2009 CHRYSLER PT CRUISER check engine

CAUTION!
Do not allow petroleum-based fluid to contaminate
the brake fluid; all brake seal components could be
damaged causing partial or complete brake failure.
Use only brake fluid that has been in a tightly closed
container to avoid contamination from foreign mat-
ter.
Automatic Transaxle
The automatic transaxle and differential assembly are
contained within a single housing.
The fluid level in the automatic transaxle should be
checked whenever the vehicle is serviced. Operation with
an improper fluid level will greatly reduce the life of the
transaxle and the fluid.
Fluid Level Check
Use the following procedure to check the automatic
transaxle fluid level properly:
1. Park the vehicle on level ground.
2. Run the engine at curb idle speed for a minimum of
60 seconds.
3. Apply the parking brake fully.
4. Place the shift lever momentarily in each gear posi-
tion, ending with the shift lever in PARK.
5. Wipe the area around the dipstick clean to eliminate
the possibility of dirt entering the transaxle.
7
MAINTAINING YOUR VEHICLE 331

At Each Stop for Fuel
•
Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transaxle, and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transaxle fluid level.
•Check the manual transaxle fluid level and fill plug
condition.
•Check the coolant level, hoses, and clamps.
8
MA I
N T
E
N A
N CE
S
C
H E
D
U L
E
S356 MAINTENANCE SCHEDULES

ABS (Anti-Lock Brake System).............. 244
Adding Engine Coolant (Antifreeze) .......... 325
Adding Fuel ........................... 274
Additives, Fuel ......................... 272
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 316
Air Conditioner Maintenance ............... 318
Air Conditioning Controls ................. 213
Air Conditioning, Operating Tips ............ 219
Air Conditioning Refrigerant .............318,319
Air Conditioning System ................213,318
Air Pressure, Tires ....................... 257
Airbag ................................ 45
Airbag Deployment ....................... 56
Airbag Light ....................... 59,73,173
Airbag Maintenance ....................... 58
Airbag, Side ............................ 54
Alarm Light ........................... 172
Alarm, Panic ............................ 23
Alarm System (Security Alarm) ............... 18Alterations/Modifications, Vehicle
............. 7
Antenna, Satellite Radio ................... 211
Antifreeze (Engine Coolant) ........324,325,349,350
Capacities ........................... 349
Disposal ............................ 327
Anti-Lock Brake System (ABS) .............. 244
Anti-Lock Warning Light .................. 172
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Appearance Care ........................ 334
Assistance Towing ........................ 96
Auto Down Power Windows ................ 32
Automatic Door Locks ..................... 29
Automatic Transaxle ..............12,224,229,331
Adding Fluid ......................... 331
Filter ............................... 333
Fluid and Filter Changes ................. 333
Fluid Level Check ..................... 331
Interlock System ..................... 15,230
Reset Mode .......................... 231
390 INDEX

Special Additives...................... 333
Autostick ............................. 234
Back-Up Lights ......................... 348
Battery ............................... 317
Keyless Transmitter Replacement (RKE) ....... 26
Belts, Seat .............................. 72
Body Mechanism Lubrication ............... 319
B-Pillar Location ........................ 252
Brake, Parking .......................... 241
Brake System ........................ 243,329
Anti-Lock (ABS) ....................... 244
Fluid Check .......................... 329
Master Cylinder ....................... 329
Parking ............................. 241
Warning Light ........................ 169
Brakes ............................. 243,329
Brake/Transmission Interlock ............... 230
Break-In Recommendations, New Vehicle ........ 70Bulb Replacement
..................... 344,345
Bulbs, Light .......................... 73,344
Calibration, Compass .................. 176,185
Capacities, Antifreeze (Engine Coolant) ........ 349
Capacities, Fluid ........................ 349
Caps, Filler Fuel ............................... 274
Oil (Engine) .................... 307,308,315
Power Steering ........................ 241
Radiator (Coolant Pressure) ............... 326
Car Washes ............................ 335
Carbon Monoxide Warning ...............71,273
CD (Compact Disc) Player ...............187,201
Cellular Phone ........................ 82,213
Center High Mounted Stop Light ............ 348
Chains, Tire ............................ 263
Changing A Flat Tire ..................... 294
Chart, Tire Sizing ........................ 249
10
INDEX 391

Check Engine Light
(Malfunction Indicator Light).............168,309
Checking Your Vehicle For Safety ............. 71
Checks, Safety ........................... 71
Child Restraint .......................... 62
Child Restraint Tether Anchors ............... 66
Child Restraint with Automatic Belts ........... 65
Child Safety Locks ........................ 30
Child Seat .............................. 68
Clean Air Gasoline ....................... 270
Cleaning Wheels ............................. 337
Climate Control ......................... 213
Clock ........................... 187,189,203
Clutch ............................... 329
Clutch Fluid ........................... 329
Coin Holder ........................... 148
Compact Disc (CD) Maintenance ............. 212
Compact Spare Tire ...................... 259 Compass
..................... 173,174,176,185
Compass Calibration .................. 176,185
Compass Variance ....................... 175
Computer, Trip/Travel .................... 173
Console .............................. 148
Contract, Service ........................ 383
Cool Down, Turbo ....................... 226
Coolant (Antifreeze) ................... 349,350
Coolant Pressure Cap (Radiator Cap) .......... 326
Cooling System ......................... 323
Adding Coolant (Antifreeze) .............. 325
Coolant Level ...................... 323,327
Disposal of Used Coolant ................ 327
Drain, Flush, and Refill .................. 324
Inspection ........................... 327
Points to Remember .................... 328
Pressure Cap ......................... 326
Radiator Cap ......................... 326
Selection of Coolant (Antifreeze) ........... 324
392 INDEX

Emission Control System Maintenance......309,354
Engine ............................ 307,308
Break-In Recommendations ................ 70
Checking Oil Level ..................... 312
Coolant (Antifreeze) .................... 323
Cooling ............................. 323
Exhaust Gas Caution .................. 71,273
Fuel Requirements ..................... 270
Jump Starting ......................... 300
Oil ........................... 312,349,350
Oil Change Interval .................... 313
Oil Filler Cap ................... 307,308,315
Oil Filter ............................ 350
Oil Selection .......................... 314
Oil Synthetic ......................... 315
Overheating .......................... 292
Temperature Gauge .................... 164
Ethanol ............................... 270
Event Data Recorder ...................... 60 Exhaust Gas Caution
..............34,71,273,321
Exhaust System ....................... 71,321
Exterior Lights .......................... 73
Fabric Care ............................ 338
Filler Location Fuel .................... 164,274
Filters Air Cleaner .......................... 316
Automatic Transaxle .................... 333
Engine Oil ........................ 316,350
Flashers .............................. 292
Hazard Warning ....................... 292
Turn Signal ........................ 73,169
Flooded Engine Starting ................... 225
Fluid Capacities ......................... 349
Fluid Leaks ............................. 73
Fluid Level Checks Automatic Transaxle .................... 331
Brake .............................. 329
394 INDEX

Low Fuel............................ 172
Malfunction Indicator (Check Engine) ........ 168
Map Reading ......................... 125
Oil Pressure .......................... 173
Rear Servicing ........................ 347
Seat Belt Reminder ..................... 171
Security Alarm (Theft Alarm) ............19,172
Service ............................. 345
Service Engine Soon (Malfunction Indicator) . . . 168
Theft Alarm (Security Alarm) .............. 172
Tire Pressure Monitoring (TPMS) ........165,265
Traction Control ....................... 247
Turn Signal ...................... 73,128,346
Voltage ............................. 169
Warning (Instrument Cluster Description) ..... 164
Loading Vehicle ...................... 276,278
Capacities ........................... 278
Tires ............................... 252 Locks
Child Protection ........................ 30
Door ................................ 27
Power Door ........................... 28
Steering Wheel ......................... 14
Low Tire Pressure System .................. 265
Lubrication, Body ....................... 319
Lumbar Support ........................ 112
Maintenance Free Battery .................. 317
Maintenance, General ..................... 312
Maintenance Procedures ................... 312
Maintenance Schedule Schedule “A”-Non Turbo ................ 368
Schedule “A”-Turbo .................... 373
Schedule “B” ......................... 357
Schedule “B”-All Engines ................ 357
Maintenance Schedules .................... 354
Malfunction Indicator Light (Check Engine) . . 168,309
398 INDEX

Manual, Service......................... 385
Manual Transaxle .................. 224,226,334
Downshifting ......................... 229
Fluid Level Check ..................... 334
Frequency of Fluid Change ............... 334
Lubricant Selection ..................... 334
Map/Reading Lights ..................... 125
Master Cylinder (Brakes) .................. 329
Methanol ............................. 270
Mini-Trip Computer ...................... 174
Mirrors ................................ 79
Electric Remote ........................ 80
Outside .............................. 79
Rearview ............................. 79
Vanity ............................... 81
Modifications/Alterations, Vehicle ............. 7
Monitor, Tire Pressure System ............... 265
Mopar Parts ......................... 31 1,384New Vehicle Break-In Period
................ 70
Occupant Classification System (OCS) .......... 50
Occupant Restraints (Sedan) ................. 35
Octane Rating, Gasoline (Fuel) .............. 270
Odometer ............................. 167
Trip ............................. 167,169
Oil, Engine ......................... 312,349
Capacity ............................ 349
Change Interval ....................... 313
Checking ............................ 312
Disposal ............................ 315
Filter ............................... 316
Identification Logo ..................... 314
Materials Added to ..................... 315
Quality ............................. 314
Recommendation ................... 314,349
Synthetic ............................ 315
Viscosity ............................ 315
Oil Filter, Selection ....................... 316
10
INDEX 399