2009 FIAT FIORINO lock

161
SAFETY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
PERIODIC CHECKING
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressure and conditions;
❒operation of lights (headlights, direction
indicators, emergency lights, etc.);
❒operation of the windscreen wiper/
washer system, position and wear of
the windscreen and rear window wiper
blades (where provided);
Every 3,000 km check the following and
top-up, if required: engine oil level.
You are recommended to use FL Sele-
niaproducts, designed and produced
specifically for Fiat vehicles (see table “Re-
fuelling” in section “Technical specifica-
tions”).
DEMANDING
VEHICLE USE
Should prevailing use of the vehicle be un-
der one of the following specially heavy
conditions:
❒trailer towing;
❒dusty roads;
❒short repeated distances (less than 7-
8 km) and with external temperatures
below zero;
❒frequently idling engine or long distance
low speed driving (e.g. taxis or door-to-
door deliveries) or in case of a long
term inactivity;
❒urban driving;
perform the following inspections more
frequently than shown on the Scheduled
Servicing Plan:
❒check front disk brake pad conditions
and wear;❒check cleanness of bonnet and boot
locks and lever cleanness and lubrica-
tion;
❒visually inspect the conditions of: the
engine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
❒check the battery and the battery fluid
(electrolyte) (this check must be car-
ried out by skilled personnel only or by
the Fiat Dealership – also refer to the
instructions provided in the “Battery”
paragraph of this section);
❒visually check the various drive belt
conditions;
❒check pollen filter and replace it, if re-
quired;
❒check air cleaner and replace it, if re-
quired.
155-176 CombiCargo GB 1ed 21-10-2008 14:13 Pagina 161

176
SAFETY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
CLEANING SEATS
AND FABRIC PARTS
Remove dust with a soft brush or a vacu-
um cleaner. It is advisable to use a moist
brush on velvet upholstery.
Rub the seats with a sponge moistened
with a solution of water and neutral de-
tergent.
CLEANING PLASTIC PARTS
It is advisable to clean interior plastic parts
with a moist cloth and a solution of wa-
ter and mild soap. Remove grease and
tough stains using specific solvent-free
products for cleaning plastic parts specif-
ically designed to prevent damage to the
appearance and colour of the treated
parts.
IMPORTANT Never use spirit or petro-
leum to clean the instrument panel.STEERING WHEEL/GEARBOX
LEVER KNOB/HANDBRAKE
COATED WITH REAL LEATHER
(where provided)
These components must be cleaned with
mild soap and water only. Never use spir-
it and/or alcohol based products.
Before using specific products for clean-
ing the interiors, carefully read the in-
structions on the product label and ensure
that it does not contain alcohol and/or al-
cohol-based substances.
If drops of the specific product for clean-
ing windows accidentally falls onto the
leather of the steering wheel / gear lever
knob during windscreen window washing,
immediately wipe the drops away and then
wash the area with mild soap and water.
IMPORTANT If a lock device is installed
on the steering wheel, maximum care
must be taken during installation in order
to prevent abrasions of the leather up-
holstery.INTERIORS
Periodically check that water is not
trapped under the mats (due to water
dripping off shoes, umbrellas, etc.) which
could cause oxidisation of the sheet met-
al.
Never use flammable prod-
ucts, such as petrol, ether or
rectified petrol, to clean the vehicle
interior. The electrostatic charges
which are generated by rubbing dur-
ing cleaning operations may cause a
fire.
WARNING
Do not keep aerosol cans in
the vehicle: risk of explosion.
Aerosol cans must not be exposed to
a temperature exceeding 50°C. When
the vehicle is exposed to sunlight, in-
ner temperature can greatly exceed
this value.
WARNING
155-176 CombiCargo GB 1ed 21-10-2008 14:13 Pagina 176

179
SAFETY
INDEX
DASHBOARDAND CONTROLS
STARTING
AND DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
BODYWORK PAINT
IDENTIFICATION PLATE fig. 4
This plate is applied inside the bonnet and
shows the following data:
A- Paint manufacturer.
B- Colour name.
C- Fiat colour code.
D- Re-spray and touch up code.ENGINE MARKING
Engine marking is stamped on the cylinder
block and includes the model and the
chassis number.
CHASSIS MARKING
This is stamped on the passenger com-
partment floor near the front right seat.
Access to this marking is gained by slid-
ing the door forward, A-fig. 3.
The chassis marking includes:
❒the vehicle model (ZFA 225000);
❒the chassis progressive number.
fig. 4F0T0012mfig. 3F0T0084m
177-199 CombiCargo GB 1ed 22-10-2008 8:00 Pagina 179

198
DASHBOARD
The presence and position of the controls, the instruments and the indicators may vary according to the versions.
1.Vent for air delivery to side windows - 2.Adjustable and directable air vent - 3.Airbag on passenger’s side (where provided) -
4.Emergency light switch, rear heated window, Bluetooth system controls (where provided), rear swing-door unlock device
(where provided) - 5.Sound system (where provided) - 6.Left stalk: external lights control - 7.Instrument and warning light panel -
8.Right stalk: windscreen wiper controls, rear window wiper, trip computer - 9.Control panel: fog lights/rear fog light/headlight po-
sition adjustment/display - 10.Ignition device - 11.Airbag on driver’s side - 12.Adjustable and directable air vents - 13.Glove box -
14.HVAC controls - 15.Glove box/oddment compartment (where provided) - 16.Stalk for opening bonnet
F0T0225mfig. 1
RIGHT HAND DRIVE VERSIONS
177-199 CombiCargo GB 1ed 22-10-2008 8:00 Pagina 198

200
WARNING
LIGHTS AND
MESSAGES
DASHBOARDAND CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Boot ................................................65-67
Bonnet ...................................................... 68
Brake lights
– bulb replacement ............................. 140
Brake Assist ............................................. 72
Brakes........................................................ 185
Bulb replacement ................................... 134
Bulkheads ................................................. 36
Capacities ................................................ 191
Car radio (provision for) ...................... 79
Care and maintenance .......................... 155
– heavy duty use of vehicle ............... 161
– routine checks .................................. 161
– routine maintenance ....................... 156
– service plan ....................................... 157
Child carriers .......................................... 89
Childproof device .................................. 61
Choke ....................................................... 14
Cigar lighter ............................................ 57
Clutch ....................................................... 182
CO
2emissions ........................................ 196
Controls ................................................... 55Dashboard and controls................. 4
Dead lock device .................................... 10
Desk .......................................................... 58
Digital display .......................................... 16
Dimensions .............................................. 187
Doors
– centralized lock/unlock .................. 59
– childproof safety .............................. 61
– double panel rear doors ................62
– sliding side doors ............................. 59
Driver protector .................................... 37
EBD system ............................................ 71
Engine codes- Engine compartment .. 175
Engine oil
– consumption ..................................... 163
– level check ......................................... 165
Engine starting ..............................102-124
Engine
– fuel system ........................................ 182
– identification codes ......................... 180
– powertrain ........................................ 182
– specification ...................................... 181
Environmental protection .................... 82 ABS system ............................................. 71
Added-on electrical/electronic devices 80
Air cleaner/anti/pollen .......................... 167
Air outlets ............................................... 42
Airbag .............................................96-98
Alarm ........................................................ 11
Ash tray .................................................... 57
ASR system ............................................. 74
Backlight washer
– control ............................................... 51
– liquid level ......................................... 164
Backlight wiper
– blade ................................................... 172
– control ............................................... 51
– nozzle ................................................. 172
Backup light
– bulb replacement ............................. 140
Battery
– recharging .......................................... 153
– replacement ...................................... 167
Body versions ......................................... 180
Body
– maintenance ...................................... 173
– version coding .................................. 180
II I
N N
D D
E E
X X
200-208 CombiCargo GB 1ed 22-10-2008 8:01 Pagina 200

202
WARNING
LIGHTS AND
MESSAGES
DASHBOARDAND CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Roof struts
– retentions .......................................... 69
Rubber hoses .......................................... 170
Safety...................................................... 83
Saving fuel ................................................ 106
SBR system .............................................. 85
Seat belt pretensioners ......................... 86
Seat belts (use) ....................................... 84
Seats
– adjustments ....................................... 33
– cleaning .............................................. 176
– foldaway passenger seat ................. 34
– heated ................................................ 33
Snow chains ............................................. 110
Spark plugs (type) .................................. 181
Specifications ........................................... 177
Speed block ............................................. 76
Starting and driving......................... 101
Stationary vehicle ................................... 104
Steering .................................................... 183
Steering column controls
– left lever ............................................. 49
– right lever .......................................... 51
Steering lock ........................................... 13
Steering wheel ........................................ 38
Sun visors ................................................. 58Suspensions ............................................. 183
Symbols .................................................... 7
Technical specifications................. 177
Tires
– inflation pressures ........................... 186
– replacement ...................................... 127
– snow tires ...............................109-186
– standard ............................................. 186
– tire data ............................................. 184
Towing the vehicle ................................ 154
Trailer towing ......................................... 108
Transmission operation ........................ 105
Trip computer ........................................ 30
Trunk
– emergency opening ......................... 64
– extension ........................................... 66
– load restraint .................................... 67
– shelf removal .................................... 65
Turn signal lights
– control ............................................... 50
– front bulb replacement ................... 138
– lane change function ....................... 50
– rear bulb replacement .................... 140
– side bulb replacement ..................... 139
Vehicle starting and driving ................. 101
Ventilation ............................................... 41 Parking lights
– bulb replacement ............................. 137
– control ............................................... 49
Performance ............................................ 189
Power socket .......................................... 57
Powertrain ............................................... 182
Prolonged inactivity ............................... 110
Provision for installation
of pushout side windows ................... 58
– cleaning .............................................. 177
Radio transmitters
and mobile telephones ....................... 80
Raising the vehicle .................................. 153
Rear fog light
– bulb replacement ............................. 140
– control rear roof lights ........ 143-144
Rear view mirrors
– external .............................................. 39
– interior ............................................... 39
– power-operated ............................... 40
Refueling .................................................. 80
Removable roof lamp ............................ 54
Roof lights
– bulb replacement
– on/off control .........................52-53-54
200-208 CombiCargo GB 1ed 22-10-2008 8:01 Pagina 202