2008 TOYOTA CAMRY Warranty And Maintenance Guide

Evaporative Control System
•
Charcoal canister
•Diaphragm valve
•Fuel filler cap
•Fuel tank
•Vapor liquid separator
Exhaust Gas Recirculation (EGR) System
•
EGR gas temperature sensor
•EGR valve
•Associated parts
Ignition System
•
Distributor and internal parts
•Ignition coil and ignitor
•Ignition wires
•Spark plugs*
Positive Crankcase Ventilation (PCV) System
•
Oil filler cap
•PCV valve or orifice
Other Parts Used in Above Systems
•
Data link connector (8/80)
•Hoses, clamps, fittings, tubing and mounting hardware
•Malfunction indicator light and bulb (8/80)
•Pulleys, belts and idlers
•Sealing gaskets and devices
•Sensors, solenoids, switches and valves
Your Warranties in Detail16
FEDERAL EMISSION CONTROL WARRANTY
*Warranted until first required maintenance under terms of the
California Emission Control Warranty.
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
AllModelsOWI-Text.cgla 6/20/07 11:50 PM Page 16

You are responsible for performance of the required maintenance indi-
cated in the
Owner’s Manualand the Scheduled Maintenance Guide.
Toyota will not deny a warranty claim solely because you do not have
records to show that you maintained your vehicle. However, any failure
or noncompliance caused by lack of maintenance is not covered by this
warranty.
When maintenance and repairs are paid for by you, these services
may be performed by you or by any automotive service provider you
choose. Toyota will not deny a warranty claim solely because you
used a service provider other than a Toyota dealership for mainte-
nance and repairs. However, any failure or noncompliance caused by
improper maintenance or repairs is not covered by this warranty. To ensure optimum performance and maintain the quality built into
your vehicle’s emission control systems, Toyota recommends the use
of Genuine Toyota Parts when servicing or repairing the systems.
Warranty coverage is not dependent upon the use of any particular
brand of replacement parts and you may elect to use non-Genuine
Toyota Parts for maintenance and repairs. However, use of replace-
ment parts that are not equivalent in quality to Genuine Toyota Parts
may impair the effectiveness of the emission control systems.
If you use replacement parts that have maintenance or replacement
schedules different from those of Genuine Toyota Parts, you must fol-
low the maintenance and replacement schedules for the parts you are
using. In addition, you should ensure that such parts are warranted by
their manufacturers to be equivalent to Genuine Toyota Parts.
MAINTENANCE REPLACEMENT PARTS
Your Warranties in Detail17
FEDERAL EMISSION CONTROL WARRANTY
AllModelsOWI-Text.cgla 6/20/07 11:50 PM Page 17

IF YOUR VEHICLE FAILS AN EMISSIONS TEST IF YOU HAVE QUESTIONS
If your vehicle fails an EPA-approved emissions test, you may make a
claim under the Emission Performance Warranty. To do so, take your
vehicle to an authorized Toyota dealership and present a copy of the
emissions test report. Also, take your maintenance records in case they
are needed.
If your claim qualifies for coverage, the dealership will repair your vehi-
cle within 30 days (unless a shorter period is required by law). If your
claim is denied, Toyota will notify you in writing of the reason within
the same period. If we fail to do so, we will repair your vehicle free of
charge. The only exceptions allowed are when you request or agree to
a delay, or when a delay is caused by factors beyond the control of
Toyota or the dealership.
For information on how to obtain service under the Emission Defect
Warranty, see page 30, “Obtaining Warranty Service.” If you have questions or concerns about your vehicle’s federal emission
warranty coverage, please follow the steps described under “If You
Need Assistance” on pages 4–5. In the case of the Emission
Performance Warranty, you may also request information from or
report complaints to:
U.S. Environmental Protection Agency
Vehicle Programs & Compliance Division (6405J)
Attn: Warranty Complaints
401 M Street SW
Washington, D.C. 20460
Excluding Camry PZEV, vehicles equipped with a California
Certified Emission Control System that are sold, registered and
operated in California or any state that adopts California emission
warranty provisions are also covered by the California Emission
Control Warranty (see page 20). Currently, Connecticut, Maine,
Massachusetts, Pennsylvania, Rhode Island and Vermont are the
other states to which the California Emission Control Warranty
applies.
Your Warranties in Detail18
FEDERAL EMISSION CONTROL WARRANTY
AllModelsOWI-Text.cgla 6/20/07 11:50 PM Page 18

We (the dealership) want you to know that at the time your new Toyota
vehicle is being delivered:
1) On the basis of written notification furnished by Toyota, we have knowledge that the vehicle is covered by an EPA Certificate of
Conformity.
2) We have visually inspected those emission control devices or por- tions thereof that are visible without removing or adjusting any
components or systems, emissions-related or otherwise. On the
basis of this inspection, there are no apparent deficiencies in the
installation of emission control devices by Toyota. (For purposes
of this certificate, “emission control devices” is limited to devices
installed on a vehicle for the sole or primary purpose of controlling
emissions and which were not in general use before 1968.)
3) We have performed all emission control system preparations required by Toyota prior to the sale of the vehicle as set forth in
Toyota’s current pre-delivery service manual.
4) Except as may be provided in Paragraph 5, if this vehicle fails an EPA-approved emissions test within three months or 4,000 miles
(whichever comes first) of delivery to the ultimate purchaser, and
the vehicle has been maintained and used in accordance with the
written instructions for proper maintenance and use, Toyota will remedy the nonconformity free of charge under the terms of the
Emission Performance Warranty.
5) If vehicle was used as a company car or demonstrator, check box and complete the following:

 The vehicle with which this statement is delivered was placed
into service as a company car or demonstrator prior to delivery.
The Emission Performance Warranty period commenced on the
date the vehicle was first placed into service, which was:
Month Day Year
Note: The dealership makes no representation or warranty that the
emission control system or any part thereof is without defect or that
the system will perform properly. The Emission Performance Warranty
referred to in Paragraph 4 and furnished with the vehicle is solely that
of the manufacturer.
This statement is required by section 207 of the Clean Air Act (42 U.S.C.
7541) and the EPA regulations issued thereunder.
Dealership Name
DEALER CERTIFICATE
Your Warranties in Detail19
FEDERAL EMISSION CONTROL WARRANTY
AllModelsOWI-Text.cgla 6/20/07 11:50 PM Page 19

YOUR WARRANTY RIGHTS
AND OBLIGATIONS
Excluding Camry PZEV, vehicles equipped with a California Certified
Emission Control System that are sold, registered and operated
in California or any state that adopts California emission warranty
provisions are covered by this warranty. Currently, Connecticut,
Maine, Massachusetts, Pennsylvania, Rhode Island and Vermont
are the other states to which this warranty applies. Vehicles cov-
ered by this warranty are also covered by the Federal Emission
Control Warranty (see page 14). The California Air Resources Board (CARB) and Toyota are pleased to
explain the emission control system warranty for your 2008 vehicle.
In California, new motor vehicles must be designed, built and equipped
to meet the state’s stringent anti-smog standards. CARB regulations
require that Toyota must warrant the emission control system on your
vehicle for the time periods indicated on the next page, provided there
has been no abuse, neglect or improper maintenance of your vehicle.
Your emission control system may include parts such as the fuel injec-
tion system, ignition system, catalytic converter and engine computer.
Also included may be hoses, belts, connectors and other emissions-
related assemblies.
Where a warrantable condition exists, Toyota will repair your vehicle at
no cost to you, including diagnosis, parts and labor.
Your Warranties in Detail20
CALIFORNIA EMISSION CONTROL WARRANTY
AllModelsOWI-Text.cgla 6/20/07 11:50 PM Page 20

1) For three years or 50,000 miles, whichever occurs first:*
•If your vehicle fails a smog-check test, all necessary repairs and
adjustments will be made by Toyota to ensure that your vehicle
passes the test. This is your Emission Control System PERFOR-
MANCE WARRANTY.
•If an emissions-related part listed on pages 15–16 is defective,
the part will be repaired or replaced by Toyota. This is your
SHORT-TERM Emission Control System DEFECT WARRANTY.
Specific components may have longer coverage under the terms
of the Powertrain Warranty.
2) For seven years or 70,000 miles, whichever occurs first:*
•If an emissions-related part listed on pages 22–23 is defective,
the part will be repaired or replaced by Toyota. This is your
LONG-TERM Emission Control System DEFECT WARRANTY. You are responsible for performance of the required maintenance indi-
cated in the
Owner’s Manual and the Scheduled Maintenance Guide.
Toyota recommends that you retain all receipts covering maintenance
on your vehicle, but Toyota cannot deny warranty coverage solely for
the lack of receipts or your failure to ensure the performance of all
scheduled maintenance.
You are responsible for presenting your vehicle to a Toyota dealership
as soon as a problem exists. The warranty repairs should be completed
in a reasonable amount of time, not to exceed 30 days.
You should also be aware that Toyota may deny you warranty coverage
if your vehicle or a part has failed due to abuse, neglect, improper
maintenance or unapproved modifications.
If you have any questions regarding your warranty rights and respon-
sibilities, you should contact the Toyota Customer Experience Center
at (800) 331-4331 or the California Air Resources Board, Mobile Source
Control Division, at 9528 Telstar Avenue, P.O. Box 8001, El Monte, CA
91734-8001.
MANUFACTURER’S WARRANTY COVERAGE OWNER’S WARRANTY RESPONSIBILITIES
Your Warranties in Detail21
CALIFORNIA EMISSION CONTROL WARRANTY
*For Camry 4-cylinder models certified as partial zero-emission vehicles (PZEV)
that are sold, registered and operated in California, Connecticut, Maine,
Massachusetts, New Hampshire, New Jersey, New York, Rhode Island or
Vermont, all emissions components are covered for 15 years or 150,000 miles,
whichever occurs first, for performance and defect.
AllModelsOWI-Text.cgla 6/20/07 11:50 PM Page 21

WHAT IS NOT COVERED PARTS LIST: LONG-TERM EMISSION DEFECT WARRANTY
These warranty obligations do not apply to failures or noncompliance
caused by:
•The use of replacement parts not certified in accordance with
aftermarket parts certification regulations.
•The use of replacement parts not equivalent in quality or design
to original equipment parts.
Provisions under the “What Is Not Covered” section of the New Vehicle
Limited Warranty also apply to this warranty. The parts listed here are covered for seven years or 70,000 miles from
the vehicle’s in-service date, whichever occurs first.*
Air/Fuel Metering System
•
Air pump on Land Cruiser, Tacoma equipped with 2TR-FE, 4Runner
equipped with 2UZ-FE
•Engine control computer (engine control module)
•Throttle body
Air Induction System
•
Intake manifold and intake air surge tank
Your Warranties in Detail22
CALIFORNIA EMISSION CONTROL WARRANTY
*For Camry 4-cylinder models certified as partial zero-emission vehicles (PZEV)
that are sold, registered and operated in California, Connecticut, Maine,
Massachusetts, New Hampshire, New Jersey, New York, Rhode Island or
Vermont, all emissions components are covered for 15 years or 150,000 miles,
whichever occurs first, for performance and defect.
AllModelsOWI-Text.cgla 6/20/07 11:50 PM Page 22

Catalyst System
•
Catalytic converter (warm-up three-way catalyst)
•Exhaust center pipe on Highlander, RAV4, Sienna
•Exhaust front pipe on Avalon, Camry, Camry PZEV, Camry Solara,
Corolla, Corolla Matrix, FJ Cruiser, Land Cruiser, Tacoma, Yaris,
4Runner
•Exhaust front pipe no. 2 on FJ Cruiser, Land Cruiser, Tacoma
equipped with 1GR-FE, 4Runner
•Exhaust manifold on Avalon, Camry, Camry PZEV, Camry Solara,
FJ Cruiser, Highlander, Land Cruiser, RAV4, Sienna, Tacoma
equipped with 1GR-FE, 4Runner
•Exhaust manifold gasket on Land Cruiser
Evaporative Control System
•
Charcoal canister on Avalon, Camry, Camry PZEV, Camry Solara,
FJ Cruiser, Highlander, RAV4, Sienna, Yaris, 4Runner
•Fuel tank
Ignition System
•
Knock sensor on Camry equipped with 2GR-FE, Camry Solara,
FJ Cruiser, Land Cruiser, Sienna, Tacoma equipped with 1GR-FE,
4Runner
Your Warranties in Detail23
CALIFORNIA EMISSION CONTROL WARRANTY
AllModelsOWI-Text.cgla 6/20/07 11:50 PM Page 23