2009 DODGE RAM 3500 DIESEL ECU

Double LineBecause pulling power decreases with the number of
layers of wire rope on the winch drum, you can use a
snatch block to double line out more wire rope. This
decreases the number of layers of wire rope on the drum,
and increases pulling power. Start by feeding out enough
wire rope to free the winch hook. Attach the hook to yourvehicle’s frame/tow hook and run the wire rope through
a snatch block. Disengage the clutch and, using the
snatch block, pull out enough wire to reach your anchor
point. Do not attach the hook to the mounting kit. Secure
to the anchor point with a tree trunk protector or choker
chain. Attach the clevis/shackle. Attach the shackle to the
two ends of the strap/chain, being careful not to over
tighten (tighten and back-off 1/2 turn).
POWER STEERINGThe standard power steering system will give you good
vehicle response and increased ease of maneuverability
in tight spaces. The system will provide mechanical
steering capability if power assist is lost.
If for some reason the power assist is interrupted, it will
still be possible to steer your vehicle. Under these condi-
tions, you will observe a substantial increase in steering
effort, especially at very low vehicle speeds and during
parking maneuvers.
STARTING AND OPERATING 327
5

then be determined separately to be sure that the load is
properly distributed over front and rear axle. Weighing
the vehicle may show that the GAWR of either the front
or rear axles has been exceeded but the total load is
within the specified GVWR. If so, weight must be shifted
from front to rear or rear to front as appropriate until the
specified weight limitations are met. Store the heavier
items down low and be sure that the weight is distributed
equally. Stow all loose items securely before driving.
Improper weight distributions can have an adverse effect
on the way your vehicle steers and handles and the way
the brakes operate.
CAUTION!
Do not load your vehicle any heavier than the GVWR
or the maximum front and rear GAWR. If you do,
parts on your vehicle can break, or it can change the
way your vehicle handles. This could cause you to
lose control. Also overloading can shorten the life of
your vehicle.TRAILER TOWINGIn this section you will find safety tips and information
on limits to the type of towing you can reasonably do
with your vehicle. Before towing a trailer carefully re-
view this information to tow your load as efficiently and
safely as possible.
To maintain warranty coverage, follow the requirements
and recommendations in this manual concerning ve-
hicles used for trailer towing.
STARTING AND OPERATING 383
5

WARNING!
Improper towing can lead to an injury accident.
Follow these guidelines to make your trailer towing
as safe as possible:
Make certain that the load is secured in the trailer
and will not shift during travel. When trailering
cargo that is not fully secured, dynamic load shifts
can occur that may be difficult for the driver to
control. You could lose control of your vehicle and
have an accident.•
When hauling cargo or towing a trailer, do not over-
load your vehicle or trailer. Overloading can cause a
loss of control, poor performance or damage to brakes,
axle, engine, transmission, steering, suspension, chas-
sis structure or tires.
•
Safety chains must always be used between your
vehicle and trailer. Always connect the chains to theframe or hook retainers of the vehicle hitch. Cross the
chains under the trailer tongue and allow enough
slack for turning corners.
•
Vehicles with trailers should not be parked on a grade.
When parking, apply the parking brake on the tow
vehicle. Put the tow vehicle automatic transmission in
PARK. With four-wheel-drive vehicles, make sure the
transfer case is not in neutral. Always, block or
chock
the trailer wheels.
•
GCWR must not be exceeded.
•
Total weight must be distributed between the tow
vehicle and the trailer such that the following four
ratings are not exceeded:
1. GVWR
2. GTW
3. GAWR
STARTING AND OPERATING 391
5

WARNING! (Continued)
•
Do not get under the vehicle when it is on a jack.
•
Only use the jack in the positions indicated and
for lifting this vehicle during a tire change.
•
If working on or near a roadway, be extremely
careful of motor traffic.
•
To assure that spare tires, flat or inflated, are
securely stowed, spares must be stowed with the
valve stem facing the ground.
•
Turn on the Hazard Warning flasher.
1. Remove the spare wheel, jack, and tools from storage. 2. Using the wheel wrench, loosen, but do not remove,
the wheel nuts by turning them counterclockwise one
turn while the wheel is still on the ground.
3. Placement of the Jack:
•
For 2500/3500 4x2 series trucks, when changing a
front wheel, place the bottle jack under the frame
rail behind the wheel. Locate the jack as far forward
as possible on the straight part of the frame.
Jack Warning Label
4x2 Jacking Location
WHAT TO DO IN EMERGENCIES 411
6

Adding Fuel........................... 379
Adjustable Pedals ....................... 141
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 434
Air Conditioner Maintenance ............... 435
Air Conditioning Refrigerant .............435,436
Air Conditioning System ................237,435
Air Conditioning System, Zone Control ........ 240
Air Pressure, Tires .................... 355,360
Airbag ............................ 34,47,54
Airbag Light ....................... 58,75,189
Airbag On/Off Switch ..................... 54
Alarm Light ........................... 191
Alarm (Security Alarm) .................... 18
Alarm System (Security Alarm) ............... 18
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 230
Antifreeze (Engine Coolant) ...........442,443,478
Disposal ............................ 445
Anti-Lock Brake System (ABS) .............. 333Anti-Lock Warning Light
...............196,332
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Anti-Theft System ........................ 18
Appearance Care ........................ 452
Ashtray ............................... 164
Assistance Towing ....................... 101
Automatic Dimming Mirror ................. 82
Automatic Transaxle ...................... 12
Interlock System ....................... 14
Automatic Transmission Adding Fluid ......................... 451
Fluid and Filter Changes ................. 452
Fluid Level Check ................... 449,450
Fluid Type ........................ 449,480
Shifting ............................. 255
Special Additives ...................... 452
Axle Fluid .......................... 448,480
Axle Lubrication (Axle Fluid) ............... 448510 INDEX

Electronic Stability Program (ESP)
Indicator......................... 197,340
Engine Temperature Warning .............. 200
Exterior .............................. 76
Fog .......................... 135,193,468
Four-Wheel Drive Indicator ............... 264
Hazard Warning Flasher ................. 406
Headlights ........................... 134
High Beam ........................ 137,189
High Beam Indicator .................... 189
High Beam/Low Beam Select ............. 137
Illuminated Entry ....................... 20
Instrument Cluster ..................... 188
Interior .......................... 132,145
Lights On Reminder .................... 135
Malfunction Indicator (Check Engine) ........ 194
Oil Pressure .......................... 201
Passing ............................. 137
Seat Belt Reminder ..................... 189 Security Alarm (Theft Alarm)
.............. 191
Service ........................... 464,465
Service Engine Soon (Malfunction Indicator) . . . 194
Side Marker .......................... 477
Theft Alarm (Security Alarm) .............. 191
Tire Pressure Monitoring (TPMS) ........... 197
Traction Control ....................... 340
Transfer Case ......................... 264
Transmission Warning ................... 199
Turn Signal ................... 76,136,465,469
Voltage ............................. 201
Warning (Instrument Cluster Description) ..... 188
Limited-Slip Differential ................... 304
Loading Vehicle ......................... 381
Tires ............................... 350
Locks ................................. 27
Child Protection ........................ 30
Door ................................ 27
Keys ................................ 12518 INDEX

Rear Folding....................... 126,127
Reclining ......................... 121,122
Reclining Rear ........................ 125
Security Alarm (Theft Alarm) ................ 18
Selection of Coolant (Antifreeze) ..........442,479
Sentry Key (Immobilizer) ................... 15
Sentry Key Programming ................... 17
Sentry Key Replacement ................... 16
Service Assistance ....................... 501
Service Contract ......................... 503
Service Engine Soon Light
(Malfunction Indicator) .................... 194
Service Manuals ........................ 505
Setting the Clock ................ 202,204,218,224
Shifting ............................... 254
Automatic Transmission ................. 255
Transfer Case ......................... 263
Transfer Case, Shifting into Transfer Case
Neutral (N) ....................... 398,400Transfer Case, Shifting out of Transfer Case
Neutral (N)
....................... 399,402
Shoulder Belt Upper Anchorage .............. 42
Shoulder Belts ........................... 35
Signals, Turn ...................... 76,136,188
Sliding Rear Window Power .............................. 173
Snow Chains (Tire Chains) ................. 361
Snow Plow ............................ 396
Snow Tires ............................ 363
Spark Plugs ............................ 479
Speed Control (Cruise Control) .............. 142
Speedometer ........................... 189
Stabilizer/Sway Bar System ................ 282
Starting ............................... 252
Automatic Transmission ................. 252
Engine Fails to Start .................... 252
Remote .............................. 25
Starting Procedures (Gas Engines) ............ 252
INDEX 523
10

INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VAN CONVERSIONS/CAMPERS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
A WORD ABOUT YOUR KEYS Ignition Key RemovalLocking Doors With A KeySTEERING WHEEL LOCK - IF EQUIPPED To Manually Lock the Steering WheelTo Release the Steering Wheel LockAutomatic Transmission Ignition Interlock SystemSENTRY KEY Replacement
KeysCustomer Key ProgrammingGeneral InformationVEHICLE SECURITY ALARM - IF EQUIPPED Rearming of the SystemTo Set the AlarmTo Disarm the SystemILLUMINATED ENTRY SYSTEM - IF EQUIPPED REMOTE KEYLESS ENTRY (RKE) - IF EQUIPPED To
Unlock the DoorsTo Lock the DoorsUsing the Panic AlarmProgramming Additional RKE TransmittersGeneral InformationRKE Transmitter Battery ServiceREMOTE STARTING SYSTEM - IF EQUIPPED How to Use Remote StartDOOR LOCKS Manual Door LocksPower
Door Locks - If EquippedChild Protection Door LockWINDOWS Power Windows-If Equipped Wind BuffetingOCCUPANT RESTRAINTS Lap/Shoulder BeltsAdjustable Upper Shoulder Belt AnchorageAutomatic Locking Retractors (ALR) Mode - If EquippedCenter Lap Belts
Seat Belt Pretensioners - If EquippedEnhanced Seat Belt Use Reminder System (BeltAlert) Seat Belts and Pregnant WomenSeat Belt ExtenderDriver And Right Front Passenger Supplemental Restraint System (SRS) - Airbags Event Data Recorder (EDR)Child Restraints
ENGINE BREAK-IN RECOMMENDATIONS SAFETY TIPS Transporting PassengersExhaust GasSafety Checks You Should Make Inside the VehiclePeriodic Safety Checks You Should Make Outside the VehicleUNDERSTANDING THE FEATURES OF YOUR VEHICLE
MIRRORS Inside Day/Night MirrorAutomatic Dimming Mirror - If EquippedOutside MirrorsOutside Mirrors Folding FeaturePower Mirrors - If EquippedHeated Mirrors - If EquippedTrailer Towing Mirrors - If Equippeduconnect phone - IF EQUIPPED OperationPhone Call
Featuresuconnect phone FeaturesAdvanced Phone ConnectivityThings You Should Know About Your uconnect phoneGeneral InformationVOICE RECOGNITION (VR) SYSTEM - IF EQUIPPED Voice Recognition (VR) System OperationCommandsVoice TrainingSEATS
Manual Seat Adjuster - If EquippedReclining Seats (Quad Cab Models)Reclining Seats (2500/3500 Models)Adjustable Head RestraintsManual Lumbar Support - If EquippedPower Seats - If EquippedRear Seat FeaturesHeated Seats - If EquippedTO OPEN AND CLOSE
THE HOOD LIGHTS Interior LightsBattery SaverHeadlight DelayHeadlights, Parking Lights and Panel LightsDaytime Running Lights (Canada Only and Fleet Vehicles)Lights-on ReminderFog Lights - If EquippedCargo Light - If EquippedMultifunction LeverWINDSHIELD
WIPERS AND WASHERS Intermittent Wiper SystemWindshield WashersTILT STEERING COLUMN DRIVER ADJUSTABLE PEDALS - IF EQUIPPED AdjustmentELECTRONIC SPEED CONTROL - IF EQUIPPED To ActivateTo Set a Desired SpeedTo DeactivateTo Resume
SpeedTo Vary the Speed SettingTo Accelerate for PassingOVERHEAD CONSOLE - IF EQUIPPED Courtesy/Reading LightsOVERHEAD CONSOLE WITH COMPASS/TEMPERATURE MINI-TRIP COMPUTER - IF EQUIPPED US/M ButtonReset ButtonGlobal ResetStep
ButtonAverage Fuel Economy (AVG ECO)Distance To Empty (DTE)Trip Odometer (ODO)Elapsed Time (ET)C/T ButtonAutomatic Compass CalibrationManual Compass CalibrationRecalibrating The CompassOutside TemperatureGARAGE DOOR OPENER - IF EQUIPPED
Programming HomeLinkGate Operator/Canadian ProgrammingUsing HomeLinkReprogramming A Single HomeLink ButtonSecurityTroubleshooting TipsGeneral InformationPOWER SUNROOF - IF EQUIPPED Open Sunroof - Express ModeClosing Sunroof - ExpressPinch
Protect FeaturePinch Protect OverrideVenting Sunroof - ExpressSunshade OperationWind BuffetingSunroof MaintenanceSunroof Fully ClosedELECTRICAL POWER OUTLETS CIGAR LIGHTER AND ASH RECEIVER CUPHOLDERS Front Instrument Panel Cupholders
(40-20-40 Seats) - Automatic TransmissionFront Instrument Panel Cupholders (Bucket Seats)Rear Cupholder (Quad Cab) - If EquippedSTORAGE Center Storage Compartment (40-20-40 Seat) - If EquippedCenter Storage Compartment (Bucket Seats) - If EquippedStorage
and Seats (Quad Cab Models)Plastic Grocery Bag Retainers - If EquippedREAR WINDOW FEATURES Rear Window Defroster and Heated Outside Mirrors - If EquippedPower Sliding Rear Window - If EquippedSliding Rear Window - If EquippedFOLD FLAT LOAD FLOOR
- IF EQUIPPED PICKUP BOX SLIDE-IN CAMPERS Camper ApplicationsEASY-OFF TAILGATE UNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANEL FEATURES RAM TRUCK POWER WAGON INSTRUMENT CLUSTER - BASE INSTRUMENT
CLUSTER - PREMIUM INSTRUMENT CLUSTER DESCRIPTION ELECTRONIC DIGITAL CLOCK Clock Setting ProcedureSALES CODE RAQ - AM/FM/CD (6-DISC) RADIO WITH OPTIONAL uconnect studios (SATELLITE RADIO), uconnect phone, AND VIDEO
ENTERTAINMENT SYSTEMS (VES) CAPABILITIES Operating Instructions - Radio ModeOperation Instructions - (CD Mode for CD Audio Play)LOAD/EJECT Button (CD Mode for CD Audio Play)Notes On Playing MP3 FilesOperation Instructions - (CD Mode for MP3 Audio
Play)LOAD/EJECT Button (CD Mode for MP3 Play)SALES CODE REF - AM/FM/CD (SINGLE-DISC) RADIO WITH OPTIONAL uconnect studios (SATELLITE RADIO) AND uconnect phone CAPABILITY Operating Instructions - Radio ModeOperating Instructions - CD Mode
Operating Instructions - Auxiliary ModeOperating Instructions - uconnect phone - If EquippedOperating Instructions - uconnect studios (Satellite Radio) - If EquippedSALES CODE REC - AM/FM/CD (6-DISC) RADIO WITH uconnect gps (NAVIGATION) Operating Instructions
- uconnect studios (Satellite Radio) - If EquippedREC Setting the Clockuconnect studios (SATELLITE RADIO) - IF EQUIPPED System ActivationElectronic Serial Number/Sirius Identification Number (ESN/SID)Selecting uconnect studios (Satellite) Mode in REF, RAQ, And
RAK RadiosSelecting A ChannelStoring And Selecting Preset ChannelsUsing The PTY (Program Type) Button - If EquippedPTY Button SCANPTY Button SEEKSatellite AntennaReception QualityVIDEO ENTERTAINMENT SYSTEM (VES) - IF EQUIPPED REMOTE SOUND
SYSTEM CONTROLS - IF EQUIPPED Radio OperationCD PlayerCD/DVD MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE CONTROLS Heater Only - If Equipped Air Conditioning and Heating - If Equipped Air Conditioning with Dual Zone
Temperature Control - If EquippedOperating TipsOperating Tips Chart STARTING AND OPERATING STARTING PROCEDURES Normal StartingAutomatic TransmissionIf Engine Fails To StartAfter StartingENGINE BLOCK HEATER - IF EQUIPPED AUTOMATIC
TRANSMISSION Automatic Transmission with OverdriveFOUR-WHEEL DRIVE OPERATION - IF EQUIPPED Manually Shifted Transfer Case Operating Information/PrecautionsShifting Procedure - Manually Shifted Transfer Case Transfer Case Position Indicator Light
Electronically Shifted Transfer Case Operating Information/Precautions (Five Position Switch) - If EquippedShifting Procedure - Electronically Shifted Transfer CaseElectronically Shifted Transfer Case Operating Information/Precautions (Four Position Switch) - If Equipped
Shifting Procedure - Electronically Shifted Transfer CaseAXLE LOCKER SYSTEM - POWER WAGON ONLY STABILIZER/SWAY BAR SYSTEM - POWER WAGON ONLY SAFE OFF-ROAD DRIVING - POWER WAGON ONLY Off-Road Driving Tips and Vehicle
CharacteristicsDriving In Snow, Mud And SandCrossing Obstacles (Rocks And Other High Points)Hill ClimbingDriving Through WaterAiring Down For Off-Road DrivingVehicle RecoveryAfter Driving Off-RoadLIMITED-SLIP DIFFERENTIAL - IF EQUIPPED DRIVING ON
SLIPPERY SURFACES DRIVING THROUGH WATER Flowing/Rising WaterShallow Standing WaterDRIVING OFF-ROAD - RAM TRUCK ONLY WINCH USAGE - IF EQUIPPED (POWER WAGON ONLY) Things To Know Before Using Your WinchUnderstanding The Features
Of Your Winch Winch AccessoriesOperating Your WinchRigging TechniquesPOWER STEERING Power Steering Fluid CheckPARKING BRAKE BRAKE SYSTEM 3500 Dual Rear Wheel Models OnlyFour-Wheel Anti-Lock Brake SystemELECTRONIC BRAKE CONTROL
SYSTEM - IF EQUIPPED Anti-Lock Brake System (ABS)Traction Control System (TCS)Brake Assist System (BAS)Hill Start Assist (HSA)Electronic Roll Mitigation (ERM)Electronic Stability Program (ESP)TSC (Trailer Sway Control)TIRE SAFETY INFORMATION Tire Markings
Tire Identification Number (TIN)Tire Loading and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresTire Pressures for High Speed OperationRadial Ply TiresTire SpinningTread Wear IndicatorsLife of TireReplacement TiresSUPPLEMENTAL
TIRE PRESSURE
INFORMATION - IF EQUIPPED TIRE CHAINS SNOW TIRES TIRE ROTATION RECOMMENDATIONS Dual Rear Wheels TIRE PRESSURE MONITOR SYSTEM (TPMS) - IF EQUIPPED Tire Pressure Monitor System (TPMS) Tire Light Load Inflation Switch Description
- If EquippedTire Pressure Monitor System ComponentsGeneral InformationFUEL REQUIREMENTS Reformulated GasolineGasoline/Oxygenate BlendsE-85 Usage In Non-Flex Fuel VehiclesMMT In GasolineMaterials Added To FuelFuel System CautionsCarbon Monoxide
WarningsADDING FUEL Loose Fuel Filler Cap (Gas Cap) MessageVEHICLE LOADING Certification LabelTRAILER TOWING Common Towing DefinitionsTrailer Hitch ClassificationTrailer Towing Weights (Maximum Trailer Weight Ratings)Trailer and Tongue WeightTowing
RequirementsTowing TipsSNOWPLOW RECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Recreational Towing - Two-Wheel Drive ModelsRecreational Towing - Four-Wheel Drive ModelsEQUIPMENT IDENTIFICATION PLATE WHAT TO DO IN EMERGENCIES
HAZARD WARNING FLASHER JACKING INSTRUCTIONS Jack LocationRemoving The Spare TireTire Changing ProcedurePreparationsInstructionsHub Caps/Wheel CoversHOISTING JUMP-STARTING PROCEDURES FREEING A STUCK VEHICLE EMERGENCY TOW
HOOKS - IF EQUIPPED TOWING A DISABLED VEHICLE 4-Wheel Drive Vehicles2-Wheel Drive VehiclesMAINTAINING YOUR VEHICLE ENGINE COMPARTMENT- 5.7L ONBOARD DIAGNOSTIC SYSTEM (OBD II) Loose Fuel Filler Cap MessageEMISSIONS
INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS DEALER SERVICE MAINTENANCE PROCEDURES Engine OilEngine Oil FilterEngine Air Cleaner FilterMaintenance-Free BatteryAir Conditioner MaintenanceFront Prop Shaft Lubrication -
2500/3500 (4X4) ModelsBody LubricationWindshield Wiper BladesAdding Washer FluidExhaust SystemCooling SystemBrake SystemRear Axle And 4x4 Front Driving Axle Fluid LevelTransfer CaseAutomatic TransmissionAppearance Care and Protection from Corrosion
FUSES Integrated Power ModuleVEHICLE STORAGE REPLACEMENT LIGHT BULBS BULB REPLACEMENT Headlight (Halogen)/Front Park and Turn LightsFog LightsTail, Stop, Turn and Backup LightsCenter High-Mounted Stoplight (CHMSL) With Cargo LightCab Top
Clearance Lights - If EquippedTailgate ID Lights (Dual Rear Wheels) - If EquippedRear Light Bar ID Marker (Dual Rear Wheel) - If EquippedSide Marker Lights (Dual Rear Wheels) FLUIDS AND CAPACITIES FLUIDS, LUBRICANTS AND GENUINE PARTS EngineChassis
MAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM MAINTENANCE MAINTENANCE SCHEDULE Required Maintenance IntervalsIF YOU NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For
The AppointmentPrepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE Chrysler LLC Customer CenterChrysler Canada Inc. Customer CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service Contract
WARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn CanadaPUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY GRADES
TreadwearTraction GradesTemperature GradesINDEX