2009 Alfa Romeo Brera/Spider brake

221
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
Brake fluid is poisonous
and highly corrosive. In
the event of accidental contact,
wash the parts involved im-
mediately with neutral soap
and water, then rinse thor-
oughly. Call the doctor imme-
diately if the fluid is swal-
lowed.
WARNING
BRAKE FLUID fig. 11
Check that the fluid level in the reservoir
is at maximum. Top up with the brake
fluid specified in the table “Fluids and
lubricants” (see section “Technical Spec-
ifications”).
NOTEClean accurately the tank cap A
and the surrounding surface. When
opening the cap take the utmost care to
prevent impurities entering the tank.
When topping up, always use a funnel
with built-in filter with mesh equal to
or lower than 0.12 mm.
A0F0016mfig. 11
Make sure that the high-
ly corrosive brake fluid
does not drip onto the
paintwork. If it does, wash it off
immediately with water.
IMPORTANTFor this operation it is
however recommended to contact Alfa
Romeo Authorised Services.
From time to time, check the instrument
panel warning light
x: pressing on cap
A(with key fitted into the ignition de-
vice) the warning light shall turn on.
IMPORTANTBrake fluid absorbs
moisture. For this reason, if the car is
mainly used in areas with a high degree
of atmospheric humidity, the fluid should
be replaced at more frequent intervals
than specified in the Service Schedule.
209-234 Alfa BRERA gb 28-08-2008 11:44 Pagina 221

222
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
Symbolπon the con-
tainer indicates syn-
thetic brake fluid, distinguish-
ing it from the mineral kind.
Using mineral fluids irre-
versibly damages the special
braking system rubber seals.
WARNINGAIR FILTER/ POLLEN
FILTER
Air cleaner or pollen filter replacement
shall be carried out at Alfa Romeo Au-
thorized Services.
DIESEL FUEL FILTER
DRAINING THE CONDENSE
The presence of water in
the fuel circuit can se-
verely damage the in-
jection system and make the en-
gine misfire. If the warning light
cturns on (together with a
message on the display) contact
Alfa Romeo Authorized Services
as soon as possible to have the
bleeding operation carried out.
Should the warning light turn on
after refuelling, water has
probably been poured into the
tank: turn the engine off imme-
diately and contact Alfa Romeo
Authorized Services.
209-234 Alfa BRERA gb 28-08-2008 11:44 Pagina 222

228
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
WINDSCREEN/
REARSCREEN
WIPERS
BLADES
Periodically clean the rubber part using
special products TUTELA PROFES-
SIONAL SC 35is recommended.
If the rubber blades are bent or worn
they should be replaced. In any case
they should be changed once a year.
RUBBER HOSES
As far as the brake system and fuel rub-
ber hoses are concerned, carefully fol-
low the Service schedule in this section.
Indeed ozone, high temperatures and
prolonged lack of fluid in the system
may cause hardening and cracking of
the hoses, with possible leaks. Careful
control is therefore necessary.
Driving with worn
wiper blades is a seri-
ous hazard, because visibility
is reduced in bad weather.
WARNING
A few simple notions can reduce the pos-
sibility of damage to the blades:
❒if the temperature falls below zero,
make sure that ice has not frozen
the rubber against glass. If neces-
sary, thaw using an antifreeze prod-
uct;
❒remove any snow from the glass:
in addition to protecting the blades,
this prevents effort on the motor and
overheating;
❒do not operate the windscreen
wipers on dry glass.
209-234 Alfa BRERA gb 28-08-2008 11:44 Pagina 228

235
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
IDENTIFICATION DATA ........................................ 236
ENGINE CODES - BODYWORK VERSIONS ............... 238
ENGINE.......................................................... 239
FUEL FEED/IGNITION ........................................ 240
TRANSMISSION............................................... 240
BRAKES........................................................... 241
STEERING........................................................ 241
SUSPENSIONS.................................................. 241
WHEELS.......................................................... 242
DIMENSIONS.................................................... 247
PERFORMANCE................................................. 248
WEIGHTS......................................................... 249
CAPACITIES...................................................... 250
FLUIDS AND LUBRICANTS................................... 251
FUEL CONSUMPTION ........................................ 253
CO
2EMISSIONS.............................................. 254
RADIO FREQUENCY REMOTE CONTROL:
MINISTERIAL CERTIFICATIONS ............................. 255
235-258 Alfa BRERA gb 28-08-2008 11:47 Pagina 235

241
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
2.2 JTS 3.2 JTS - 2.4 JTDM
Service brakes:
– front Disc, self-ventilating Disc, self-ventilating
– rear Disc Disc, self-ventilating
Parking brake Controlled by hand lever, it works on rear brakes
WARNING Water, ice and antifreeze salt on roads may deposit on the brake discs thus reducing braking efficiency at first braking.
2.2 JTS - 3.2 JTS - 2.4 JTDM
Type Rack and pinion with hydraulic power steering
Turning radius
(between pavements) 10.7
BRAKES
STEERING
2.2 JTS - 3.2 JTS - 2.4 JTDM
Front High quadrilateral system
Rear Multi-link system
SUSPENSIONS
235-258 Alfa BRERA gb 28-08-2008 11:47 Pagina 241

244
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
On tyres 225/50 R17” only “spider” type chains can be used. Also for 3.2 JTS version, snow chains shall be fitted on the FRONT axle of the car.
Tyres 235/45 R18” cannot be fitted with snow chains due to interference with fender.
(*) Tyres that cannot be fitted with traditional snow chains. Only “spider” type chains can be used.
(**) Vehicles with “Red brake caliper” opt should not use 16” wheel rims.
WARNINGSnow tyres with speed index Hare recommended.
(
▼) Unchainable tyres. Size certified and admitted only for PIRELLI 235/40 ZR19 96Y. When using winter tyres, use 225/50 R17 98 tyres or
235/45 R18 98.
4,00B x17"
T125/80 R17
TYRES
Standardtyres
Optional
Space-saver
spare wheel
(for versions/
markets where
applicable)rim
tyre
rim
tyre
rim
tyre
rim
tyre2.2 JTS
7Jx16" alloy (**)
215/55 R16 93V
7,5Jx17" alloy
225/50 R17 98W
8Jx18" alloy 8Jx19" alloy
235/45 R18 98W 235/40 ZR19 96Y(O)3.2 JTS
7,5Jx17" (*) alloy
225/50 R17 98W
8Jx19" alloy
235/40 ZR19 96Y(O)
8Jx18" alloy
235/45 R18 98W
2.4 JTDM
7,5Jx17" (*) alloy225/50 R17 98W
8Jx19" alloy
235/40 ZR19 96Y(O)
8Jx18" alloy
235/45 R18 98W
235-258 Alfa BRERA gb 28-08-2008 11:47 Pagina 244

252
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND
CONTROLS
CORRECT USE
OF THE CAR
TUTELA CAR
MATRYX
Contractual Technical
Reference N° F108.F02
TUTELA
MULTIAXLE
Contractual Technical
Reference N° F426.E06
TUTELA GI/EContractual Technical
Reference N° F001.C94
TUTELA ALL STARContractual Technical
Reference N° F702.G07
TUTELA STAR 700Contractual Technical
Reference N° F701.C07
TUTELA TOP 4Contractual Technical
Reference N° F001.A93
PARAFLU UP (●)Contractual Technical
Reference N° F101.M01
TUTELADIESEL ARTContractual Technical
Reference N° F601.L06
TUTELA
PROFESSIONAL SC 35
Contractual Technical
Reference N° F201.D02
Mechanical gearbox and
differential
Rear differential and
transmission unit
(3.2 JTS version)
Power steering
CV joints
on wheel side
CV joints
on differential side
Hydraulic brake and
clutch controls
Cooling circuits
Proportion:
50% water and
50%PARAFLU UP
(❑)
To be mixed with fuel oil
(25 cc per 10 litres)
To be used diluted or
undiluted in windscreen/
rear window washer/
wiper systems Brake fluid
Windscreen/
headlight washer
fluid
Use Fluid and lubricant specifications Original fluids Applications
for correct car operation and lubricants
Protective agent for
radiators Lubricants and
greases
for transmission
(●)IMPORTANTDo not top up or mix with fluids having different specifications from those described here.(❑)For particularly hard climate conditions, we recommend use of a 60% PARAFLU UP and 40% demineralized water mixture.
Additive for
diesel fuel
Synthetic-based oil, grade SAE 75W-85
Passes API GL 4 specifications.
QualificationFIAT 9.55550-MZ1
Synthetic-based oil, grade SAE 75W-90
Passes API GL-5, ZF-TE ML 18 specifications.
QualificationFIAT 9.55550-DA3
Lubricant for automatic transmissions that passes
"ATF DEXRON III" specification.
QualificationFIAT 9.55550-AG2.
Grease containing Molybdenum bisulphide for high temperature
appliances. N.L.G.I. 1-2 consistency.
QualificationFIAT 9.55580.
Grease for homokinetic joints with low friction coefficient.
NLGI 0-1 consistency.
QualificationFIAT 9.55580.
Synthetic fluid for Brake and clutch controls FMVSS n° 116
DOT 4, ISO 4925, SAE J1704, CUNA NC 956-01
QualificationFIAT 9.55597.
Protective with antifreeze action, red colour based on inhibited
monoethylen glycol and organic formula, that passes
CUNA NC 956-16, ASTM D 3306 specifications
QualificationFIAT 9.555523.
Additive for diesel fuels with protective action for Diesel engines
Mixture of alcohol, water and surfactants CUNA NC 956-11
QualificationFIAT 9.55522.
235-258 Alfa BRERA gb 28-08-2008 11:47 Pagina 252

259
SAFETY
DEVICES
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CORRECT USE
OF THE CAR
DASHBOARD
AND
CONTROLS
INDEX
– replacing ........................... 224
– useful advice for
lengthening the life ............. 225
Bodywork (cleaning) ................ 230
Bonnet................................... 96
Boot ...................................... 90
– light replacement ................ 192
Brakes ................................... 241
Brake lights ............................ 188
Bulb (replacement) .................. 182
– general instructions ............. 182
– types of bulbs .................... 183
Capacities......................112-250
Car inactivity ........................... 150
Car maintenance................ 209
– periodical checks ................ 213
– service Schedule ................. 211
– scheduled service ................ 210
– use of the car under heavy
conditions .......................... 213
Carrying children safely ............. 121– child restraint systems ......... 124
– passenger’s seat compliance . 124
– presetting for mounting
the “Universal Isofix”
child restraint system .......... 126
Ceiling lights ........................... 75
Checking fluid levels ................. 214
Cigar lighter ............................ 82
Climate control system .............. 49
– automatic two-zone . ........... 54
– manual ............................. 51
CO
2emissions......................... 254
CODE card .............................. 11
Containing running costs ........... 145
Controls................................. 77
Correct use of the car........ 137
Courtesy mirror light
– bulb replacement ................ 191
Cruise Control .......................... 72
Dashboard............................. 8
Dashboard and controls.... 6 ABS system ............................ 99
Accessories purchased
by the owner ........................ 106
Additional heater ..................... 64
Air/pollen filter ........................ 222
Air vents ................................. 50
Alarm ..................................... 17
Alfa Romeo CODE system .......... 9
Armrest
– central .............................. 80
– rear .................................. 81
Ashtray.................................. 82
ASR system ............................ 102
At the filling station ......... 112-250
Automatic headlight sensor ........ 66
Automatic two zone
climate control system ............ 54
Battery
– checking the charge ............ 223
– jump starting ..................... 170
– recharging ......................... 204
II I
N N
D D
E E
X X
259-268 Alfa BRERA gb 28-08-2008 11:49 Pagina 259