2009 FORD EXPEDITION check engine

The OBD-II system is designed to check the emission control system
during normal driving. A complete check may take several days. If the
vehicle is not ready for I/M testing, the following driving cycle consisting
of mixed city and highway driving may be performed:
15 minutes of steady driving on an expressway/highway followed by
20 minutes of stop-and-go driving with at least four 30-second idle
periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete. If
the vehicle is still not ready for I/M testing, the above driving cycle will
have to be repeated.
POWER STEERING FLUID
Check the power steering fluid. Refer to thescheduled maintenance
informationfor the service interval schedules.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be
near the center of the normal area
between H and C).
2. While the engine idles, turn the
steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is in this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the range between the MIN and MAX lines. Be
sure to put the cap back on the reservoir. Refer toMaintenance
product specifications and capacitiesin this chapter for the proper
fluid type.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
396

BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “MIN” and
“MAX” lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of the
system could be compromised; seek
service from your authorized dealer
immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid
The automatic transmission does not have a transmission fluid dipstick.
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transmission does not
consume fluid. However, the fluid level should be checked if the
transmission is not working properly, (i.e., if the transmission slips or
shifts slowly) or if you notice some sign of fluid leakage.
Transmission fluid should be checked by an authorized dealer. If
required, fluid should be added by an authorized dealer.
Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transmission components.
AIR FILTER
Refer toscheduled maintenance informationfor the appropriate
intervals for changing the air filter element.
When changing the air filter element, use only the Motorcraft air filter
element listed. Refer toMotorcraft part numbersin this chapter.
WARNING:To reduce the risk of vehicle damage and/or
personal burn injuries do not start your engine with the air
cleaner removed and do not remove it while the engine is running.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
397

Item Capacity Ford part nameFord part number /
Ford specification
Fuel tank
(Expedition EL – U.S.
only)33.5 gallons
(126.8L)
Fuel tank
(Expedition Max –
Canada only)33.5 gallons
(126.8L)
1Add the coolant type originally equipped in your vehicle.2Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.3Indicates only approximate dry-fill capacity. Some applications may vary based on cooler size and
if equipped with an in-tank cooler.4Automatic transmissions that require MERCON
LV should only use MERCON
LV fluid. Refer to
scheduled maintenance informationto determine the correct service interval. Use of any fluid
other than the recommended fluid may cause transmission damage.5Add 4 oz. (118 ml) of Additive Friction Modifier XL-3 or equivalent for complete refill of Ford
Limited Slip rear axles.6Your vehicle’s rear axle is filled with a synthetic rear axle lubricant and is considered lubricated
for life. These lubricants are not to be checked or changed unless a leak is suspected, service is
required or the axle has been submerged in water. The axle lubricant should be changed any time
the axle has been submerged in water.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
404

The Vehicle Identification Number (VIN) contains the following
information:
1. World manufacturer identifier
2. Brake system / Gross Vehicle
Weight Rating (GVWR) / Restraint
System
3. Vehicle line, series, body type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number
TRANSMISSION CODE DESIGNATIONS
You can find a transmission code on
the Safety Compliance Certification
Label. The following table tells you
which transmission each code
represents.
Description Code
Six-speed automatic (6R80 ) 6
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
407

A
ABS (see Brakes) .....................291
Accessory delay ........................115
AdvanceTrac ..............................293
Air cleaner filter .......397–398, 400
Air suspension ...........................298
description ..............................298
Airbag supplemental restraint
system ........................218, 222, 224
and child safety seats ............220
description ..............218, 222, 224
disposal ....................................228
driver airbag ............220, 223, 225
indicator light .................222, 227
operation .................220, 223, 225
passenger airbag .....220, 223, 225
side airbag ...............................222
Antifreeze
(see Engine coolant) ................377
Anti-lock brake system
(see Brakes) ..............................291
Anti-theft system ..............178, 182
arming the system ..................182
disarming a triggered
system .....................................183
Armrests ....................................188
Audio system
(see Radio) ......................20, 24, 31
Automatic transmission
driving an automatic
overdrive .................................303
fluid, adding ............................397
fluid, checking ........................397
fluid, refill capacities ..............401
fluid, specification ..................401
Auxiliary input jack (Line in) ....39
Auxiliary power point ...............111Axle
lubricant specifications ..........401
refill capacities ........................401
B
Battery .......................................375
acid, treating emergencies .....375
jumping a disabled battery ....341
maintenance-free ....................375
replacement, specifications ...400
servicing ..................................375
Belt-Minder
.............................214
Booster seats .............................242
Brakes ........................................290
anti-lock ...................................291
anti-lock brake system (ABS)
warning light ...........................291
fluid, checking and adding ....397
fluid, refill capacities ..............401
fluid, specifications .................401
lubricant specifications ..........401
parking ....................................292
shift interlock ..................300, 302
Bulbs ..........................................101
C
Capacities for refilling fluids ....401
Cargo cover ...............................160
Cargo management system ......160
Cassette tape player ...................24
Cell phone use ..............................8
Changing a tire .........................331
Child safety seats ......................232
in front seat ............................232
in rear seat ..............................232
LATCH .....................................235
recommendations ...................230
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
410

Child safety seats - booster
seats ...........................................242
Cleaning your vehicle
engine compartment ..............360
instrument panel ....................361
interior .............................362–363
plastic parts ............................360
washing ....................................358
waxing .....................................359
wheels ......................................359
wiper blades ............................361
Clock adjust
6-CD in dash .............................33
AM/FM/CD .................................26
Compass, electronic ..................133
calibration ...............................134
set zone adjustment .......133, 149
Console ......................................111
overhead ..........................109–110
Controls
power seat ...............................189
steering column ......................124
Coolant
checking and adding ..............377
refill capacities ................381, 401
specifications ..........................401
Cruise control
(see Speed control) ..................121
Customer Assistance ................321
Ford Extended Service
Plan ..........................................354
Getting assistance outside the
U.S. and Canada .....................355
Getting roadside assistance ...321
Getting the service you
need .........................................350
Ordering additional owner’s
literature .................................356Utilizing the
Mediation/Arbitration
Program ...................................354
D
Daytime running lamps
(see Lamps) ................................96
Dipstick
automatic transmission
fluid ..........................................397
engine oil .................................372
Driving under special
conditions ..................306, 315, 318
sand .........................................317
snow and ice ...........................319
through water .................317, 320
DVD system .................................51
E
Electronic message center ......131,
141
Emergencies, roadside
jump-starting ..........................341
running out of fuel .........341, 389
Emission control system ..........393
Engine ........................................405
cleaning ...................................360
coolant .....................................377
fail-safe cooling .......................381
idle speed control ...................375
lubrication specifications .......401
refill capacities ........................401
service points ..........................369
starting after a collision .........323
Engine block heater .................288
Engine oil ..................................372
change oil soon warning,
message center .......................372
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
411

Illuminated visor mirror ...........109
Infant seats
(see Safety seats) .....................232
Inspection/maintenance (I/M)
testing ........................................395
Instrument panel
cleaning ...................................361
cluster ........................................12
lighting up panel and
interior .......................................97
J
Jack ............................................331
positioning ...............................331
storage .....................................331
Jump-starting your vehicle ......341
K
Keyless entry system ...............176
autolock ...................................165
keypad .....................................176
locking and unlocking doors ..177
programming entry code .......176
Keys ...................................163, 179
positions of the ignition .........284
L
Lamps
autolamp system .......................95
bulb replacement
specifications chart ................101
daytime running light ...............96
fog lamps ...................................96
headlamps .................................95
headlamps, flash to pass ..........96
instrument panel, dimming .....97
interior lamps ...................99, 102
replacing bulbs ...............102, 105LATCH anchors .........................235
Liftgate ......................155, 159, 171
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........291
Limited-slip axle .......................299
Load limits .................................269
Loading instructions .................275
Locks
autolock ...................................165
childproof ................................169
doors ........................................165
Lubricant specifications ...........401
Lug nuts ....................................340
Lumbar support, seats .....188–189
M
Message center .................131, 141
english/metric button .....136, 146
system check button ......135, 144
warning messages ...........138, 151
Mirrors ...............................115, 117
automatic dimming rearview
mirror ......................................116
fold away .................................117
heated ..............................118–119
programmable memory ..........172
signal .......................................119
Moon roof ..................................126
Motorcraft parts ........365, 383, 400
N
Navigation system .......................83
O
Octane rating ....................387–388
Oil (see Engine oil) ..................372
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
413