2009 DODGE CHALLENGER SRT power steering

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealers or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, and refrigerants.
A/C Air Filter — If Equipped
The filter is located in the fresh air inlet under the hood,
behind a removable panel in the cowl on the passenger
side of the vehicle, next to the windshield wipers. When
installing a new filter, ensure its proper orientation. To
replace the filter, remove the access door in the cowl
screen by pressing the retaining clips. Slide the lid on the
filter adapter forward and down and remove the usedfilter. Install the new filter with arrows pointing in the
direction of airflow, which is toward the rear of the
vehicle (text and arrows on the filter indicate this).
Refer to the Maintenance Schedule in Section 8 for the
recommended air conditioning filter replacement inter-
vals.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through an autho-
rized dealer. No chemical flushes should be used in any
power steering system; only the approved lubricant may
be used.
310 MAINTAINING YOUR VEHICLE

WARNING!
Fluid level should be checked on a level surface and
with the engine OFF to prevent injury from moving
parts and to ensure accurate fluid level reading. Do
not overfill. Use only manufacturer’s recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to “Fluids, Lubricants, and Genuine
Parts” in this section for the correct fluid type.
Front And Rear Suspension Ball Joints
The suspension ball joints should be inspected for exter-
nal leakage or damage when other maintenance is per-
formed.
Steering Linkage
The tie rod end ball joints should be inspected for
external leakage or damage when other maintenance is
performed.
Body Lubrication
Locks and all body pivot points, including seat tracks,
door hinges, trunk hinges, and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating,
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to ensure proper function. When performing other
underhood services, the hood latch, release mechanism,
and safety catch should be cleaned and lubricated.
MAINTAINING YOUR VEHICLE 311
7

Care should be taken with installing quick connect
fittings to ensure they are properly installed and fully
connected. See your authorized dealer for service.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the Mainte-
nance Schedule in Section 8.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake and Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Ensure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:
•Often, fluid such as oil, power steering fluid, and
brake fluid are used during assembly plant operations
to facilitate the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not
320 MAINTAINING YOUR VEHICLE

Cavity Cartridge
FuseMini-
FuseDescription
28 — 10 Amp
RedIgnition Run
29 — 5 Amp
OrangeCluster/Electronic Stabil-
ity Program (ESP)/
Powertrain Control Mod-
ule (PCM)/STOP LIGHT
Switch
30 — 10 Amp
RedDoor Modules/Power
Mirrors/Steering Control
Module (SCM)
31 — — —
32 — — —
33 — — —
34 — — —
35 — 5 Amp
OrangeAntenna Module - if
equipped/Power MirrorsCavity Cartridge
FuseMini-
FuseDescription
36 — 20 Amp
YellowHands-Free Phone - if
equipped//Radio
37 — 15 Amp
BlueTransmission
38 — 10 Amp
RedCargo Light/Vehicle In-
formation Module - if
equipped
39 — 10 Amp
RedHeated Mirrors - if
equipped
40 — 5 Amp
OrangeAuto Inside Rearview
Mirror/Heated Seats - if
equipped/Switch Bank
41 — 10 Amp
RedAC Heater Control/
Headlights/Tire Pressure
Monitoring - if equipped
42 30 Amp
Pink— Front Blower Motor
334 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants, and Genuine Parts
Automatic Transmission MOPARATF+4 Automatic Transmission Fluid
Brake Master Cylinder MOPARDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Power Steering Reservoir MOPARPower Steering Fluid + 4, MOPARATF+4 Automatic Transmis-
sion Fluid
Rear Axle API GL-5 SAE 75W140 Synthetic Gear Lubricant or equivalent
MAINTAINING YOUR VEHICLE 343
7

FlashersHazard Warning ....................... 280
Turn Signal ...................... 70,119,152
Flash-To-Pass ........................... 120
Flooded Engine Starting ................... 218
Fluid, Brake ........................... 343
Fluid Capacities ......................... 341
Fluid Leaks ............................. 70
Fluid Level Checks Automatic Transmission ................. 322
Brake ............................... 321
Cooling System ....................... 314
Engine Oil ........................... 301
Power Steering ........................ 310
Fluids ................................ 342
Fluids, Lubricants and Genuine Parts .......... 342
Fog Lights .......................... 1 18,154
Folding Rear Seat ........................ 113
Freeing A Stuck Vehicle ................... 289 Front Suspension Ball Joints
................ 311
Front Wheel Bearings ..................... 324
Fuel ................................. 270
Adding ............................. 274
Additives ............................ 272
Clean Air ............................ 270
Ethanol ............................. 271
Filler Cap (Gas Cap) .................... 274
Filter ............................... 304
Gasoline ............................ 270
Gauge .............................. 150
Hoses .............................. 319
Materials Added ....................... 272
Methanol ............................ 271
Octane Rating ...................... 270,342
Requirements ......................... 270
Specifications ......................... 342
Tank Capacity ........................ 341
Fuel System Caution ..................... 274
368 INDEX

Mirrors.............................. 76
Outlet (Auxiliary Electrical Outlet) .......... 140
Seats ............................... 109
Steering ............................. 237
Steering, Checking ..................... 310
Sunroof ............................. 136
Windows ............................. 33
Power Steering Fluid .................. 310,343
Pregnant Women and Seat Belts .............. 45
Pretensioners Seat Belts ............................. 43
Programmable Electronic Features ............ 172
Programming Transmitters (Remote Keyless
Entry) ................................. 21
Radial Ply Tires ......................... 257
Radiator Cap (Coolant Pressure Cap) .......... 316
Radio Broadcast Signals ................... 175
Radio, Navigation ....................... 191 Radio Operation
...................... 192,202
Radio Remote Controls .................... 201
Radio, Satellite .................... 191,192,195
Radio (Sound Systems) .................... 191
Rear Cup Holder ........................ 142
Rear Seat, Folding ....................... 113
Rear Wheel Bearings ..................... 324
Rear Window Defroster ................... 144
Rear Window Features .................... 144
Reception, Radio ........................ 175
Recorder, Event Data ...................... 56
Recreational Towing ...................... 278
Reformulated Gasoline .................... 270
Refrigerant ............................ 310
Release, Hood .......................... 114
Reminder, Lights On ..................... 118
Reminder, Seat Belt ....................... 43
Remote Control Starting System ........................ 27
INDEX 375
10

Spark Plugs......................... 304,342
Specifications Fuel (Gasoline) ........................ 342
Oil ................................ 342
Speed Control (Cruise Control) .............. 126
Speedometer ........................... 150
Starting ............................. 27,214
Automatic Transmission ................. 215
Cold Weather ......................... 217
Emergency (Jump Starting) ............... 286
Engine Fails to Start .................... 218
Remote .............................. 27
Starting and Operating .................... 214
Starting Procedures ...................... 214
Steering Column Controls ...................... 119
Column Lock ......................... 125
Linkage ............................. 311
Power ........................... 237,310Tilt Column
.......................... 125
Wheel, Tilt ........................... 125
Steering Wheel Mounted Sound System
Controls .............................. 201
Storage ............................... 335
Storage, Vehicle ...................... 207,335
Storing Your Vehicle ...................... 335
Stuck, Freeing .......................... 289
Sun Roof .............................. 136
Sunglasses Storage ....................... 130
Sunroof Maintenance ..................... 139
Supplemental Restraint System - Airbag ........ 46
System, Navigation ...................... 191
System, Remote Starting .................... 27
Tachometer ............................ 150
Telescoping Steering Column ............... 125
Temperature Gauge, Engine Coolant .......151,281
Tether Anchor, Child Restraint ............... 61
378 INDEX