2009 FORD EXPEDITION steering wheel

Maintenance and Modifications
The suspension and steering systems on your vehicle have been designed
and tested to provide predictable performance whether loaded or empty
and durable load carrying capability. For this reason, Ford Motor
Company strongly recommends that you do not make modifications such
as adding or removing parts (such as lift kits or stabilizer bars) or by
using replacement parts not equivalent to the original factory equipment.
Any modifications to a vehicle that raise the center of gravity can make
it more likely the vehicle will roll over as a result of a loss of control.
Ford Motor Company recommends that caution be used with any vehicle
equipped with a high load or device (such as ladder racks or pickup box
cover).
Failure to maintain your vehicle properly may void the warranty, increase
your repair cost, reduce vehicle performance and operational capabilities
and adversely affect driver and passenger safety. Frequent inspection of
vehicle chassis components is recommended if the vehicle is subjected to
heavy off-road usage.
DRIVING THROUGH WATER
If driving through deep or standing
water is unavoidable, proceed very
slowly especially when the depth is
not known. Never drive through
water that is higher than the bottom
of the wheel rims (for cars) or the
bottom of the hubs (for trucks).
When driving through water, traction or brake capability may be limited.
Also, water may enter your engine’s air intake and severely damage your
engine or your vehicle may stall.Driving through deep water where
the transmission vent tube is submerged may allow water into the
transmission and cause internal transmission damage.
Once through the water, always dry the brakes by moving your
vehicle slowly while applying light pressure on the brake pedal.
Wet brakes do not stop the vehicle as quickly as dry brakes.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Driving
320

Fuse/Relay
LocationFuse Amp
RatingProtected Circuits
64 30A** Moon roof
65 20A** Auxiliary power point
66 20A** Auxiliary power point
67 40A** Climate controlled seats
68 60A** ABS valves
69 60A** ABS pump
70 40A** Left-hand and right-hand third
row power fold seat
71 20A** Auxiliary power point
72 20A** Auxiliary power point
73 — Not used
74 30A** Driver power seat/DSM
75 20A* PCM – VPWR1
76 20A* PCM – VPWR2
77 15A* VPWR4, Ignition coils
78 — Not used
79 20A* PCM – VPWR3
80 — Not used
81 — Not used
82 — Not used
83 — Not used
84 — Not used
85 — Wiper motor relay
* Mini Fuses ** Cartridge Fuses
CHANGING THE TIRES
If you get a flat tire while driving, do not apply the brake heavily.
Instead, gradually decrease your speed. Hold the steering wheel firmly
and slowly move to a safe place on the side of the road.
Note:The tire pressure monitoring system (TPMS) indicator light will
illuminate when the spare tire is in use. To restore the full functionality
of the monitoring system, all road wheels equipped with tire pressure
monitoring sensors must be mounted on the vehicle.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Roadside Emergencies
331

•Be certain to wash or wipe your hands clean if you have been in
contact with certain products such as insect repellent and suntan
lotion in order to avoid possible damage to the interior painted
surfaces.
•Do not use household or glass cleaners as these may damage the
finish of the instrument panel, interior trim and cluster lens.
WARNING:Do not use chemical solvents or strong detergents
when cleaning the steering wheel or instrument panel to avoid
contamination of the airbag system.
If a staining liquid like coffee/juice has been spilled on the instrument
panel or on interior trim surfaces, clean as follows:
1. Wipe up spilled liquid using a clean, white, cotton cloth.
2. Apply Motorcraft Deluxe Leather and Vinyl Cleaner (ZC-11-A) [In
Canada use Motorcraft Multi-Purpose Cleaner (CXC-101)] to the wiped
area and spread around evenly.
3. Apply more Motorcraft cleaner to a clean, white, cotton cloth and
press the cloth onto the soiled area–allow this to set at room
temperature for 30 minutes.
4. Remove the soaked cloth, and if it is not soiled badly, use this cloth to
clean the area by using a rubbing motion for 60 seconds.
5. Following this, wipe area dry with a clean, white, cotton cloth.
INTERIOR
For fabric, carpets, cloth seats, safety belts and seats equipped with side
airbags:
•Remove dust and loose dirt with a vacuum cleaner.
•Remove light stains and soil with Motorcraft Professional Strength
Carpet & Upholstery Cleaner (ZC-54).
•If grease or tar is present on the material, spot-clean the area first
with Motorcraft Spot and Stain Remover (ZC-14). In Canada, use
Motorcraft Multi-Purpose Cleaner (CXC-101).
•If a ring forms on the fabric after spot cleaning, clean the entire area
immediately (but do not oversaturate) or the ring will set.
•Do not use household cleaning products or glass cleaners, which can
stain and discolor the fabric and affect the flame retardant abilities of
the seat materials.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Cleaning
362

The OBD-II system is designed to check the emission control system
during normal driving. A complete check may take several days. If the
vehicle is not ready for I/M testing, the following driving cycle consisting
of mixed city and highway driving may be performed:
15 minutes of steady driving on an expressway/highway followed by
20 minutes of stop-and-go driving with at least four 30-second idle
periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete. If
the vehicle is still not ready for I/M testing, the above driving cycle will
have to be repeated.
POWER STEERING FLUID
Check the power steering fluid. Refer to thescheduled maintenance
informationfor the service interval schedules.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be
near the center of the normal area
between H and C).
2. While the engine idles, turn the
steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is in this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the range between the MIN and MAX lines. Be
sure to put the cap back on the reservoir. Refer toMaintenance
product specifications and capacitiesin this chapter for the proper
fluid type.
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Maintenance and Specifications
396

Child safety seats - booster
seats ...........................................242
Cleaning your vehicle
engine compartment ..............360
instrument panel ....................361
interior .............................362–363
plastic parts ............................360
washing ....................................358
waxing .....................................359
wheels ......................................359
wiper blades ............................361
Clock adjust
6-CD in dash .............................33
AM/FM/CD .................................26
Compass, electronic ..................133
calibration ...............................134
set zone adjustment .......133, 149
Console ......................................111
overhead ..........................109–110
Controls
power seat ...............................189
steering column ......................124
Coolant
checking and adding ..............377
refill capacities ................381, 401
specifications ..........................401
Cruise control
(see Speed control) ..................121
Customer Assistance ................321
Ford Extended Service
Plan ..........................................354
Getting assistance outside the
U.S. and Canada .....................355
Getting roadside assistance ...321
Getting the service you
need .........................................350
Ordering additional owner’s
literature .................................356Utilizing the
Mediation/Arbitration
Program ...................................354
D
Daytime running lamps
(see Lamps) ................................96
Dipstick
automatic transmission
fluid ..........................................397
engine oil .................................372
Driving under special
conditions ..................306, 315, 318
sand .........................................317
snow and ice ...........................319
through water .................317, 320
DVD system .................................51
E
Electronic message center ......131,
141
Emergencies, roadside
jump-starting ..........................341
running out of fuel .........341, 389
Emission control system ..........393
Engine ........................................405
cleaning ...................................360
coolant .....................................377
fail-safe cooling .......................381
idle speed control ...................375
lubrication specifications .......401
refill capacities ........................401
service points ..........................369
starting after a collision .........323
Engine block heater .................288
Engine oil ..................................372
change oil soon warning,
message center .......................372
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
411

Servicing your vehicle ..............367
Setting the clock
AM/FM single CD .....................26
AM/FM/In-dash 6 CD ................33
Snowplowing .................................8
Spark plugs,
specifications .....................400, 405
Special notice
utility-type vehicles ....................8
Specification chart,
lubricants ...................................401
Speed control ............................121
Stability system .........................293
Starting a flex fuel vehicle .......287
Starting your vehicle ........284–287
jump starting ..........................341
Steering wheel
controls ....................................124
tilting .......................................108
SYNC ............................................83
T
Tilt steering wheel ....................108
Tire Pressure Monitoring
System (TPMS)
Driving .....................................317
Tires, Wheels and Loading ....263
Warning Displays ......12, 138, 151
Tires ...........................248–249, 331
alignment ................................257
care ..........................................253
changing ..........................331, 335
checking the pressure ............253
inflating ...................................251
label .........................................262
replacing ..................................254
rotating ....................................257safety practices .......................256
sidewall information ...............258
snow tires and chains ............268
spare tire .................................332
terminology .............................250
tire grades ...............................249
treadwear ........................249, 253
Towing .......................................275
recreational towing .................283
trailer towing ..........................275
wrecker ....................................348
Transmission .............................300
brake-shift interlock
(BSI) ................................300, 302
fluid, checking and adding
(automatic) .............................397
fluid, refill capacities ..............401
lubricant specifications ..........401
Turn signal ..................................99
U
USB port ......................................41
V
Vehicle Identification Number
(VIN) ..........................................406
Vehicle loading ..........................269
Ventilating your vehicle ...........288
W
Warning lights (see Lights) .......12
Washer fluid ..............................370
Water, Driving through .............320
Windows
power .......................................113
rear wiper/washer ...................108
2009 Expedition(exd)
Owners Guide, 1st Printing
USA(fus)
Index
415