2008 YAMAHA VX maintenance

Maintenance and care
75
CAUTION:
ECJ00230

Be careful not to place the battery on its
side.

Be sure to remove the battery from the
battery compartment when adding elec-
trolyte or charging the battery.
To remove the battery:
Disconnect the negative (–) battery lead first,
then the positive (+) battery lead and breather
hose, and then remove the battery from the
watercraft.
To replenish the battery:
(1) Make sure that the electrolyte level is be-
tween the maximum and minimum level
marks.
(2) If the electrolyte level is low, add distilled
water to raise it to the specified level.
CAUTION:
ECJ00240
Normal tap water contains minerals that
are harmful to a battery. Use only distilled
water for replenishing the battery.
To recharge the battery:
CAUTION:
ECJ00250
Do not attempt to charge a battery hastily.
Battery life could be shortened.
It is recommended to have a Yamaha dealer
charge the battery. If you charge the battery
yourself, be sure to read and follow the in-
structions provided with the battery tester and
charger you use.
To install the battery:
(1) Place the battery in the battery compart-
ment and connect the battery leads to the
battery terminals.
(2) Connect the breather hose to the battery.
(3) Secure the battery in place.
WARNING
EWJ00400
Be sure to connect the breather hose to
the battery. Fire or explosion could result
if the breather hose is damaged, obstruct-
ed, or not connected properly.
CAUTION:
ECJ00260
After installation, make sure that the bat-
tery leads are properly connected to the
battery terminals.
EJU34490Fuel injection system
The fuel injection system was set at the
Yamaha factory. If the fuel injection system
needs to be adjusted, have a Yamaha dealer
service the watercraft.
1Maximum level mark
2Minimum level mark
1Positive (+) battery terminal: Red lead
2Negative (–) battery terminal: Black lead
3Breather hose
UF1K73E0.book Page 75 Wednesday, July 11, 2007 9:15 AM

Maintenance and care
76
CAUTION:
ECJ00220
Do not attempt to adjust the fuel injection
system. If the settings are disturbed by
someone who does not have the neces-
sary technical knowledge, poor engine
performance and damage may result.
EJU34500Checking the trolling speed
(1) Place the watercraft in the water.
(2) Start the engine and warm it up. Use the
tachometer in the multifunction informa-
tion center to check the trolling speed.
If the trolling speed is out of specification,
have a Yamaha dealer service the watercraft.Trolling speed:
1650 ±50 r/min
UF1K73E0.book Page 76 Wednesday, July 11, 2007 9:15 AM

Index
A
Air filter element ....................................... 71
B
Battery ................................................ 44, 65
Battery, checking...................................... 74
Battery, jumping ....................................... 81
Beaching the watercraft ........................... 60
Bilge ......................................................... 43
Boarding alone ......................................... 55
Boarding and starting from a dock ........... 54
Boarding and starting in deep water ........ 54
Boarding and starting in shallow water .... 54
Boarding with passengers ........................ 55
Bow eye ................................................... 28
Builder’s plate............................................. 2
C
Capsized watercraft ................................. 57
Check engine warning indicator ............... 34
Cleaning the watercraft ............................ 65
Cooling water pilot outlet .................... 26, 48
Craft Identification Number (CIN) ............... 1
Cruising limitations ................................... 10
D
Docking the watercraft ............................. 60
E
Emergency procedures ............................ 80
Engine break-in ........................................ 49
Engine compartment ................................ 42
Engine oil ................................................. 39
Engine oil and oil filter .............................. 70
Engine oil level ......................................... 42
Engine overheat warning indicator ........... 33
Engine serial number ................................. 1
Engine shut-off cord ................................. 47
Engine shut-off switch .............................. 25
Engine stop switch ................................... 25
Enjoy your watercraft responsibly ............ 18
F
Fire extinguisher....................................... 45
Flushing the cooling system ..................... 63
Front storage compartment ...................... 35
Fuel and oil............................................... 38
Fuel injection system................................ 75
Fuel level .................................................. 42
Fuel level meter........................................ 31Fuel level warning indicator ...................... 32
Fuel system .............................................. 64
Fuel system, checking .............................. 70
Fuel tank .................................................. 70
Fuel tank filler cap .................................... 24
Fuel tank, filling ........................................ 39
Fuses, replacing ....................................... 82
G
Gasohol .................................................... 38
Gasoline ................................................... 38
Getting to know your watercraft ............... 52
Glove compartment .................................. 36
H
Handgrip ................................................... 28
Hazard information ................................... 14
Hood ......................................................... 23
Hour meter/voltmeter ............................... 32
Hull and deck ........................................... 42
I
Identification numbers ................................ 1
Important labels .......................................... 3
J
Jet intake .................................................. 47
Jet intake and impeller, cleaning .............. 80
Jet thrust nozzle angle, checking ............. 71
Jumper cables, connecting ...................... 81
L
Labels, other .............................................. 7
Labels, warning .......................................... 4
Launching the watercraft .......................... 49
Learning to operate your watercraft ......... 52
Leaving the watercraft .............................. 51
Limitations on who may operate the
watercraft ................................................ 9
“L-MODE” indicator light (for VX Deluxe/
VX Cruiser) ........................................... 35
Lubrication................................................ 64
Lubrication points ..................................... 73
M
Main components, location of .................. 19
Maintenance and adjustments ................. 66
Model information....................................... 2
Multifunction information center ......... 30, 48
O
Oil pressure warning indicator .................. 32
UF1K73E0.book Page 1 Wednesday, July 11, 2007 9:15 AM

Index
Operating your watercraft......................... 52
Operation ................................................. 49
Operation of controls and other
functions ............................................... 23
Operation requirements ........................... 11
Owner’s/operator’s manual and tool kit .... 67
P
Periodic maintenance chart...................... 68
Post-operation care .................................. 61
Pre-operation check list............................ 40
Pre-operation check points ...................... 42
Pre-operation checks ............................... 40
Primary Identification (PRI-ID) number ...... 1
R
Recommended equipment ....................... 13
Remote control transmitter
(for VX Deluxe/VX Cruiser) ................... 24
Reverse on waterways
(for VX Deluxe/VX Cruiser) ................... 60
Riding with passengers ............................ 53
Rough water operation ............................. 61
S
Safe boating rules .................................... 17
Seat .......................................................... 23
“SECURITY” indicator light
(for VX Deluxe/VX Cruiser) ................... 34
Selecting the normal mode/low-RPM
mode (for VX Deluxe/VX Cruiser) ......... 30
Shift cable, checking (for VX Deluxe/
VX Cruiser) ........................................... 71
Shift lever and reverse gate
(for VX Deluxe/VX Cruiser) ................... 46
Shift lever (for VX Deluxe/VX Cruiser) ..... 27
Spark plugs, cleaning and adjusting ........ 72
Speedometer............................................ 31
Start switch............................................... 26
Starting the engine ................................... 49
Starting the watercraft .............................. 53
Steering system ................................. 27, 45
Stern drain plugs ...................................... 44
Stern eyes ................................................ 28
Stopping the engine ................................. 51
Stopping the watercraft ............................ 60
Storage..................................................... 63
Storage compartments ............................. 35Submerged watercraft .............................. 83
Switches ................................................... 48
T
Tachometer .............................................. 31
Throttle cable, checking and adjusting ..... 72
Throttle lever ...................................... 26, 45
Towing the watercraft ............................... 83
Transporting ............................................. 62
Trolling speed, checking .......................... 76
Troubleshooting ....................................... 78
Troubleshooting chart .............................. 78
Turning the watercraft .............................. 58
W
Water separator ....................................... 43
Watercraft characteristics ......................... 14
Water-skiing ............................................. 16
Y
Yamaha Engine Management System
(YEMS) ................................................. 28
Yamaha Security System and low-RPM
mode (for VX Deluxe/VX Cruiser) ......... 29
Yamaha Security System
(for VX Deluxe/VX Cruiser) ................... 29
Yamaha Security System lock and
unlock modes (for VX Deluxe/
VX Cruiser) ........................................... 29
UF1K73E0.book Page 2 Wednesday, July 11, 2007 9:15 AM