2008 TOYOTA YARIS HATCHBACK fuel pump

5
When trouble arises
297
5-1. Essential information
Fuel pump shut off system
Follow the procedure below to restart the engine after the system is
activated.Turn the engine switch to the ACC or LOCK position.
Restart the engine.
NOTICE
nBefore starting the engine
Inspect the ground under the vehicle.
If you find that fuel has leaked onto the ground, the fuel system has been
damaged and is in need of repair. Do not restart the engine.
To minimize the risk of fuel leakage when the engine stalls or an air-
bag inflates upon collision, the fu el pump shut off system stops sup-
plying fuel to the engine.

340 6-1. Specifications
Engine
Fuel
Model1NZ-FE
Type 4-cylinder in line, 4-cycle, gasoline
Bore and stroke 2.95 × 3.33 in. (75.0 × 84.7 mm)
Displacement 91.3 cu.in. (1497 cm3)
Drive belt tension 55 — 88 lbf (245 — 392 N, 25 — 40 kgf)
*
*: Drive belt tension measured with Boroughs drive belt ten- sion gauge No. BT-33-73F (used belt)
Fuel type Unleaded gasoline only
Octane rating 87 (Research octane number 91) or higher
Fuel tank capacity
(Reference) 11.1 gal. (42.0 L, 9.2 lmp.gal.)
Generator
Water pump Air
conditioning
compressor
Crankshaft

347
6-1. Specifications
6
Vehicle specifications
Fuel information
nFuel tank opening fo r unleaded gasoline
To help prevent incorrect fueling, your Toyota has a fuel tank opening that
only accommodates the special nozzle on unleaded fuel pumps.
n If your engine knocks
lConsult your Toyota dealer.
l You may occasionally notice light knocking for a short time while acceler-
ating or driving uphill. This is normal and there is no need for concern.
n Gasoline quality
In very few cases, driveability problems may be caused by the brand of gas-
oline you are using. If driveability problems persist, try changing the brand of
gasoline. If this does not correct the problem, consult your Toyota dealer.
n Gasoline quality standards
lAutomotive manufacturers in the US, Europe and Japan have developed
a specification for fuel quality called World-Wide Fuel Charter (WWFC)
that is expected to be applied worldwide.
l The WWFC consists of four categories that are based on required emis-
sion levels. In the US, category 4 has been adopted.
l The WWFC improves air quality by lowering emissions in vehicle fleets,
and customer satisfaction through better performance.
Your vehicle must use only unleaded gasoline.
Unleaded gasoline with an octane rating of 87 (Research Octane
Number 91) or higher.
At minimum, the gasoline you us e should meet the specifications
of ASTM D4814 in the U.S.A. and CGSB3.5-M93 in Canada.

377
Alphabetical index
If the vehicle becomes
stuck................................... 335
If your vehicle needs to be towed ................................. 290
If your vehicle overheats ...... 332
Engine Compartment........................ 239
Engine switch ....................... 119
Hood ..................................... 236
How to start the engine ........ 119
Identification number ............ 339
If the engine will not start...... 323
Ignition switch ....................... 119
Immobilizer system................. 70
Overheating .......................... 332
Specifications ....................... 340
Warning light ........................ 301
Engine coolant Capacity ............................... 342
Checking .............................. 244
Indicator................................ 135
Preparing and checking before winter ...................... 151
Type ..................................... 342
Warning light ........................ 301
Engine immobilizer system ...... 70
Engine oil
Capacity ............................... 341
Checking .............................. 240
Grade ................................... 341
Initializing the maintenance data .................................... 243
Preparing and checking before winter ...................... 151
Warning light ................ 301, 303
Engine switch .......................... 119
Engine oil maintenance data ........................................ 242
EPS EPS ...................................... 145
Warning light ........................ 301
Event data recorder ................ 298 Floor mat...................................218
Fluid
Automatic transmission .........343
Brake .....................................246
Clutch ....................................344
Warning light .................300, 303
Washer ..................................250
Fog lights
Indicator ................................141
Replacing light bulbs .............280
Switch....................................141
Wattage .................................346
Front fog lights Indicator ................................141
Replacing light bulbs .............280
Switch....................................141
Wattage .................................346
Front passenger's seat belt reminder light.........................303
Front seats
Adjustment ..............................37
Front side marker lights Replacing light bulbs .............280
Switch....................................139
Wattage .................................346
Front turn signal lights
Indicator ................................126
Lever .....................................126
Replacing light bulbs .............280
Switch....................................126
Wattage .................................346
Fuel
Capacity ................................340
Fuel pump shut off system ....297
Gas station information .........388
Gauge ...................................129
Information ............................347
Refueling .................................66
Type ......................................340
Warning light .........................303
Fuel door.....................................66
Fuel filler door ............................66
Fuel gauge ................................129F

378 Alphabetical index
Fuel pump shut off system ..... 297
Fuses......................................... 269
Gas station information........... 388
Gauges ...................................... 129
Glove boxes.............................. 206
Head restraintsAdjusting ................................45
Headlights Indicator ................................ 139
Replacing light bulbs ............. 280
Switch.................................... 139
Wattage ................................. 346
Hood .......................................... 236
I/M test....................................... 232
Identification
Engine ................................... 339
Tire ........................................ 350
Vehicle .................................. 339
Ignition switch .......................... 119
Illuminated entry system ......... 204
Immobilizer system....................70
Indicator lights ......................... 135
Initialization Items to initialize.................... 365
Inside rear view mirror ..............59
Interior light Switch.................................... 205
Wattage ................................. 346
Jack Positioning a floor jack .......... 237
Replacing the flat tire ............ 310
Jack handle .............................. 310
Keys Electronic key ..........................26
Engine switch ........................ 119
If you lose your keys ............. 326
Ignition switch........................ 119 Key battery ............................ 267
Key number plate .................... 26
Keys ........................................ 26
Mechanical key ....................... 26
Wireless remote control .......... 28
License plate lights Replacing light bulbs ............. 280
Switch ................................... 139
Wattage................................. 346
Light bulbs Replacing .............................. 280
Wattage................................. 346
Lights Fog lights switch ................... 141
Headlights switch .................. 139
Instrument panel lightsswitch.................................. 139
Interior light switch ................ 205
License plate lights switch .... 139
Parking lights switch ............. 139
Personal lights switch ........... 205
Replacing light bulbs ............. 280
Side marker lights switch ...... 139
Tail lights switch .................... 139
Turn signal lights switch ........ 126
Load capacity ........................... 150
Lock steering column.............. 121
Luggage compartment features Auxiliary boxes ...................... 219
Luggage cover ...................... 220
Luggage compartment light Wattage................................. 346
Maintenance Do-it-yourself maintenance ... 233
Emission inspection and
maintenance (I/M)
programs ............................ 232
General maintenance............ 229
Maintenance data ................. 338
Maintenance requirements ... 227
G
H
I
J
K
L
M

TABLE OF CONTENTSIndex
4
4-3. Do-it-yourself maintenance ................... 233
Do-it-yourself service precautions ...................... 233
Hood................................... 236
Positioning a floor jack ....... 237
Engine compartment .......... 239
Tires ................................... 252
Tire inflation pressure......... 258
Wheels ............................... 262
Air conditioning filter ........... 264
Key battery ......................... 267
Checking and replacing fuses ................................ 269
Light bulbs .......................... 280
5-1. Essential information....... 290 If your vehicle needs to be towed ............................... 290
If you think something is wrong ............................... 296
Fuel pump shut off system .............................. 297
Event data recorder............ 298
5-2. Steps to take in an emergency ...................... 300
If a warning light turns on or a warning buzzer
sounds... .......................... 300
If you have a flat tire ........... 310
If the engine will not start ... 323
If the shift lever cannot be shifted from P ................... 325
If you lose your keys .......... 326 If the vehicle battery is
discharged ........................ 327
If your vehicle overheats..... 332
If the vehicle becomes stuck ................................. 335
6-1. Specifications ................... 338 Maintenance data (fuel, oil level, etc.) ........... 338
Fuel information .................. 347
Tire information................... 350
6-2. Customization ................... 363 Customizable features ........ 363
Items to initialize ................. 365
Reporting safety defects for U.S. owners ...................... 368
Seat belt instructions for Canadian owners
(in French) ......................... 369
Abbreviation list ........................ 374
Alphabetical index .................... 375
What to do if... ........................... 383
5When trouble arises
6Vehicle specifications
7For owners
Index