2009 FIAT PANDA fuel

14
FIAT PANDA LPG
FUEL CUT-OFF SWITCH
In the case of LPG operation as well, the
safety switch is triggered if the car is in-
volved in an impact immediately cutting off
the supply (safety solenoid valve closed)
and causing the engine to cut out.
For further information, see the “Fuel cut
off switch” paragraph in the “Knowing
your car” chapter in the Owner Hand-
book.
STARTING THE ENGINE
The engine is always started on petrol
even with the switch in the LPG position
(green LED flashing, yellow LED on con-
stantly) and switches from petrol to LPG
automatically soon after.
There must therefore always be some
petrol in the tank to protect the petrol
pump.
To carry out the starting manoeuvre cor-
rectly, see the warnings and advice in the
Owner’s Handbook under the chapter
Starting the engine enclosed with this
Supplement.
In this situation, you can con-
tinue driving, with the car run-
ning on petrol (excluding the
LPG fuel system). To turn off
the acoustic warning press button A:
the green LED ON will go out and the
yellow LED OFF will remain on con-
stantly. Go to a Fiat Dealer as soon as
possible to have the system checked.
System failure signalling
The car has a self-diagnosis system capa-
ble of signalling any malfunctions in the
LPG fuel system through the green LED
ON fig. 7flashing. In the case of faults that
could affect the correct operation of the
engine, the LPG control unit will auto-
matically switch from LPG operation to
running on petrol.
This condition will be shown by:
– the yellow LED OFF on constantly;
– the green LED ON flashing;
– an acoustic warning from the switch
buzzer (slow frequency).
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 14

15
FIAT PANDA LPG
AT THE FILLING
STATION
LPG filler fitting
The gas filler is located next to the petrol
filler cap. It has a one-way valve, located
in the actual filler body.
To access the filler B-fig. 8, open the ac-
cess hatch Aand undo the cap C.
Observe the following precautions during
the refuelling operation:
– switch off the engine;
– apply the handbrake;
– turn the ignition key to the STOPpo-
sition;
– do not smoke;
– hand the special adaptor over to the
qualified LPG refuelling personnel.
IMPORTANT Before refuelling with LPG,
the qualified personnel should make sure
that the adaptor is correctly tightened on-
to the filler fitting.
IMPORTANT Depending on the country,
there are two types of adaptors for refu-
elling pumps. The adaptor that comes with
the car in a special case is specifically de-
signed for the country in which the car is
sold. If you are in a different country, find
out what type of adaptor is used there.
WHEELS
Wheel repair
The car does not have a spare wheel but
comes with a quick tyre repair kit known
as Fix&Go.
The kit is located on the left side of the
luggage compartment and is fastened by
Velcro.
For use, see the instructions in the main
Owner Handbook associated with this
supplement.
The tool box fig. 9is located under the
driver’s seat and fastened by Velcro.
FUSE REPLACEMENT
The LPG system components are protec-
ted by specific fuses. Contact a Fiat Dea-
lership if a fuse needs replacing.
For all other fuses, consult the Owner
Handbook that this supplement comes
with.
fig. 8F0Z0808m
fig. 9F0Z0607m
IMPORTANT Only use LPG for mo-
tor vehicles.
IMPORTANT Look after the LPG
adaptor carefully so that it does not
get damaged.
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 15

16
FIAT PANDA LPG
SCHEDULED SERVICING PLAN
Additional operations to the Servicing Plan in the Owner Handbook.
Thousands of kilometres
Visual check on conditions: LPG piping and connectors and
LPG tank fastening
Replacement of filter inside the pressure regulator
Paper filter replacement (LPG in gaseous state)
Check operation and parameters of fuel supply system
using self-diagnostic socket
Check mechanical tappet clearance and restore if necessary20 40 60 80 100 120 140 160 180
●●●●● ●●●●
●
●●●●● ●●●●
●●●●● ●●●●
●●●●● ●●●●
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 16

18
FIAT PANDA LPG
LPG FUEL SYSTEM
Electronic injection with special LPG injec-
tors.
Type: Multipoint phased sequential.
Stoichiometric metering of the air/gas mix-
ture.
Engine idle speed: 750 ± 50 rpm
The LPG injection system is controlled by
a dedicated control unit (connected to the
petrol unit) using the sensors already on
the car.
IGNITION
Static advance, electronic, integrated with
the injection.
PERFORMANCE
Top speed in km/h.
Running on petrol: 155
Running on LPG: 155
Modifications or repairs to
the fuel feed system that are
not carried out properly or do not
take the system technical specifica-
tions into account can cause mal-
functions leading to fire risk.
IMPORTANT
GENERAL FEATURES 1.2
Engine identification code 188A4000
Bodywork version code 169AXB1A G0BU
Cycle Otto
Number and layout of cylinders 4 in line
Piston bore and stroke mm 70.8 x 78.86
Total capacity cm31242
Compression ratio 9.8 : 1
LPG Petrol
kW 44 44
Max. EEC power HP 60 60
at a speed of rpm 5000 5000
Nm 102 102
Max. EEC torque kgm 10.4 10.4
at a speed of rpm 3000 3000
Spark plugs NGK DCPR7E-N-10
BOSCH YR7DEU
Fuel
LPGUnleaded
petrol
95 RON
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 18

19
FIAT PANDA LPG
WEIGHTS
(1) In the presence of optional equipment the unladen weight increases and, as a result, the payload decreases in relation to the
maximum permitted loads.
(2) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/or load carrying plat-
form within the maximum permitted loads.
(**) 2-seater VAN version.
(❒) 4-seater VAN version.
Weights (kg) for versions
Unladen weight (with all fluids, fuel tank
filled to 90% and without optional equipment)
Payload including the driver (1):
Maximum permitted loads (2)
– front axle:
– rear axle:
– total:
Towable loads:
– braked trailer:
– non-braked trailer:
Maximum permitted load on the roof:
Maximum load on the ball:1.2
860/875 (*) / 885 (❒)
445/505 (*) / 505 (❒)
730
660/760 (*) / 760 (❒)
1305/1380 (*) / 1390 (❒)
800
400
50
60
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 19

21
FIAT PANDA LPG
supply pressures of pumps in the net-
work, pumps with different sup-
ply/stop specifications, tank not com-
pletely in reserve condition.
It should be remembered that when using
a fuel such as LPG the range is very vari-
able because, as well as driving and car
maintenance conditions, it also depends
on the different composition of the gas
which can vary not only seasonally but al-
so from supplier to supplier. LPG is, in ef-
fect, a composition of gas (butane and
propane) mixed in a way that may not be
standardized.
BOOT CAPACITY
Capacity with vehicle unladen (V.D.A. standards) in dm3
One-piece and split rear seat
Under rear parcel shelf with rear backrest in normal position
To waist level with rear backrest folded over
Max. to the roof with rear backrest folded over
Max. to the roof with rear backrest folded over (with sun roof)
Volume of the load carrying compartment (2-seater VAN version)
Volume of the load carrying compartment (4-seater VAN version)187
471
841
796
1000
256
CAPACITIES
Petrol
Petrol . . . . . . . . . . . . . . . . . litres 35
– including a reserve of . . . litres 5
LPG
– maximum refuelling
capacity (*) . . . . . . . litres 31/27 (▲)
(▲) VAN version
(*) The value already takes into account
the 80% filling limit of the tank and the
residual fluid necessary for the priming and
is the maximum permitted refilling. This
value may undergo slight changes
from one refilling operation to the
next due to: differences between the The trip meter indication on range is indica-
tive and refers to petrol operation only.
During LPG operation, the Instant con-
sumption and Average consumption read-
ings are not significant, whereas all other
functions remain valid.
IMPORTANT Only use LPG for mo-
tor vehicles.
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 21

22
FIAT PANDA LPG
FUEL CONSUMPTION
The fuel consumption figures given in the
table below are determined on the basis
of the homologation tests set down by
specific European Directives.
The procedures below are followed for
measuring consumption:
– urban cycle: begins with cold starting,
then follows a driving path simulating the
usage of the vehicle in town;
– extra-urban cycle: driving that simulates
using the vehicle out of town with fre-
quent acceleration in all gears; the speed
varies from 0 to 120 km/h;
– combined consumption: the weighting is
around 37% urban cycle and 63% extra-
urban cycle.IMPORTANT The type of route, traffic
situations, weather conditions, driving
style, general car condition, trim lev-
el/equipment/accessories, use of the cli-
mate control system, vehicle load, roof
rack and other situations that affect air
drag may lead to different fuel consump-
tion levels than those measured. (See
Saving fuel in the Starting and driving
chapter in the handbook).
LPG range
With reference to the combined con-
sumption figures, the range while running
on LPG is 433 km (378 km for the VAN
version).
According to the European Directive in force
Petrol LPG
(litres x 100 km) (litres x 100 km)
Urban 7.0 9.0
Extra-urban 4.6 5.9
Combined 5.5 7.0
If, when refuelling with LPG,
there is an irregularity and the
tank is filled to more than the
31litres (27 litres for the VAN
version) (allowing for a surplus of 2 litres)
get help immediately from a Fiat Deal-
er. Periodically (at least once every six
months) it is advisable to let the LPG
in the tank run out and, at the first re-
fuelling, check that it does not exceed
the maximum permitted capacity.
The LPG supply system is
equipped with a "consump-
tion" function linked to the LED display
of LPG level on the switch; this function
activates only after a consistent varia-
tion in fuel level has been detected. You
are therefore advised to fill up with fu-
el at the first LPG refuelling to obtain a
more precise indication of the “level".
WARNING
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 22

CO2EMISSIONS
The CO2emission figures in the table below refer to combined fuel consumption.
According to the current
European Directive (g/km)
LPG . . . . . . . . . . . . . . . . . . . . . . . . . 114
Petrol . . . . . . . . . . . . . . . . . . . . . . . 129
FLUIDS AND LUBRICANTS
CHARACTERISTICS OF PRODUCTS
Use Quality specifications of fluids and lubricants Fluids and lubricants Interval
for correct car operation original replacements
Lubricants
for petrol/
LPG-engines
For petrol engines running on LPG, we recommend using the original product formulated specifically for the type of use.
The use of products with specifications below ACEA C3 – SAE 5W-40 could cause damage to the engine not covered
by the warranty.According to annual
maintenance and in-
spection schedule
SELENIA
MULTIPOWER
GAS 5W-40
Contractual
Technical Reference
N° F922.E09
SAE 5W-40 ACEA C3
grade totally synthetic lubricant.
FIAT 9.55535-T2specification
23
FIAT PANDA LPG
603_97_595GB PANDA GPL Euro 5 16-12-2009 12:58 Pagina 23