2009 FIAT PANDA Adventure Supplement Manual

9
FIAT PANDA ADVENTURE
ASSEMBLY DIAGRAM fig. 11
The following is merely the description of
assembly with the new hook fixing points.
The tow hook structure must be fastened
in the points shown by the symbol Øwith
a total of 4 M8 screws, 2 M12 screws. The
internal plates 1 must be 6 mm thick. The
hook should be fastened to the body
avoiding any type of drilling and trimming
of the rear bumpers that remains visible
when the hook is removed.
IMPORTANT It is compulsory to fasten a
label (plainly visible) of suitable size and
material with the following wording: MAX
LOAD ON BALL 60 kg
After fitting, screw holes shall be sealed to
prevent exhaust gas inlet.
fig. 11F0G0266m
existing screw
existing hole
existing hole
standard tow ball existing hole
existing
screw
existing hole
603_97_569 PANDA ADV Euro5 GB 9-12-2009 8:06 Pagina 9

10
FIAT PANDA ADVENTURE
20 40 60 80 100 120 140 160 180
●●●●● ●●●●
●●●●● ●●●●
●●●●● ●●●●
●●●●● ●●●●
●●●●● ●●●●
●● ● ●
●●●●● ●●●●
●●●●● ●●●●
●
●● ● ●
●● ● ●
●● ● ●
●●
MAINTENANCE SCHEDULE
Thousands of kilometres
Check tyre condition/wear and, if necessary,
adjust pressure
Check lighting system operation (headlights, direction indicators,
hazard lights, passenger compartment lights, boot lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer operation,
adjustment of spray nozzles
Check position/wear of
front/rear windscreen wiper blades
Check front disk brake pad conditions and wear
Check rear disc brake pad condition and wear
Visually inspect the condition of: bodywork, underbody
protection, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, hoses, bushes, etc.)
Check cleanness of locks, bonnet and boot and lever
cleanness and lubrication
Check tension and conditions of various accessory drive belts
(except for engines with automatic take-up devices)
Visually inspect the condition of the accessory drive belt
Check and adjust tappets (petrol versions)
Check handbrake stroke adjustment
Check anti-evaporation system (petrol versions)
603_97_569 PANDA ADV Euro5 GB 9-12-2009 8:06 Pagina 10

11
FIAT PANDA ADVENTURE
20 40 60 80 100 120 140 160 180
●● ●
●● ●●●●●●●
●●
●
●●●●
●●●●
●●
●● ●●●●●●●
●● ●
●● ●●●●●●●
●●●●
●● ●
Thousands of kilometres
Replacement of air filter cartridge
(every 30,000 km/for 1.3 Multijet engine)
Top up liquids if required
(engine coolant, brakes, windscreen washer, battery, etc.)
Check timing belt conditions
(excluding 1.3 Multijet engine)
Replace timing belt (*)
(excluding 1.3 Multijet engine)
Replace spark plugs (petrol versions)
Check operation of engine management systems
(using diagnostic socket)
Check mechanical gearbox fluid level
Replacement of engine oil and oil filter
(every 30,000 km/for 1.3 Multijet engine)
Change brake fluid (or every two years)
Replace pollen filter (or once a year)
Check exhaust emissions/smokiness (1.3 Multijet engines)
Replace fuel filter (Green filter)
(1.3 Multijet engine)
(*) Irrespective of mileage, the timing drive belt must be replace every 4 years for heavy duty applications, cold climates, town use, long periods idling) or at
least every 5 years.
603_97_569 PANDA ADV Euro5 GB 9-12-2009 8:06 Pagina 11

BODYWORK VERSIONS
Versions Engine Bodywork codes
2-seater 4-seater
1.2 169 AXF2A 09E (*) 169 AXF2A 09F (*)
1.3 Multijet 169 AXC2A 0FM 169 AXC2A 0FN
(*) Euro 5
12
FIAT PANDA ADVENTURE
Fiat Panda Adventure
ENGINE CODES
Versions
(*) Euro 5
Fiat Panda Adventure
Engine
1.2
1.3 MultijetEngine code
169 A 4000 (*)
188 A 8000
603_97_569 PANDA ADV Euro5 GB 9-12-2009 8:06 Pagina 12

Version Rims Tyres Spare wheel
Rim Tyre
(*) Space-saver spare wheel for versions/markets, where provided
13
FIAT PANDA ADVENTURE
Please do not drive for long dis-
tances with the wheels not at
the prescribed pressure (wheels
partially or totally flat), as this
may damage the viscous joint.
RIMS AND TYRES
The tyres on this version have been designed to yield the best possible balance between road performance and performance on non-
asphalted and/or snow and icy ground. These tyres are marked by a high capacity to run on off-road conditions and good driving
both on snowy/icy ground and on wet/dry ground.
5,5J X 14
165/70 R14 81T M+S5,5J X 14
4.00B X 14 (*)165/70 R14 81T M+S
135/80 R14 84P (*) Fiat Panda
Adventure
Versions Medium load Full load
Front rear front rear
1.22,3 2,3 2,3 2,5
1.3 Multijet2,3 2,3 2,3 2,5
INFLATION PRESSURE (bar)
2-SEATER
Versions Medium load Full load
Front rear front rear
1.22,2 2,0 2,3 2,3
1.3 Multijet2,3 2,1 2,3 2,3
4-SEATER
603_97_569 PANDA ADV Euro5 GB 9-12-2009 8:06 Pagina 13

14
FIAT PANDA ADVENTURE
TRANSMISSION
Gearbox
Clutch
Drive
Keep your speed down when
snow chains are fitted. Do
not exceed 50 km/h. Avoid potholes,
steps and pavements and also avoid
driving long distances on roads not
covered with snow in order to prevent
damaging the car and the roadbed.The snow chains may be ap-
plied only onto the front
wheel tyres.
SNOW CHAINS
Use of snow chains should be in compli-
ance with local regulations.
Chains can be fitted on 165/70 R14 81T
M+S tyres. For tyres to which chains can
be fitted, only use compact chains (maxi-
mum extension beyond tyre profile 9 mm).
WARNING
Use of Lineaccessori Fiat snow chains is
recommended.
Check the tension of the chains after the
first few metres have been driven.
Five forward gears plus reverse
with synchronisers for forward gears
Self-registering with play-less pedal
Automatic insertion by means of electronically controlled joint and two differentials
rack and pinion with electric power steering
9,6
STEERING SYSTEM
Fiat Panda Adventure
Type
Steering circle
(kerb to kerb) m
603_97_569 PANDA ADV Euro5 GB 9-12-2009 8:06 Pagina 14

15
FIAT PANDA ADVENTURE
DIMENSIONS
Dimensions are expressed in mm and re-
fer to the vehicle equipped with its origi-
nal tyres.
Height is measured with vehicle unladen.
Versions A B C D E F G H
Fiat Panda Adventure3574 721 2305 548 1632 1358 1605 1366
F0G0708m
603_97_569 PANDA ADV Euro5 GB 9-12-2009 8:06 Pagina 15

16
FIAT PANDA ADVENTURE
LOAD COMPARTMENT
1.2
148 (*)1.3 Multijet
150
1.2
2,7
0,61.3 Multijet
2,7
0,6Recommended fuels
and recommended products
TUTELA CAR TECHNYX (*)
TUTELA CROSS 75W85(**)
Maximum length mm
Maximum width mm
Width between wheel arches mm
Maximum height mm
Height of load platform from ground mm
Load compartment volume dm3
PERFORMANCE
Fiat Panda Adventure
Top permissible speed after initial car use in km/h.
(*) Euro 5
CAPACITIES
Gearbox casing/differential: litres
Rear differential: litres
(*) Synthetic oil SAE 75W-85. Exceeds specifications API GL4 PLUS, MIL - L - 2105 D Lev
(**) Synthetic oil SAE 75W-85. Exceeds specifications API GL5, MIL - L - 2105 D Lev
2-seater version
1150
1220
1020
1000
560
10004-seater version
480
1020
1020
800
540
275
603_97_569 PANDA ADV Euro5 GB 9-12-2009 8:06 Pagina 16