2009 DODGE RAM 2500 DIESEL gas type

CAUTION!
Never use a floor jack directly under the differential
housing of a loaded truck or damage to your vehicle
may result.JUMP-STARTING PROCEDURESDo not attempt to push or tow your vehicle to get it
started. Vehicles equipped with an automatic transmis-
sion cannot be started this way. Also, there is a greater
risk of an accident when a vehicle is being pushed or
towed. If the vehicle has a discharged battery, booster
cables may be used to obtain a start from a booster
battery or the battery in another vehicle. This type of start
can be dangerous if done improperly, so follow this
procedure carefully.
WARNING!
•
Battery fluid is a corrosive acid solution; do not
allow battery fluid to contact eyes, skin or cloth-
ing. Don’t lean over battery when attaching
clamps or allow the clamps to touch each other. If
acid splashes in eyes or on skin, flush contami-
nated area immediately with large quantities of
water.
•
A battery generates hydrogen gas which is flam-
mable and explosive. Keep flame or spark away
from the vent holes.
•
Do not use a booster battery or any other booster
source that has a greater than 12-Volt system, i.e.,
do not use a 24-Volt power source.
1. Remove all metal jewelry such as watch bands or
bracelets which might make an unintended electrical
contact.
WHAT TO DO IN EMERGENCIES 419
6

•
Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Brake System
Master Cylinder — Brake Fluid Level CheckThe fluid level of the master cylinder should be checked
when performing under the hood service, or immedi-
ately if the brake system warning lamp indicates system
failure.
The brake master cylinder has a translucent plastic
reservoir. On the outboard side of the reservoir, there is a
“FULL” mark and an “ADD” mark. The fluid level must
be kept within these two marks. Do not add fluid above
the “FULL” mark, because leakage may occur at the cap.With disc brakes the fluid level can be expected to fall as
the brake linings wear. However, an unexpected drop in
fluid level may be caused by a leak and a system check
should be conducted.
Refer to “Fluids, Lubricants, and Genuine Parts” in this
section for the correct fluid type.
WARNING!
•
Use of a brake fluid that may have a lower initial
boiling point, or is unidentified as to specification,
may result in sudden brake failure during hard
prolonged braking. You could have an accident.
•
Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts and the
brake fluid catching fire.
(Continued)
MAINTAINING YOUR VEHICLE 447
7

INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VAN CONVERSIONS/CAMPERS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE
A WORD ABOUT YOUR KEYS Ignition Key RemovalLocking Doors With A KeySTEERING WHEEL LOCK - IF EQUIPPED To Manually Lock the Steering WheelTo Release the Steering Wheel LockAutomatic Transmission Ignition Interlock SystemSENTRY KEY Replacement
KeysCustomer Key ProgrammingGeneral InformationVEHICLE SECURITY ALARM - IF EQUIPPED Rearming of the SystemTo Set the AlarmTo Disarm the SystemILLUMINATED ENTRY SYSTEM - IF EQUIPPED REMOTE KEYLESS ENTRY (RKE) - IF EQUIPPED To
Unlock the DoorsTo Lock the DoorsUsing the Panic AlarmProgramming Additional RKE TransmittersGeneral InformationRKE Transmitter Battery ServiceREMOTE STARTING SYSTEM - IF EQUIPPED How to Use Remote StartDOOR LOCKS Manual Door LocksPower
Door Locks - If EquippedChild Protection Door LockWINDOWS Power Windows-If Equipped Wind BuffetingOCCUPANT RESTRAINTS Lap/Shoulder BeltsAdjustable Upper Shoulder Belt AnchorageAutomatic Locking Retractors (ALR) Mode - If EquippedCenter Lap Belts
Seat Belt Pretensioners - If EquippedEnhanced Seat Belt Use Reminder System (BeltAlert) Seat Belts and Pregnant WomenSeat Belt ExtenderDriver And Right Front Passenger Supplemental Restraint System (SRS) - Airbags Event Data Recorder (EDR)Child Restraints
ENGINE BREAK-IN RECOMMENDATIONS SAFETY TIPS Transporting PassengersExhaust GasSafety Checks You Should Make Inside the VehiclePeriodic Safety Checks You Should Make Outside the VehicleUNDERSTANDING THE FEATURES OF YOUR VEHICLE
MIRRORS Inside Day/Night MirrorAutomatic Dimming Mirror - If EquippedOutside MirrorsOutside Mirrors Folding FeaturePower Mirrors - If EquippedHeated Mirrors - If EquippedTrailer Towing Mirrors - If Equippeduconnect phone - IF EQUIPPED OperationPhone Call
Featuresuconnect phone FeaturesAdvanced Phone ConnectivityThings You Should Know About Your uconnect phoneGeneral InformationVOICE RECOGNITION (VR) SYSTEM - IF EQUIPPED Voice Recognition (VR) System OperationCommandsVoice TrainingSEATS
Manual Seat Adjuster - If EquippedReclining Seats (Quad Cab Models)Reclining Seats (2500/3500 Models)Adjustable Head RestraintsManual Lumbar Support - If EquippedPower Seats - If EquippedRear Seat FeaturesHeated Seats - If EquippedTO OPEN AND CLOSE
THE HOOD LIGHTS Interior LightsBattery SaverHeadlight DelayHeadlights, Parking Lights and Panel LightsDaytime Running Lights (Canada Only and Fleet Vehicles)Lights-on ReminderFog Lights - If EquippedCargo Light - If EquippedMultifunction LeverWINDSHIELD
WIPERS AND WASHERS Intermittent Wiper SystemWindshield WashersTILT STEERING COLUMN DRIVER ADJUSTABLE PEDALS - IF EQUIPPED AdjustmentELECTRONIC SPEED CONTROL - IF EQUIPPED To ActivateTo Set a Desired SpeedTo DeactivateTo Resume
SpeedTo Vary the Speed SettingTo Accelerate for PassingOVERHEAD CONSOLE - IF EQUIPPED Courtesy/Reading LightsOVERHEAD CONSOLE WITH COMPASS/TEMPERATURE MINI-TRIP COMPUTER - IF EQUIPPED US/M ButtonReset ButtonGlobal ResetStep
ButtonAverage Fuel Economy (AVG ECO)Distance To Empty (DTE)Trip Odometer (ODO)Elapsed Time (ET)C/T ButtonAutomatic Compass CalibrationManual Compass CalibrationRecalibrating The CompassOutside TemperatureGARAGE DOOR OPENER - IF EQUIPPED
Programming HomeLinkGate Operator/Canadian ProgrammingUsing HomeLinkReprogramming A Single HomeLink ButtonSecurityTroubleshooting TipsGeneral InformationPOWER SUNROOF - IF EQUIPPED Open Sunroof - Express ModeClosing Sunroof - ExpressPinch
Protect FeaturePinch Protect OverrideVenting Sunroof - ExpressSunshade OperationWind BuffetingSunroof MaintenanceSunroof Fully ClosedELECTRICAL POWER OUTLETS CIGAR LIGHTER AND ASH RECEIVER CUPHOLDERS Front Instrument Panel Cupholders
(40-20-40 Seats) - Automatic TransmissionFront Instrument Panel Cupholders (Bucket Seats)Rear Cupholder (Quad Cab) - If EquippedSTORAGE Center Storage Compartment (40-20-40 Seat) - If EquippedCenter Storage Compartment (Bucket Seats) - If EquippedStorage
and Seats (Quad Cab Models)Plastic Grocery Bag Retainers - If EquippedREAR WINDOW FEATURES Rear Window Defroster and Heated Outside Mirrors - If EquippedPower Sliding Rear Window - If EquippedSliding Rear Window - If EquippedFOLD FLAT LOAD FLOOR
- IF EQUIPPED PICKUP BOX SLIDE-IN CAMPERS Camper ApplicationsEASY-OFF TAILGATE UNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANEL FEATURES RAM TRUCK POWER WAGON INSTRUMENT CLUSTER - BASE INSTRUMENT
CLUSTER - PREMIUM INSTRUMENT CLUSTER DESCRIPTION ELECTRONIC DIGITAL CLOCK Clock Setting ProcedureSALES CODE RAQ - AM/FM/CD (6-DISC) RADIO WITH OPTIONAL uconnect studios (SATELLITE RADIO), uconnect phone, AND VIDEO
ENTERTAINMENT SYSTEMS (VES) CAPABILITIES Operating Instructions - Radio ModeOperation Instructions - (CD Mode for CD Audio Play)LOAD/EJECT Button (CD Mode for CD Audio Play)Notes On Playing MP3 FilesOperation Instructions - (CD Mode for MP3 Audio
Play)LOAD/EJECT Button (CD Mode for MP3 Play)SALES CODE REF - AM/FM/CD (SINGLE-DISC) RADIO WITH OPTIONAL uconnect studios (SATELLITE RADIO) AND uconnect phone CAPABILITY Operating Instructions - Radio ModeOperating Instructions - CD Mode
Operating Instructions - Auxiliary ModeOperating Instructions - uconnect phone - If EquippedOperating Instructions - uconnect studios (Satellite Radio) - If EquippedSALES CODE REC - AM/FM/CD (6-DISC) RADIO WITH uconnect gps (NAVIGATION) Operating Instructions
- uconnect studios (Satellite Radio) - If EquippedREC Setting the Clockuconnect studios (SATELLITE RADIO) - IF EQUIPPED System ActivationElectronic Serial Number/Sirius Identification Number (ESN/SID)Selecting uconnect studios (Satellite) Mode in REF, RAQ, And
RAK RadiosSelecting A ChannelStoring And Selecting Preset ChannelsUsing The PTY (Program Type) Button - If EquippedPTY Button SCANPTY Button SEEKSatellite AntennaReception QualityVIDEO ENTERTAINMENT SYSTEM (VES) - IF EQUIPPED REMOTE SOUND
SYSTEM CONTROLS - IF EQUIPPED Radio OperationCD PlayerCD/DVD MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE CONTROLS Heater Only - If Equipped Air Conditioning and Heating - If Equipped Air Conditioning with Dual Zone
Temperature Control - If EquippedOperating TipsOperating Tips Chart STARTING AND OPERATING STARTING PROCEDURES Normal StartingAutomatic TransmissionIf Engine Fails To StartAfter StartingENGINE BLOCK HEATER - IF EQUIPPED AUTOMATIC
TRANSMISSION Automatic Transmission with OverdriveFOUR-WHEEL DRIVE OPERATION - IF EQUIPPED Manually Shifted Transfer Case Operating Information/PrecautionsShifting Procedure - Manually Shifted Transfer Case Transfer Case Position Indicator Light
Electronically Shifted Transfer Case Operating Information/Precautions (Five Position Switch) - If EquippedShifting Procedure - Electronically Shifted Transfer CaseElectronically Shifted Transfer Case Operating Information/Precautions (Four Position Switch) - If Equipped
Shifting Procedure - Electronically Shifted Transfer CaseAXLE LOCKER SYSTEM - POWER WAGON ONLY STABILIZER/SWAY BAR SYSTEM - POWER WAGON ONLY SAFE OFF-ROAD DRIVING - POWER WAGON ONLY Off-Road Driving Tips and Vehicle
CharacteristicsDriving In Snow, Mud And SandCrossing Obstacles (Rocks And Other High Points)Hill ClimbingDriving Through WaterAiring Down For Off-Road DrivingVehicle RecoveryAfter Driving Off-RoadLIMITED-SLIP DIFFERENTIAL - IF EQUIPPED DRIVING ON
SLIPPERY SURFACES DRIVING THROUGH WATER Flowing/Rising WaterShallow Standing WaterDRIVING OFF-ROAD - RAM TRUCK ONLY WINCH USAGE - IF EQUIPPED (POWER WAGON ONLY) Things To Know Before Using Your WinchUnderstanding The Features
Of Your Winch Winch AccessoriesOperating Your WinchRigging TechniquesPOWER STEERING Power Steering Fluid CheckPARKING BRAKE BRAKE SYSTEM 3500 Dual Rear Wheel Models OnlyFour-Wheel Anti-Lock Brake SystemELECTRONIC BRAKE CONTROL
SYSTEM - IF EQUIPPED Anti-Lock Brake System (ABS)Traction Control System (TCS)Brake Assist System (BAS)Hill Start Assist (HSA)Electronic Roll Mitigation (ERM)Electronic Stability Program (ESP)TSC (Trailer Sway Control)TIRE SAFETY INFORMATION Tire Markings
Tire Identification Number (TIN)Tire Loading and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresTire Pressures for High Speed OperationRadial Ply TiresTire SpinningTread Wear IndicatorsLife of TireReplacement TiresSUPPLEMENTAL
TIRE PRESSURE
INFORMATION - IF EQUIPPED TIRE CHAINS SNOW TIRES TIRE ROTATION RECOMMENDATIONS Dual Rear Wheels TIRE PRESSURE MONITOR SYSTEM (TPMS) - IF EQUIPPED Tire Pressure Monitor System (TPMS) Tire Light Load Inflation Switch Description
- If EquippedTire Pressure Monitor System ComponentsGeneral InformationFUEL REQUIREMENTS Reformulated GasolineGasoline/Oxygenate BlendsE-85 Usage In Non-Flex Fuel VehiclesMMT In GasolineMaterials Added To FuelFuel System CautionsCarbon Monoxide
WarningsADDING FUEL Loose Fuel Filler Cap (Gas Cap) MessageVEHICLE LOADING Certification LabelTRAILER TOWING Common Towing DefinitionsTrailer Hitch ClassificationTrailer Towing Weights (Maximum Trailer Weight Ratings)Trailer and Tongue WeightTowing
RequirementsTowing TipsSNOWPLOW RECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Recreational Towing - Two-Wheel Drive ModelsRecreational Towing - Four-Wheel Drive ModelsEQUIPMENT IDENTIFICATION PLATE WHAT TO DO IN EMERGENCIES
HAZARD WARNING FLASHER JACKING INSTRUCTIONS Jack LocationRemoving The Spare TireTire Changing ProcedurePreparationsInstructionsHub Caps/Wheel CoversHOISTING JUMP-STARTING PROCEDURES FREEING A STUCK VEHICLE EMERGENCY TOW
HOOKS - IF EQUIPPED TOWING A DISABLED VEHICLE 4-Wheel Drive Vehicles2-Wheel Drive VehiclesMAINTAINING YOUR VEHICLE ENGINE COMPARTMENT- 5.7L ONBOARD DIAGNOSTIC SYSTEM (OBD II) Loose Fuel Filler Cap MessageEMISSIONS
INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS DEALER SERVICE MAINTENANCE PROCEDURES Engine OilEngine Oil FilterEngine Air Cleaner FilterMaintenance-Free BatteryAir Conditioner MaintenanceFront Prop Shaft Lubrication -
2500/3500 (4X4) ModelsBody LubricationWindshield Wiper BladesAdding Washer FluidExhaust SystemCooling SystemBrake SystemRear Axle And 4x4 Front Driving Axle Fluid LevelTransfer CaseAutomatic TransmissionAppearance Care and Protection from Corrosion
FUSES Integrated Power ModuleVEHICLE STORAGE REPLACEMENT LIGHT BULBS BULB REPLACEMENT Headlight (Halogen)/Front Park and Turn LightsFog LightsTail, Stop, Turn and Backup LightsCenter High-Mounted Stoplight (CHMSL) With Cargo LightCab Top
Clearance Lights - If EquippedTailgate ID Lights (Dual Rear Wheels) - If EquippedRear Light Bar ID Marker (Dual Rear Wheel) - If EquippedSide Marker Lights (Dual Rear Wheels) FLUIDS AND CAPACITIES FLUIDS, LUBRICANTS AND GENUINE PARTS EngineChassis
MAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM MAINTENANCE MAINTENANCE SCHEDULE Required Maintenance IntervalsIF YOU NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For
The AppointmentPrepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE Chrysler LLC Customer CenterChrysler Canada Inc. Customer CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service Contract
WARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn CanadaPUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY GRADES
TreadwearTraction GradesTemperature GradesINDEX