2009 FIAT QUBO engine

●● ●● ● ●
●
●
●● ●● ● ●
●● ●
●● ●● ● ●
●● ●
●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●●●
15
FIAT FIORINO/QUBO NATURAL POWER
If the car is mainly used in town, change the engine oil and filter every 12 months.
Thousands of kilometres 30 60 90 120 150 180
Check engine management system operation (using diagnosis socket)
Replace accessory drive belt/s
Replace toothed timing belt (*)
Replace spark plugs
Replace air filter cartridge
Change engine oil and oil filter (or every 24 months)
Change brake fluid (or every 24 months)
Replace pollen filter (or every 24 months)
Visually inspect condition of: methane pipes and connectors,
methane tank fastening, restore, if necessary (**)
Check pressure regulator and, if necessary, replace internal filter (**)
Check operation and parameters of fuel supply system using
the self-diagnosis socket
Check tightening torque of the cylinder fastening bands
(*) Regardless of the mileage, the timing drive belt shall be replaced every 4 years for particularly demanding use (cold climates, town driving,
idling for a long time, dusty areas) or, in any case, every 5 years.
(**) or every 12 months.
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:35 Pagina 15

GENERAL FEATURES 1.4
Engine identification code 350A1000
Cycle Otto
Number and layout of cylinders 4 in line
Piston bore and stroke mm 72 ˘ 84
Total capacity cc 1368
Compression ratio 11.1±0,2
kW
EEC max. power HP
at a speed of rpm
Nm
EEC max. torque kgm
at a speed of rpm
Spark plugsNGKZKR7A-10
Fuel
ENGINE
ENGINE CODE – BODYWORK VERSIONS
Engine code Bodywork version
1.4350A1000 225AXC1A03 (*)
225AXC1A03B (❍)
225BXC1AA7 (❒)
COMBI versions (*) QUBO versions (❍) CARGO versions (❒)
MethaneUnleaded petrol
95 RON
(EN 228 specification)
16
FIAT FIORINO/QUBO NATURAL POWER
51
70
6000
104
10.6
300057
77
6000
115
11.7
3000
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 16

20
FIAT FIORINO/QUBO NATURAL POWER
BOOT/LOAD COMPARTMENT VOLUME
The volume of the boot on Qubo and Combi versions and of the load compartment on Cargo versions, measured in dm3, is as follows:
TYRES
COLD TYRE INFLATION PRESSURE
Medium load Full load
Enginefront rear front rear
1.42.3 2.1 2.3 2.5 1.4
COMBI - QUBO
CARGO
Version
With rear backrests not folded over:
With rear backrests folded over:
–1.4
275
553
2100
(*) For versions/markets where providedVersion Tyres Snow tyres Rims
COMBI versions 185/65 R15 88T 185/65 R15Q (M+S) 6JX15-44
QUBO versions 185/65 R15 88T/195/55R16 87H (*) 185/65 R15Q (M+S) 6JX15-44/6JX16-45 (*)
CARGO versions 185/65 R15 88T 185/65 R15Q (M+S) 6JX15-44
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 20

Fuel tank:including a reserve of:
Engine cooling system
Engine sump: Engine sump and filter:
Gearbox/differential casing:
Hydraulic power steering
Hydraulic brake circuit with
ABS:
Windscreen/rearscreen washer
fluid reservoir
(▲) When the vehicle is used in particularly harsh climate conditions, we recommend using a mixture of 60% PARAFLUUPand 40% distilled water.
21
FIAT FIORINO/QUBO NATURAL POWER
CAPACITIES
1.4
litres
45
6
÷7
6.6
2.4
2.6
–
0.38
–
2.2kg
–
–
–
–
–
1.5
0.35
0.50
–
Methane
– Methane (*) . . . . . . . . kg (approx.) 13
(*) The amount of methane depends on
the outside temperature, the supply pres-
sure, the quality of the gas and the type of
refuelling system. Total cylinder volume
about 77 litres.IMPORTANT Please note that, when us-
ing a fuel like methane, the range can vary
greatly as it depends on the temperature
of the gas in the cylinder as well as on the
vehicle driving and maintenance condi-
tions.Methane heats up during filling and cools
down during driving, undergoing changes
in pressure that reduce the quantity that
can be used.
It should also be pointed out that whilst
the vehicle is being run in (up to around
3,000 km) fuel consumption may be high-
er than the figures given. Recommended fuels
Original products
Green unleaded petrol not less than 95 R.O.N.
(EN 228 specification)
Mixture of 50% distilled water and PARAFLU
UP(▲)
SELENIA MULTIPOWER GAS 5W-40
TUTELA CAR TECHNYX
TUTELA GI/E
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL SC 35
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 21

22
FIAT FIORINO/QUBO NATURAL POWER
FUEL SYSTEM (methane)
Electronic injection specifically for meth -
ane.
Type: timed, sequential Multipoint.
Injection pressure: approx. 6 bar.
Stoichiometric metering of the air/meth -
ane gas mixture.
The methane injection system is con-
trolled by the dedicated control unit us-
ing the sensors already on the vehicle, in-
cluding the Lambda sensor for controlling
the fuel metering.
IGNITION
Static advance, electronic, integrated with
the injection.ENGINE COOLING SYSTEM
Engine cooling system with pressure re-
duction unit heating circuit subject to ex-
treme cooling during operation.
PERFORMANCE
Top speed in km/h.
Running on petrol:
– Cargo versions: .............................. 157
– Combi versions: ............................. 155
– Qubo versions: ................................ 155
Running on methane: ......................... 149
Modifications or repairs to
the fuel system that are not
carried out properly or do not take
the system technical specifications in-
to account can cause malfunctions
leading to a fire risk.
IMPORTANT
CO2EMISSIONS
CO2emissions according to the
current European directive (g/km)
CO2EMISSIONS Operation Operationpetrol methane
Combined 158 119
Urban 207 154
Extra-urban 129 98
Cargo/Combi/Qubo versions
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 22

24
FIAT FIORINO/QUBO NATURAL POWER
Fiat Group Automobiles S.p.A. – Customer Services – Technical Services – Service Engineering
Largo Senatore G. Agnelli, 5 – 10040 Volvera – Torino (Italia)
Print No. 603.97.591 – 11/2009 – 1 Edition
For petrol engines running on methane, we recommend using the original product formulated specifically for this type of use.
The use of products with specifications below ACEA C3 – SAE 5W-40 could cause damage to the engine not covered by the warranty. Lubricants for
petrol/methane
enginesSAE 5W-40 ACEA C3
grade totally synthetic lubricant.
FIAT 9.55535-T2specification.SELENIA MULTIPOWER
GAS 5W-40
Contractual Technical
Reference No. F922.E09According
to annual maintenance
and inspection plan
FLUIDS AND LUBRICANTS
SPECIFICATIONS AND RECOMMENDED PRODUCTS
Use Quality specifications of fluids Genuine lubricants Interval
and lubricants for correct vehicle operation and fluids original replacement
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 24