2009 OPEL ANTARA air condition

Self-help, vehicle care199
Replacing windscreen wipers
Lift wiper arm, press and hold retaining clip
and detach wiper blade.Windscreen washer system
Do not spray washer fluid onto windscreen
in freezing weather, to avoid ice forming
and impairing vision.
The filler opening of the fluid container for
the windscreen washer system is located in
the front of the engine compartment.
Fill only with commercially available,
ready-to-use windscreen washer fluid.
Do not use tap water, as minerals will
cause clogging in the system.In cold weather, do no
t fill the windscreen
washer fluid reservoir more than three-
quarters full, to allow enough room for
expansion if the fluid freezes, and to
prevent damage to the reservoir.
In freezing conditions, use windscreen
washer fluid with sufficient antifreezing
properties. Do not use coolant antifreeze or
tap water, to avoid freezing the solution
and damaging the windscreen washer
system.
When closing the cont ainer, press the lid
down firmly all the way round.
If the fluid in the windscreen washer fluid
reservoir is too low, control indicator G
illuminates in the instrument panel -
see page 73. Top up washer fluid as soon
as possible.

Self-help, vehicle care202
Vehicle care aids 3
Vehicle wash:
z Car Shampoo
z Sponges
z Chamois Leather
z Wheel Cleaners
z Engine Cleaners
z Glass Cleaners
Exterior care:
z Touch-up Applicator
z Spray and Touch-up Paint
z Car Polishes/Colour Restorers
z Car Waxes/Sealers
z Alloy Wheel Cleaner
z Alloy Wheel Preserver
z Metallic Paintwork Wax
z Rust Preventative
z Lubricant Sprays
z Lock Cylinder Grease
z De-icer Sprays
z Tar Removal Spray
z Insect Remover
z Window Cleaning Spray
z Cleaning Solvent and Antifreeze
Interior care:
z Interior/Upholstery Cleaner Washing
The paintwork of your vehicle is exposed to
environmental influences, e.g. continuous
changes in weather conditions, industrial
waste gases and dust or thawing salts, so
wash and wax your vehicle regularly. When
using automatic car washes, select a
program which includes waxing.
Bird droppings, dead insects, resin, pollen
and the like should be cleaned off
immediately, as they contain aggressive
constituents which can cause paint
damage.
If using a car wash, comply with the
pertinent instructions of the car wash
manufacturer. The windscreen wipers and
tailgate wipers must be switched off –
see pages 92, 93. Remove detachable rod
antenna by unscrewing it.
Do not use high-pressure jet cleaners.
If you wash your vehicle by hand, make
sure that the insides of the wings are also
thoroughly rinsed out. Do not use
household dishwashing liquid, to avoid
removing wax from the paintwork.
Clean edges and folds on opened doors
and flaps as well as the areas they cover.
Thoroughly rinse off and leather-off the
vehicle. Rinse leather frequently. Use
separate leathers for paint and window
surfaces; remnants of wax on the windows
will impair vision.
Also wash aluminium trim parts, avoiding
the use of abrasive materials such as
automotive or chrome polish, steam or
caustic soap. Washing with water is
normally sufficient.
Observe national regulations.

Self-help, vehicle care205
Windscreen wiper blades
Wax, such as that used in car washes, can
cause streaks to form on the windscreen
when the wipers are used.
Smearing wiper blades can be cleaned with
a soft cloth and Opel Cleaning Solvent and
Antifreeze, and replaced if necessary –
see page 198. Do not use abrasive
cleaners.
Locks
The locks are lubricated with a high-grade
lock cylinder grease at the factory. Opel
Lock Cylinder Grease prevents the locks
from freezing up.
Only use de-icing agents in emergencies,
as they have a degreasing effect and will
impair the function of the locks. After using
a de-icing agent, have the locks re-greased
by a workshop. Engine compartment
Areas of the engine compartment that are
painted in the same colour as the vehicle
must be looked after
like any other painted
surface.
It is advisable to wash the engine
compartment before and after winter and
preserve it with wax. Cover alternator and
fluid reservoirs with plastic sheets before
washing the engine.
When washing the engine with a steam-jet
cleaner, do not direct the steam-jet at
components of the Anti-lock Brake System
(ABS), the air conditioning system or the
belt drive and its components.
Protective wax that has been applied is
also removed during the engine wash. For
this reason, have the engine, brake system
components in the engine compartment,
axle components with steering, body parts
and cavities thoroughly preserved with
protective wax after the wash.
An engine wash can be performed in the
spring in order to remove dirt that has
adhered to the engine compartment,
which may also have a high salt content.
Check protective wax layer and make good
if necessary. Underbody
Your vehicle has a factory-applied PVC
undercoating in the wheel arches
(including the longitudinal members) which
provides permanent protection and needs
no special maintenance. The surfaces of
the vehicle underbody not covered by PVC
are provided with a durable protective wax
coating in critical areas.
On vehicles which are washed frequently
in automatic car wash
es with underbody
washing facility, the protective wax
coating may be impaire d by dirt-dissolving
additives. Check the underbody after
washing and have it waxed if necessary.
Before the start of the cold weather season,
check the PVC coating and protective wax
coating and, if necessary, have them
restored to perfect condition.
Caution
– commercially available bitumen/
rubber materials can damage the PVC
coating. We recommend that you have
underbody work carried out by a
workshop, who knows the prescribed
materials and has experience in the use
thereof.
The underbody should be washed
following the end of the cold weather
season to remove any dirt adhering to the
underbody since this may also contain salt.
Check protective wax coating and, if
necessary, have it restored to perfect
condition.

208 Service, maintenance
Service operations by year 1)
km ( x 1000)1)
miles ( x 1000)1)
1)Whichever occurs first.
⊕ Additional operations.
o Under extreme operating conditions and if required by country-specific conditions, the intervals are reduced.
15
10 1
30
20 45
30 2
60
40 75
50 3
90
60
⊕o Diesel fuel filter: drain water
(If relative humidity is high an
d/or fuel is of lower quality) Annually
Fuel filter: replace and drain water - diesel (g rade EN 590) Every 2 years/60 000 km/40 000 miles
Parking brake: check and adjust
Wheel mounting and suspension front an d rear, brake lines, brake pressure
hoses, fuel lines and exhaust system: visual check xxx
Corrosion protection: check and record in Service and Warranty Booklet Annually
Front and rear wheel br akes: check visually xxx
o
⊕Annual service check if annual mileage exceeds 20 000 km Annually
Engine, transmission, PTO, rear differential, A/C compressor: check for leaks xxx
Steering system boots, track rods , final drive: visual check xxx
Track rod end and supporting ball joint: check xxx
⊕Brake and clutch fluid: change Every 2 years
Wheel fastening: loosen and tighten to torque
Tyre condition and pressures: check, correct xxx
⊕Annual service check if annual
mileage exceeds 20 000 km Annually
First aid kit, tyre repair kit and lash ing eyes: visual check Every 2 years
Headlamp aiming: check, adjust x x x
Door hinges, door stop, lock cylinder, lock striker, bonnet catch, tailgate
hinges and check links: lubricate xxx
Test drive, final check
Service interval display and oil life monitor: reset - if applicable xxx

210 Service, maintenance
Service operations by year 1)
km ( x 1000)1)
miles ( x 1000)1)
1)Whichever occurs first.
⊕ Additional operations.
o Under extreme operating conditions and if required by country-specific conditions, the intervals are reduced.
15
10 1
30
20 45
30 2
60
40 75
50 3
90
60
⊕o Diesel fuel filter: drain water
(If relative humidity is high an
d/or fuel is of lower quality) Annually
Fuel filter: replace and drain water - diesel (g rade EN 590) Every 2 years/60 000 km/40 000 miles
Parking brake: check and adjust
Wheel mounting and suspension front an d rear, brake lines, brake pressure
hoses, fuel lines and exhaust system: visual check Every 2 years/60 000 km/40 000 miles
Corrosion protection: check and record in Service and Warranty Booklet Annually
Front and rear wheel brakes: check visually Every 2 years/60 000 km/40 000 miles
o
⊕Annual service check if annual mileage exceeds 20 000 km Annually
o
⊕Automatic transmission oil: change Every 4 years/60 000 km/40 000 miles
Engine, transmission, A/C compressor: check for leaks Annually
Steering system boots, track rods, final drive: visual check Annually
Track rod end and supporting ball joint: check Annually
⊕Brake and clutch fluid: change Every 2 years
Wheel fastening: loosen and tighten to torque
Tyre condition and pressures: check, correct Every 2 years/60 000 km/40 000 miles
⊕Annual service check if annual
mileage exceeds 20 000 km Annually
First aid kit, tyre repair kit and lash ing eyes: visual check Every 2 years
Headlamp aiming: check, adjust Every 2 years/60 000 km/40 000 miles
Door hinges, door stop, lock cylinder, lock striker, bonnet catch, tailgate
hinges and check links: lubricate Every 2 years/60 000 km/40 000 miles
Test drive, final check
Service interval display and oil life monitor: reset - if applicable xxxxxx

212 Service, maintenance
Service operations by month 1)
km ( x 1000)1)
miles ( x 1000)1)
1)Whichever occurs first.
⊕ Additional operations.
o Under extreme operating conditions and if required by country-specific conditions, the intervals are reduced.
6
10
6.5 12
20
1318
30
2024
40
26.5 30
50
3336
60
40
Parking brake: check and adjust
Wheel mounting and suspension front an d rear, brake lines, brake pressure
hoses, fuel lines and exhaust system: visual check xxx
Corrosion protection: check and record in Service and Warranty Booklet Annually
Front and rear wheel br akes: check visually x x x
Engine, transmission, PTO, rear differential, A/C compressor: check for leaks xxx
Steering system boots, track rods , final drive: visual check xxx
Track rod end and supporting ball joint: check xxx
⊕Brake and clutch fluid: change Every 2 years
Wheel fastening: loosen and tighten to torque
Tyre condition and pressures: check, correct xxx
First aid kit, tyre repair kit and lash ing eyes: visual check Every 2 years
Headlamp aiming: check, adjust xxx
Door hinges, door stop, lock cylinder, lock striker, bonnet catch, tailgate
hinges and check links: lubricate xxx
Test drive, final check
Service interval display and oil life monitor: reset - if applicable xxx

Index228
IndexA
ABS ......................................................... 148
Accessories
......... 45, 57, 69, 169, 191, 200
Accessory sockets
................................... 69
Active Rollover Protection (ARP)
.......... 138
Air conditioning system
................ 103, 109
Air distribution
....................................... 106
Air intake
............................................... 114
Air quality sensor
.................................. 112
Air recirculation mode
.......................... 109
Air vents
................................................. 104
Airbags
.................................. 42, 52, 54, 55
Alarm
....................................................... 29
Alarm system
........................................... 27
All Wheel Drive (AWD)
.......................... 121
Alternator
................................................ 74
Antenna
......................................... 101, 202
Antifreeze
...................................... 195, 214
Antifreeze protection
.................... 195, 199
Anti-knock quality of fuel
..................... 131
Octane number
................................. 217
Anti-lock Brake System (ABS)
.............. 148
Anti-theft alarm system
.......................... 27
Anti-theft locking system
........................ 27
Towing equipment
............................ 166
Approach lighting
................................... 94
Aquaplaning
......................................... 151
Armrests
............................................. 40, 42
Ashtrays
................................................... 67
Illumination
........................................ 100
Assist grips
............................................... 69
Automatic air recirculation
.................. 112
Automatic anti-dazzle exterior mirrors
.31 Automatic anti-dazzle interior mirror
... 32
Automatic dipped beam activation
...... 95
Automatic level control
.................. 97, 143
Automatic transmission
................. 18, 115
Automatic mode
............................... 116
Engine braking assistance
............... 118
Fault
................................................... 120
Interruption of power supply
............ 120
Kickdown
................................... 117, 118
Manual mode
.................................... 117
Rocking the vehicle
........................... 119
Selector lever
..................................... 116
Transmission display
........................ 116
Winter program
................................. 117
B
Battery ................................................... 200
Interruption of power supply
............ 120
Battery discharge protection
............... 100
Before starting-off
.................................. 18
Belt force limiters
.................................... 44
Belt tensioners
......................................... 44
Belts
....................................... 8, 42, 43, 204
Bleeding, diesel fuel system
................. 171
Board information display
............... 76, 78
Bonnet
.................................................... 171
Boot, see Luggage compartment
......... 41
Brake assist
........................................... 146
Brake fluid
............................................. 214
Brake system
......................................... 145

Index230
D
Dashboard - see Instrument panel ........ 10
Data
................................................. 21, 215
Date
.......................................................... 80
Daytime running lamps
.......................... 94
DCS (Descent Control System)
............. 138
Demisting and defrosting Windows
............................................... 17
With air conditioning system
............ 108
With Electronic Climate Control
....... 113
Descent Control System
........................ 138
Diesel
...................................................... 131
Diesel fuel filter
...................................... 194
Diesel fuel system
.......................... 171, 194
Diesel particle filter
......................... 73, 135
Dipped beam
..................................... 14, 95
Bulb replacement
.............................. 186
Display
..................................................... 76
Display mode
........................................... 87
Door locks
.......................................... 6, 205
Doors
........................................................ 72
Drink holders
............................................ 67
Drive control systems
............................ 136
Driving abroad
...................................... 100
Driving hints
........................................... 127
E
Economical driving ................................ 129
Electric exterior mirrors
....................... 9, 30
Electric sun roof
....................................... 34
Electric windows
...................................... 32
Child safety system
............................. 33
Safety function
.................................... 33
Electrical system
.................................... 181 Electrically adjustable front seat
........... 37
Electronic Climate Control
...... 17, 103, 111
Electronic components
......................... 201
Electronic immobiliser
............................. 22
Electronic Stability Control (ESC)
......... 136
Engine braking assistance
................... 118
Engine code
................................... 216, 217
Engine control indicator
....................... 134
Engine data
........................................... 217
Engine oil
............................................... 213
Additives
............................................ 214
Topping up
........................................ 213
Viscosity
............................................. 214
Engine oil change
.................................. 194
Engine oil filter change
......................... 194
Engine oil level and consumption
........ 192
Engine oil life monitor
..................... 73, 194
Engine oil pressure
.................................. 74
Engine oils
...................................... 192, 216
Engine speed
........................................... 75
Engine wash
.......................................... 205
Environmental protection
............. 194, 201
ESC (Electronic Stability Control)
......... 136
Exhaust control indicator
..................... 134
Exhaust gases
....................................... 135
Exhaust system
...................................... 135
Exterior lamps
.......................................... 94
Exterior mirrors
........................................ 30
F
Fan ................................................. 106, 191
Filling station Capacities
.......................................... 225
Engine oil level
................................... 192
Fuel
............................................. 131, 217
Ignition key
.......................................... 21
Opening the bonnet
......................... 171
Tyre pressure
............................. 130, 224
Vehicle data
...................................... 215
Windscreen washer system
.............. 199
First aid kit
....................................... 68, 177
Flat tyre
................................................. 177
Flex-Fix system
...................................... 154
FlexOrganizer
.......................................... 62
Fog tail lamp
........................................... 96
Bulb replacement
.............................. 188
Fold in exterior mirrors
....................... 9, 30
Foot brake
............................................. 146
Front airbags
........................................... 52
Front door lamps
.................................. 100
Bulb replacement
.............................. 190
Front fog lamps
...................................... 96
Bulb replacement
.............................. 188
Front passenger’s seat airbag
............... 52
Front passenger’s seat undertray
......... 66
Front reading lamps Bulb replacement
.............................. 189
Front seat armrest
.................................. 40
Fuel
........................................................ 131
Fuel consumption
................. 129, 131, 219
Fuel filler cap
......................................... 132
Fuel filter
................................................ 194