2009 OPEL AGILA parking brake

9-9 Driving and operating
Brakes
Foot brake
The brake system comprises two
separate brake circuits.
If one brake circuit should fail, the
vehicle can still be braked with the
second remaining circuit.
If this happens, the brake pedal must
be fully depressed with greater pedal
pressure. The distance required for
braking will be greater. Seek the
assistance of a workshop.
In order to utilise the full pedal travel,
particularly in the event of a brake
circuit fault, there must be no mats in
the area of the pedals 3 9-1.
With the engine stopped, the brake
servo assistance is discontinued after
the brake pedal has been depressed
once or twice. The braking effect is
not reduced, but increased foot
pressure will be necessary. Take
extra care if the vehicle is being
towed.
Brake system control indicator 3 5-9.
Anti-lock Brake System
(ABS) u
The ABS prevents the wheels from
locking during heavy braking.
It starts to regulate braking pressure
as soon as a wheel shows a tendency
to lock. The vehicle remains
steerable, even during heavy braking,
e.g. on bends or when swerving to
avoid an obstacle. Even in the case of
extreme braking, ABS makes it
possible to drive round obstacles
without releasing the foot brake.
ABS control indicator 3 5-9.
Fault
Have the cause of the fault remedied
by a workshop.
Parking brake
Always apply the parking brake firmly
without actuating the release button.
Apply as fully as possible on uphill or
downhill inclines.
To release the parking brake, press
and hold the button, pull the lever up
slightly and lower lever while holding
the button in.
To reduce the operating forces of the
parking brake, depress the foot brake
at the same time.
Brake system control indicator 3 5-9.
Caution
If there is a fault in the ABS, the
wheels may lock during heavy
braking. This may cause the vehicle
to swerve.

10-22 Vehicle care
Wheel changing
In order to reduce the chance of
possible injuries, make the following
preparations and note the procedure:
„Park on a level, firm and non-
slippery surface.
„Switch on hazard warning lamps
and apply parking brake. Engage
reverse gear (automatic
transmission 3 in P).
„Take the spare wheel from under
the luggage compartment floor
cover 3 10-24.
„Before raising the vehicle, turn front
wheels to straight-ahead position.
„Never change more than one
wheel at a time.
„Block wheel diagonally opposite
the wheel to be changed, by
placing wedge blocks or equivalent
in front and behind the wheel.
„Use jack only when changing
wheels.
„If the ground on which the vehicle is
parked is soft, a solid board (max.
1 cm thick) should be placed under the jack. Using a thicker board
could lead to damage of the jack
and the vehicle.
„Do not raise the vehicle more than
is necessary to change a wheel.
„No people or animals may be in the
vehicle when it is jacked-up.
„Never start or run the engine or
crawl under a jacked-up vehicle.
„Before screwing on the wheel bolts
when changing a wheel, apply a
light coating of grease to the cone
of each wheel bolt.
1. Prise off the wheel cover 3.
2. Slacken the wheel bolts by one
turn each using the wheel bolt
wrench, putting the wrench on
as far as possible.
3. The location of front and rear
jacking bars may be indicated
by notches on the bottom edge
of the vehicle, under the doors.

10-26 Vehicle care
Rotate jack shaft anti-clockwise and
remove jack from storage bracket.
To stow the jack after use, place it in
its storage bracket and turn jack shaft
clockwise until jack is held securely in
place.Jump starting 3
Do not start with quick charger, to
prevent damage to electronic
components.
Never expose the battery to naked
flames or sparks.
„A discharged battery can freeze at
temperatures of 0 °C. Defrost the
battery in a warm room before
connecting the jump leads.
„Do not allow battery fluid to contact
eyes, skin, fabrics or painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event of
direct contact.„Wear eye protection and protective
clothing when handling a battery.
„Use auxiliary battery with same
voltage (12 volts). Its capacity (Ah)
must not be considerably less than
that of the discharged battery.
Voltage and capacity information
can be found on the batteries.
„Use jump leads with insulated
terminals and a width of at least
16 mm
2 (25 mm2 for diesel
engines).
„Do not disconnect the discharged
battery from the vehicle.
„Switch off all unnecessary
electrical consumers. Infotainment
system may be damaged if
switched on while jump starting.
„Do not lean over the battery during
jump starting procedure.
„Do not allow the terminals of one
lead to touch those of the other
lead.
„The vehicles should not touch while
jump starting.
„Apply parking brake.
9 Warning
This must be done with extreme
care. Any deviation from the
following instructions could lead
to personal injury or damage
resulting from battery explosion,
as well as to damage to the
electrical systems in both
vehicles.

10-28 Vehicle care
Towing
Towing the vehicle
Towing from the front is permissible
in emergency situations only.
For fixing of the front towing eye,
remove the towing eye socket cover
by pressing the lower part of the
cover.
The towing eye attachment is stored
below the spare wheel in the luggage
compartment 3 10-25.Screw in towing eye attachment
clockwise until it is firmly in place. If
necessary, use jack handle to tighten.
Attach a tow rope 3 - or better still a
tow rod 3 - to the front towing eye.
The front towing eye must only be
used for towing and not recovering
the vehicle.
Switch on the ignition (3 9-1) to
release the steering column lock and
to permit operation of the brake
lamps and windscreen wipers.
Manual transmission in neutral,
automatic transmission 3 in N.More brake pedal pressure is
necessary when braking since the
brake servo unit is operative only
when the engine is running.
Considerably greater steering force is
necessary since this unit is operative
only when the engine is running.
To prevent entry of exhaust fumes
from towing vehicle, switch on air
recirculation mode (3 8-3) and close
the windows.
Do not tow the vehicle with a tow
rope3 or tow rod 3 for extended
periods, to avoid causing damage to
the vehicle. Only tow in this manner
on hard-surfaced roads.
Vehicles with manual or automatic
transmission3 can be towed from
the front, provided the front axle is
raised off the ground and the parking
brake is released.
Caution
Drive slowly and avoid jerky
movements. Impermissible tractive
forces could damage the vehicles.

10-29Vehicle care
Vehicles with manual transmission
can also be towed from the front with
all four wheels on the ground. In this
case, the gearshift lever must be in
neutral with the parking brake
released and the key in ignition
switch position ACC, to permit
release of the steering column lock
before towing.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
attachment anti-clockwise and refit
the cover.Towing another vehicleInterior care
Interior and upholstery
Clean the vehicle interior regularly,
including the instrument panel facia,
using Interior/Upholstery Cleaner.
Clean fabric upholstery with a
vacuum cleaner and brush. To
remove stains, use a cleaner that is
suitable for both fabrics and vinyl.
Clean seat belts only with lukewarm
water or Interior/Upholstery Cleaner.
Caution
Never tow the vehicle with the front
wheels on the ground, to avoid
causing damage to the automatic
transmission 3.
Caution
The rear lashing eye is designed for
shipping purposes only.
Towing another vehicle from the
rear is not permitted!
Caution
Open Velcro fasteners on clothing
could damage seat upholstery.
Make sure that Velcro fasteners are
closed.

11-3 Service and maintenance
Service operations by year 1)
km ( x 1000)1)
miles ( x 1000)1)
1)Whichever occurs first.⊕Additional operations.o Under extreme operating conditions and if required by country-specific conditions, the intervals are reduced.
1
15
102
30
203
45
304
60
405
75
506
90
60
Ribbed V-belt: visual check - petrol engines only x x
⊕ Replace every 6 years/90,000 km/60,000 miles
Ribbed V-belt and tensioner: visual check - diesel engines only x x x
⊕ Replace every 10 years/150,000 km/100,000 miles
⊕Valve clearances: check, adjust - petrol engines only x x x
Engine oil and oil filter: replace x x x x x x
oDiesel fuel filter: drain water x x x x x x
Diesel fuel filter: replace and bleed x x x
⊕Manual transmission: oil level check, correct x
Oil changexx
Parking brake cable: check, adjust x
Parking brake: check and adjust
Wheel mounting and suspension front and rear, brake lines, brake
pressure hoses, fuel lines, fuel tank and exhaust system: visual checkxxx
Corrosion protection: check and record in Service and Warranty Booklet annually
Front and rear wheel brakes: check visually x x x x x x

13-1 Index
IndexA
ABS ........................................... 9-9
Accessories
............... 3-9, 4-5, 10-6
Accessory socket
....................... 5-4
Air conditioning system ....... 8-1, 8-3
Air intake
.................................... 8-6
Air recirculation
.......................... 8-3
Air vents ..................................... 8-4
Airbags
.................................... 3-13
Alternator, see Charging system
5-9
Antenna .......................... 7-6, 10-30
Antifreeze
....................... 10-4, 11-6
Antifreeze protection
....... 10-4, 10-5
Anti-knock quality of fuel .......... 9-12
Octane number
.................... 12-3
Anti-theft locking system
............ 2-6
Anti-theft protection ................... 9-2
Ashtrays
..................................... 5-5
Automatic transmission
............. 9-3
Automatic mode ..................... 9-4
Engine braking assistance
..... 9-4
Fault
....................................... 9-5
Interruption of power supply ... 9-5
Kickdown
................................ 9-4
Rocking the vehicle
................ 9-5
Selector lever ......................... 9-4
Transmission display
.............. 9-3
Automatic wiping
....................... 5-3B
Battery
..................................... 10-6
Interruption of power supply
... 9-5
Before starting-off
...................... 9-2
Belt force limiters ....................... 3-6
Belt tensioners
........................... 3-6
Belts
................................ 3-5, 10-29
Bleeding, diesel fuel system .... 10-7
Bonnet
..................................... 10-2
Boot, see Luggage compartment
3-3
Brake assist ............................. 9-10
Brake fluid
................................ 11-7
Brake system
............................. 9-9
Brakes ....................................... 9-9
ABS
........................................ 9-9
Brake assist
.......................... 9-10
Brake fluid ............................ 10-6
Brake lamps
......................... 10-9
Foot brake
.............................. 9-9
Parking brake ......................... 9-9
Bulb replacement
..................... 10-7
C
Capacities
................................ 12-5
Care
....................................... 10-29
Catalytic converter
..................... 9-8
Central locking system ....... 2-3, 2-4
Centre high-mounted
stoplamp (CHMSL)
Bulb replacement
............... 10-10

13-3 Index
Engine oil ........................ 10-3, 11-6
Additives ............................... 11-6
Topping up
.................. 10-3, 11-6
Viscosity
............................... 11-6
Engine oil level and
consumption
............................ 10-3
Engine oil life monitor
.............. 5-14
Engine oil pressure .................. 5-11
Engine speed
............................. 5-6
Engine wash
.......................... 10-32
Environmental protection ....... 10-30
ESP (Electronic Stability
Program)
.................................. 9-10
Exhaust gases ........................... 9-8
Exhaust system
......................... 9-8
Exterior care
.......................... 10-30
Exterior lamps ............................ 6-1
Exterior mirrors
.......................... 2-8
F
Fan
............................................ 8-2
Filling station
Capacities
............................ 12-5
Engine oil level ..................... 10-3
Fuel
............................. 9-12, 12-3
Opening the bonnet
.............. 10-2
Tyre pressure ....................... 12-8
Vehicle data
......................... 12-1
Windscreen washer system
. 10-5
First aid kit ................................. 4-5Flat tyre
.................................. 10-24
Foot brake ................................. 9-9
Front airbags
........................... 3-13
Front fog lamps
.......................... 6-3
Bulb replacement ................. 10-8
Front passenger’s airbag
......... 3-13
Deactivation
......................... 3-17
Front turn signal lamps
Bulb replacement
................. 10-8
Fuel
.......................................... 9-12
Fuel consumption ........... 9-13, 12-4
Fuel filler cap
........................... 9-13
Fuel gauge
................................. 5-7
Fuse extractor ........................ 10-12
Fuses
..................................... 10-11
G
Gears
......................................... 9-6
Generator, see Charging system
5-9
Glove box
.................................. 4-1
Gross Vehicle Weight ..... 9-12, 12-7
H
Hand brake, see Parking brake
.9-9
Hazard warning lamps ............... 6-2
Head restraints
.......................... 3-1
Headlamp flash
.......................... 6-2
Headlamp range adjustment ..... 6-1Headlamps
................................ 6-1
Bulb replacement ................. 10-7
Driving abroad
........................ 6-3
Front fog lamps
...................... 6-3
Warning chime ..................... 5-13
Heated exterior mirrors
.............. 8-5
Heated rear window
................... 8-5
Heating ...................................... 8-1
Exterior mirrors
....................... 8-5
Rear window
.......................... 8-5
Height adjustment
Head restraints
....................... 3-1
Seat belts
............................... 3-8
Steering wheel ....................... 5-1
High beam
................................. 6-2
Bulb replacement
................. 10-7
High-pressure cleaners 10-30, 10-31
Horn
........................................... 5-2
I
Identification plate
.................... 12-1
Ignition switch
............................ 9-1
Ignition system
........................... 9-2
Immobiliser ................................ 2-7
Infotainment system
.................. 7-1
Instrument cluster
...................... 5-8
Instrument panel ........................ 1-5
Instruments
................................ 5-1
Interior care
........................... 10-29