2009 FIAT DUCATO steering wheel

F0N0109mfig. 230
POWER STEERING FLUID fig. 230
Check that the liquid contained in the tank is at the
maximum level. This operation must be carried out with
the vehicle level and with the engine off and cold. Check
that the fluid level is up to the MAX mark on the
dipstick attached to the fuel cap (use the level shown on
the 20°C side of the dipstick to check when cold).
If the level of the fluid in the tank is lower than the
specified level, top up using only one of the products
indicated in the “Fluid and lubricants” table in the
“Technical specifications” section, proceeding as follows:
❒Start the engine and wait for the level of fluid in the
tank to stabilise.
❒With the engine running, turn the steering wheel
from right to left fully, several times.
220
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Power steering fluid consumption is very
low. If the fluid needs topping up a short
time after the last top-up, have the
system checked by a Fiat Dealership to ensure
there are no leaks.
Do not press the power steering end of
travel lock for longer than 8 consecutive
seconds with the engine running because
it will cause noise and risk damaging the system.
❒Top up the fuel to the MAX level and then retighten
the cap.
Prevent power steering fluid from
coming into contact with hot engine
parts: the liquid is flammable.
WARNING
207-230 DUCATO LUM EN 7ed 6/21/10 2:17 PM Page 220

224
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
F0N0111mfig. 233
IMPORTANT NOTES
❒Avoid braking suddenly, burning starts and violent
knocks against the curb, potholes or other obstacles
if possible. Driving for long stretches over bumpy
roads can damage the tyres;
❒check the tyres regularly for cuts on the sides,
swelling or irregular tread wear. Contact a Fiat
Dealership if required.
❒avoid overloading the car when travelling: this may
cause serious damage to the wheels and tyres;
❒if a tyre is punctured, stop the vehicle immediately
and change it to avoid damage to the tyre, the rim,
the suspensions and the steering system;
❒a tyre will age even if it is not used much. Cracks in
the tread and on the sidewalls are a sign of ageing.
Have the tyres checked by skilled personnel if they
have been fitted for longer than six years. Also
remember to check the space-saver wheel very
carefully;
❒In the case of replacement, always fit new tyres,
avoiding those with an unknown origin.
❒If a tyre is replaced, also change the inflation valve.
❒to allow an even wear between the front and rear
tyres, it is advisable to change them over every
10-15 thousand kilometres, keeping them on the
same side of the vehicle so as not to reverse the
direction of rotation.
WHEELS AND TYRES
Check the pressure of each tyre, including the space-
saver wheel, approximately every two weeks and before
long journeys: the pressure should be checked with the
tyre rested and cold. It is normal for the pressure to
increase when the vehicle is used; for the correct tyre
inflation pressure, see “Wheels” in the “Technical
specifications” section. Incorrect pressure causes
abnormal tyre wear fig. 233:
A normal pressure: tread evenly worn.
B low pressure: tread particularly worn at the edges.
C high pressure: tread particularly worn in the centre.
The tyres must be replaced when the tread is less than
1.6 mm thick. In all cases, follow the laws in force in the
country where you are driving.
207-230 DUCATO LUM EN 7ed 6/21/10 2:17 PM Page 224

230
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
INTERIOR PLASTIC PARTS
It is advisable to clean interior parts with a moist cloth
and a solution of water and mild soap. Use specific
products for cleaning plastic, without solvents and
specifically designed to prevent damage to the
appearance and colour of the treated parts to remove
grease and tough stains.
IMPORTANT Never use alcohol or petroleum to clean
the instrument panel.
LEATHER STEERING WHEEL/GEAR KNOB
These components must be cleaned with mild soap and
water only.
Never use alcohol and/or alcohol-based products.
Before using off-the-shelves products designed for
cleaning car interiors, make sure that they do not
contain alcohol and/or alcohol based substances before
using them.
If window cleaner accidentally drips onto the steering
wheel or gear lever knob, wipe away immediately and
then wash the affected area with mild soap and water.
IMPORTANT Be careful when using a steering wheel
lock device, where applicable, to prevent damaging the
leather upholstery by rubbing. SEATS AND FABRIC PARTS
Remove dust with a soft brush or a vacuum cleaner. It is
advisable to use a moist brush on velvet upholstery.
Rub the seats with a sponge moistened with a solution
of water and neutral detergent.
The fabric upholstery of your vehicle is
designed to withstand the normal wear
and tear of your vehicle for a long time.
You are however recommended to avoid strong
and/or continuous scratching with clothing
accessories such as metal buckles, studs, Velcro
fastenings and the like, as these items cause stress
of the cover fabric that could lead threads to
break and damage the upholstery.
207-230 DUCATO LUM EN 7ed 6/21/10 2:18 PM Page 230

self-ventilated discs
discs
controlled by hand lever, acting on rear brakes
236
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
STEERINGShort Medium Medium-long Longwheelbase wheelbase wheelbase wheelbase
Type
Steering circle
(kerb to kerb) m 11,06 12,46 13,54 14,28
Rack and pinion with hydraulic power steering
BRAKES
Service brakes: front
rear
Parking brake
IMPORTANT Water, ice and antifreeze salt spread on the roads may deposit on the brake discs reducing braking efficiency
the first time the brakes are applied.
231-276 DUCATO LUM EN 9ed 15-04-2011 8:20 Pagina 236

268
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
According to
Scheduled
Servicing Plan
Manual gearbox
and differential
Manual gearbox
and differential
Wheel side
constant velocity
joints
Differential side
constant velocity
joints
Differential side
constant velocity
joints
Hydraulic power
steering
Lubricants
(▲)
For diesel engines, in the event of an emergency in which the original products are not available, lubricants with at least ACEA C2
performance are acceptable; however, in this case optimum engine performance is not guaranteed and the lubricants should be replaced
with recommended products as soon as possible at a Fiat Dealership.
The use of products with lower specifications than ACEA C2 could cause damage to the engine not covered by the warranty.
For particularly harsh climate conditions, ask a Fiat Dealership for the appropriate product from PETRONAS LUBRICANTS.
SAE 5W-30 grade synthetic base lubricant.
FIAT 9.55535-S1 certification.
Synthetic base lubricant, SAE 75W-80 grade
that exceeds API GL-4 specifications
Synthetic base lubricant, SAE 75W-85 grade
that exceeds API GL-4 specifications
Lithium soap grease with molybdenum
disulphide. NI.GI. 2 consistency
Lithium-based grease
NI.GI. 0 consistency
Poly-urea synthetic-based grease suitable for
high temperatures. NI.GI. 2 consistency
Lubricant for power steering and automatic
transmissions. Exceeds
ATF DEXRON IIISELENIA WR P.E.(▲)
Contractual Technical
Reference No. 510.D07
TUTELA CAR EXPERYA
Contractual Technical
Reference No. F178.B06
TUTELA CAR MATRYX
Contractual Technical
Reference No. F108.F02
TUTELA STAR 500
TUTELA MRM ZERO
TUTELA STAR 325
Contractual Technical
Reference No. F301.D03
TUTELA GI/E
Contractual Technical
Reference No. F001.C94Diesel engine
lubricants
Lubricants
and greases
for motion
transmission
FLUIDS AND LUBRICANTS
SPECIFICATIONS AND RECOMMENDED PRODUCTS
Use Quality specifications of fluids and lubricants Genuine lubricants Replacement for correct vehicle operation and fluids interval
231-276 DUCATO LUM EN 9ed 15-04-2011 8:21 Pagina 268

278
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– positioning
the restraint systems
on the seats ................137-140
– preparation for “Isofix
Universale” child seat ........ 138
Central door
locking/unlocking system ..... 102
Changing a wheel ..................... 174
Chassis (marking) .................... 233
Checking the levels ................. 213
– brake fluid ............................ 219
– engine coolant .................... 217
– engine oil ............................. 215
– power steering fluid .......... 220
– washer fluid for
windscreen/rear
window/headlamps ............ 218
Cigar lighter ............................... 94
Cleaning and maintenance
– bodywork ............................ 227
– engine compartments ....... 229– front headlights .................. 229
– interiors ............................... 229
– leather upholstery ............. 230
– paintwork ............................ 228
– plastic parts ......................... 230
– rubber tubes ....................... 225
– seats and fabric parts ........ 230
– windows ............................... 229
– windows ................................ 229
CO
2emissions ......................... 271
Code card................................... 5
Compartment under front
passenger seat ........................ 92
Controls .................................... 85
Cruise Control (constant
speed regulator) .................... 80
Cup/can holder ........................ 93
Dashboard ................................ 3
Dashboard and controls ........ 3
Dead lock (device) .................. 105
Desk/bookrest .........................96
Digital display ............................ 18
Dimensions ............................... 241
Direction indicators
– bulb replacement ....... 190-192
– control ................................. 75
– front bulb replacement ..... 190
– rear bulb replacement ...... 192
Door lock .................................. 87
Door pockets ........................... 92
Doors ......................................... 102
DPF
(diesel particulate filter) ....... 128
EBD (system) ...........................114
Electric windows ...................... 109
Electricity supply and fuel
cutoff switch ........................... 88
277-284 DUCATO LUM EN 9ed 15-04-2011 8:32 Pagina 278

283
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Shelf above the cab ................. 96
Side air bags .............................. 143
Side lights
– control ................................. 74
– front bulb replacement ..... 189
– rear bulb replacement ...... 192
– side bulb replacement ....... 196
Ski rack ...................................... 112
Sliding side door ...................... 106
Sliding side window ................. 106
Snow chains .............................. 159
Speed block ............................... 102
Speedometer ............................ 15
Starting the engine ................... 147
– bump starting ...................... 174
– emergency starting ............ 173
– ignition switch ..................... 12
– jump starting ....................... 173
– procedure ............................ 147
– stopping the engine ........... 148
– warming up the engine
once started ........................148Starting up and driving ............ 147
Steering lock ............................. 13
Steering wheel
(adjustment) ........................... 47
Steering
– technical specifications ...... 236
– turning circle ....................... 236
Storage compartments ..... 90-91
Sun visors .................................. 95
Supply (specifications) ............. 235
Suspension (specifications) .... 235
Symbols ...................................... 4
Tachograph ..............................101
Technical specifications .......... 231
Telepass (preparation) ............ 126
Third brake light ...................... 195
Towing the vehicle .................. 205
Trailer (towing) ....................... 154
– installing the tow hook ..... 155
– warnings ...............................155Transmission
(specifications) ....................... 235
Trip computer .......................... 35
TV camera system and rear
visibility display ....................... 98
Tyre inflation pressure ........... 240
Tyres
– changing a wheel ................ 174
– maintenance ........................ 224
– provided ...............................239
– reading tyre markings ....... 237
– Rim Protector .................... 238
– snow ..................................... 159
– tyre inflation pressure ....... 240
Under-seat compartment ..... 42
Vehicle identification data ...... 231
Vehicle inactivity ...................... 160
Ventilation ................................. 51
277-284 DUCATO LUM EN 9ed 15-04-2011 8:32 Pagina 283