invoiced separately. It is, however, more
c o s t - e f f e c t i v e t o h a v e t h i s w o r k d o n e a t t h e
same time as a scheduled service rather
than have it done separately.
Hard driving conditions o
Conditions are considered hard when one
or more of the following situations occurs
more frequently:
z cold start,
z stop and go,
z caravan/trailer towing,
z inclines or steep climbs,
z poor road conditions,
z sand and dust,
z extreme temperature fluctuations.
Police vehicles, taxis and driving school
vehicles are classified as being subjected to
hard driving conditions. With hard driving conditions it might be
necessary to carry out certain service work
more frequently than the scheduled
intervals.
We recommend seeking technical advice
with regard to servic
ing requirements for
your particular driving circumstances.
Recommended fluids and
lubricants Only use products which have been tested
and approved. Damage caused by using
operating materials which have not been
approved is not covere d by the guarantee.
Engine oil
Engine oil is graded by quality and
viscosity. When choosing an engine oil, the
quality grade is more important than the
viscosity. Engine oil for Service schedule Europe
Opel engine oil is GM-LL-A-025
and GM-LL-B-025 grade and therefore
suitable for both petrol and diesel engines.
Engine oil for International service
9
Warning
Operating materials are dangerous and
must be handled carefully. If swallowed,
seek medical help immediately. Do not
breath in fumes and avoid contact with
the skin. Keep away from children.
These materials are forbidden to con-
taminate waste water, surface water,
groundwater or soil. Dispose of empty
containers correctly. Always remember
that operating materials are dangerous.
GM-LL-A-025: Petrol engines
GM-LL-B-025: Diesel engines
GM General Motors Europe
LL Long life A or B Details of engine oil grade
025 Validity code
Back to overview

240 Opel Service, maintenance
Picture no: 18239s.tif
Inspection system In order to guarantee economical and safe
vehicle operation and to maintain the
value of your vehicle, it is of vital
importance that all maintenance work is
carried out at the proper intervals.
Fixed service interval
When a service is due, the InSP display
appears in the odometer display when the
ignition is switched on. Have the next
service performed by a workshop within
one week or 500 km (whichever occurs
first). The service interval display takes account
of off-the-road periods during which the
battery is disconnected.
Flexible service interval
3
The length of the service intervals is based
on several parameters stemming from
usage. For this reason, various
engine-specific data is continually
gathered and is used to calculate the
remaining distance until the next service.
If the remaining distance is less than
1500 km, InSP is displayed with a
remaining distance of 1000 km when
the ignition is switched on and off. If less
than 1000 km remains, InSP is displayed
for several seconds. Have the next service
performed by a workshop within one week
or 500 km (whichever occurs first).
Display of remaining distance:
1. Switch off ignition.
2. Briefly press the trip odometer reset button. The odometer reading is shown.
3. Press and hold the reset button for about 2 seconds. InSP and the remaining
distance are displayed. Further information
on maintenance and
the inspection system can be found in the
Service and Warranty Booklet, which is in
the glove compartment.
Have maintenance work – and repair work
on the body and the equipment – carried
out professionally by a workshop. We
recommend using your Opel partner, who
has excellent knowledge of Opel vehicles
and has the necessary special tools and
up-to-date service inst ructions from Opel.
It is particularly advisable to use an Opel
Partner during the warranty period in order
to prevent loss of warranty. Further
information can be found in the Service
and Warranty Booklet.
Separate anti-corrosion service
Have this work done at the intervals given
in the Service and Warranty Booklet.
Back to overview

244 Opel Service, maintenanceDiesel fuel filter On the event of engine oil change, have
fuel filter checked for possible water
residue by a workshop.
Illumination of A indicates water in the
fuel filter 3.
Have fuel filter checked at shorter intervals
if the vehicle is subjected to extreme
operating conditions such as high humidity
(primarily in coastal areas), extremely high
or low outside temperatures and
substantially varying daytime and
night-time temperatures.
Coolant The coolant provid es anti-freeze
protection down to approx. -28 C. .
Picture no: 18148s.tif
Antifreeze and corrosion protection
Have the concentration of the radiator
contents tested by a workshop before
winter starts. The amount of
antifreezemust provide protection down to
approx. -28 C. A lower antifreeze
concentration will reduce the amount of
protection from fros t and corrosion. Add
antifreeze if necessary.
If coolant loss is topped up with water,
have concentration checked and add
antifreeze if necessary.
Caution
Only use approved anti-freeze.
Coolant additives used to give addi-
tional protection aga inst corrosion and
prevention against small leaks can lead
to functional problems. No liability is
accepted for damage caused by using
coolant additives.
9
Warning
Antifreeze is a danger to health; it must
therefore be kept in the original con-
tainer and out of the reach of children.
Back to overview

246 Opel Service, maintenance
Picture no: 18151s.tif
Brake fluid The brake fluid level must be between
theMIN and the MAX marks. When topping up, ensure maximum
cleanliness as contamination of the brake
fluid can lead to func
tion problems in the
braking system.
Only use approved high performance
brake fluids. Only us e brake fluid DOT4.
After correcting the brake fluid level, have
the cause of the loss of brake fluid
remedied by a workshop. Brake fluid change
Brake fluid is hygroscopic, i.e. it absorbs
water. If the brakes become hot, such as
when driving on long downhill stretches,
vapour bubbles can occur in the water,
which can have an extremely adverse
effect on braking power (depending on the
proportion of water).
Keep to the specified intervals.
9
Warning
Brake fluid is poisonous and corrosive.
Do not allow it to come into contact with
eyes, skin, fabrics or painted surfaces.
9
Warning
Have the brake fluid change performed
by a workshop. Please comply with the
legal environmental and health regula-
tions – concerning the disposal of brake
fluid.
Back to overview

275
Index
SSafeguard against unauthorised use .... 16
Safety accessories ........................... 63, 196
Saving energy ........................................ 151
Seat adjustment ........................................ 2
Seat belts ............................................ 58, 62
Seat height adjustment ....................... 3, 49
Seat position ............................................ 50
Seats ........................................................... 2Heated ............................................ 50, 51
Selector lever .................................. 137, 145
Selector lever lock ............................ 15, 145
Self-diagnosis .............................61, 74, 166
Self-help .................................................. 190 Central locking ..................................... 34
Electric sun roof .................................... 47
Electric windows ................................... 46
Information display ............................. 96
Remote control ..................................... 31
Service interval display ......................... 240
Service intervals ..................................... 231 Additional work .................................. 238
Hard driving conditions ..................... 238
Main inspection .................................. 231
Service work ........................................... 240
Side airbags ............................................. 71
Signal system ........................................... 12
Spare keys ................................................ 26
Spare wheel ........................... 196, 197, 200
Speed .............................................. 151, 152 Fuel consumption ...................... 151, 152 Speed warning ......................................... 92
Speedometer ........................................... 90
Sport programme .................................. 140
Starting the engine .......................... 27, 137
Steam-jet cleaners ................................. 230
Steering column lock ......................... 16, 17
Steering wheel adju
stment ....................... 5
Steering wheel remote control ....... 21, 118
Stowage compartments ......................... 82
Sun roof ............................................ 46, 230
Sunblind ................................................... 47
System settings ........................................ 98
TTachometer .............................................. 90
Tail lamps ............................................... 108 Bulb replacement .............................. 221
Tailgate .................................................... 36
Tank Fuel gauge ........................................... 90
Technical data ....................................... 250
Telephone, see Mobile telephone ........ 119
Temperature regulation ............... 123, 130
Tempomat, see cruise control .............. 160
Temporary spare wheel ................ 173, 197
Tightening torque .......................... 203, 264
Time .......................................................... 96
To fold backrest .................................. 3, 49
Tools ....................................................... 198
Top speed .............................................. 254
Top-Tether ............................................... 68
Towing .................................................... 193
Towing equipment ........................ 184, 269 Towing eye .................................... 193, 195
Transmission
Manual transmission ......................... 144
Transmission display ............... 91, 136, 144
Transmission, automatic ........................ 15 Automatic mode ............................... 145
Driving programme ........................... 146
Fault ................................................... 148
Interruption of power supply ............ 148
Kickdown ............................................ 146
Selector lever ............................... 15, 145
Selector lever lock ................................ 15
Winter programme ............................ 146
Transmission, Easytronic Driving programmes ......................... 139
Fault ................................................... 142
Interruption of power supply ............ 143
Kickdown ............................................ 141
Selector lever ............................... 15, 138
Sport programme .............................. 140
Winter programme ............................ 140
Transmission, manual ............................. 14
Tread depth ........................................... 170
Trip computer ............................ 20, 92, 101
Trip odometer .................................... 92, 93
Triple information display ...................... 94
Turn signal lamps .................................... 11
Turn signals Bulb replacement ...................... 220, 221
Tyre chains ..................................... 172, 264
Tyre condition ........................................ 170
Tyre pressure ........................... 22, 169, 264
Tyre repair kit ........................................ 204
Back to overview