2008 TESLA ROADSTER technical specifications

Table of Contents
For information on how to use the Touch Screen, the High Power Connector, and the audio and
navigation systems, refer to the separate manuals provided in your owners package.Introduction and consumer information
Important notes about your vehicle 1-2
Important notes about this manual 1-3
Consumer information 1-4
Your vehicle at a glance Exterior 2-2
Interior 2-4
Seating an d safety restraints
Seats 3-2
Seat belts 3-3
Airbag system 3-6
Doors, locks, and s ecurity
Keys 4-2
Do ors
4-4
Trunk 4-6
Vehicle security 4-7
Charging your vehicle General information about charging 5-2
Charge settings 5-4
Charging components 5-6
Driving your vehicle Driving basics 6-2
Switches and controls 6-7
Instruments 6-11
Comfort and convenience Power windows 7-2
Rear view mirrors 7-3
Interior temperature control 7-4
Interior accessories 7-7
Removable roof 7-9
HomeLink® 7-15Audio and navigation systems
8-1
Maintenance and care Maintenance 9-2
Fluid reservoirs 9-4
Windshield wiper and washer 9-6
Cleaning and vehicle care 9-7
Roadside emergencies Tool kit 10-2
Energy Depletion 10-3
Tire repair 10-4
Wheels 10-6
Fuse replacement 10-7
Bulb replacement 10-9
Raising the vehicle 10-11
Vehicle recovery 10-13
Technical specifications Vehicle identification 11-2
Wheels and tires 11-4
Approved fluids and capacities 11-14
Vehicle dimensions and weights 11-15
Subsystem specifications 11-17
Roadster OHB.book Page 1 Thursday, October 2, 2008 8:59 AM

11-1
Technical specifications
Vehicle identificationVehicle Identification Number 11-2
Safety compliance certification label 1 1-3
Wheels and tires Specifications and tire pressures 11-4
Tire markings 11-5
Tire placard/label 11-7
Uniform tire quality grading 11-7
Tire care 11-8
Tire Pressure Monitoring System 11 -11
Dynamic tire pressure monitoring 11-12
Wheels and tires glossary 11-13
Approved fluids and capacities Fluid specifications 11-14
Capacities 11-14
Vehicle dimensions and weights Exterior dimensions 11-15
Vehicle weights 11-16
Subsystem specifications Motor 11-17
Transmission 11-17
Steering 11-17
Front suspension 11-18
Rear suspension 11-18
Brakes 11-18
Electrical 11-19
Battery 11-19
Roadster OHB.book Page 1 Thursday, October 2, 2008 8:59 AM

Vehicle identification11-2
Technical specifications
Technical specifications
Vehicle identification
SFZRE11B063000000*SFZRE11B063000000*
TR0047
Vehicle Identification NumberYou can find the Vehicle Identification
Number (VIN) in multiple locations:• Top of Dashboard - the VIN is stamped on
a plate which is visible through the lowest
part of the drivers side of the windshield.
• Chassis - the VIN is stamped on the
vehicle chassis, and is visible behind the
passenger side front wheel.
• Underside of Dashboard - a VIN label is
attached to the underside of the
dashboard. This label also displays the
vehicle paint code should repairs to the
vehicle’s painted surfaces be required.
• Touch Screen - the VIN can also be
displayed on the Touch Screen when your
vehicle is parked. For details, refer to the
Touch Screen Users Manual provided in
your owners package. TR0160
Roadster OHB.book Page 2 Th ursday, October 2, 2008 8:59 AM

Vehicle identification
11-3
Technical specifications
Safety compliance certification
labelThe National Highway Traffic Safety
Administration (NHTSA) regulations require
that a safety compliance certification label is
affixed to the vehicle. This label is located on
the opening face of the driver’s door.
R1
B RAKE FA
U
LT
C R U
IS Emph
rpmx10001
50
1
40
13
0
1
20
1
10
10
0
50
40
30
20
10 90
60 8070
0
0
1
2
3
4
5
6
7
8
9
10
11
12
13
1415T CPRN12
2:00PM
1R1RR
FA U
LTmphrpmx10000000000000000000050501 5000000000000000000000014000000000000000000000303013 00000000000000000000202020120000000000000000000000105012345678900000010111111112222222222123333333333134444414515TCRN12RN12RN12RN12RN12RN12RN12RN12
2:00PM0000000000000
TR0155
Roadster OHB.book Page 3 Th
ursday, October 2, 2008 8:59 AM

Wheels and tires11-4
Technical specifications
Wheels and tiresSpecifications and tire
pressuresWheel type
Location
Size
Forged light alloy - directional Front 6J x 16 Rear7.5J x 17
Tire type
Location
Size
Yokohama Neova AD07 LTS - directional Front 175/55 R16 Rear225/45 R17
Road wheel bolt torque 77 lbf.ft 105 Nm
Note: For details on where to position a jack to lift the vehicle, see Vehicle jacking points, page 10-11.Tire
Tire Pressure
Recommended
Comfort setting
Front 30 PSI (207 kPa)25 PSI (172 kPa)
Rear 40 PSI (276 kPa)36 PSI (248 KPa)
Note: The recommended tire pressures have been calculated to provide the best combination of vehicle range, tire life, ride comfort a nd road
handling.
Driving the vehicle with the tires inflated to the comfort setti ng will improve ride comfort and road handling, but will decrea se vehicle range (the
number of miles you can travel on a charge) and Battery life (see the New Vehicle Limited Warranty, provided in your owners pac kage, for details
on expected range of the Battery).
Roadster OHB.book Page 4 Th ursday, October 2, 2008 8:59 AM

Wheels and tires
11-5
Technical specifications
TR0057
225/45 R17/91 MADE IN JAPAN AD07 19444-2 STEEL BELTED RADIAL TUBELESS G4 0224943-S DOT FDH8 NWA1706


SAFETY WARNING DUE TO IMPROPER MOUNTING. ONLY SPECIALLY TRAINED PERSONS SHOU LD MOUNT TIRES
SERIOUS INJURY MAY RESULT FROM TIRE FAILURE DUE TO UNDERINFLATION/OVERLOADING - FOLLOW OWNER’S MAUAL OR TIRE FLAGARD
DANGER: DO NOT MOUNT ON 17 RIM. NEVER INFLATE BEYOND 275kPa (40psi) TO SEAT BEAD



TREADWARE 180 TRACTION AA TEMPERATURE A
ADVAN AD07 LTS
225/45R17 91W YOKOHAMA
1
12 2
3
4 5
6 7
8
9
10
11
Tire markings1, Tire widthThis three digit number gives the width in
millimeters of the tire from sidewall edge to
sidewall edge.2, Aspect ratioThis two digit number, known as the aspect
ratio or profile, gives the sidewall height as a
percentage of the tread width. So, if the tread
width is 205 mm, and the aspect ratio is 50,
the sidewall height will be 102 mm.3, Tire constructionR indicates that the tire is of Radial ply
construction.4, Wheel diameterThis two digit number is the diameter of the
wheel rim in inches.5, Load indexThis two or three digit number is the tire's load
index. It is a measurement of how much
weight each tire can support. This number is
not always shown.6, Speed ratingThe speed rating, when stated, denotes the
maximum speed at which the tire should be
used for extended periods. The ratings range
from 99 mph to 186 mph. These ratings are
listed in the following table.
Roadster OHB.book Page 5 Th ursday, October 2, 2008 8:59 AM

Wheels and tires11-6Technical specifications7, U.S DOT Tire Identification Number
(TIN)This begins with the letters DOT and
indicates that the tire meets all federal
standards. The next two numbers or letters
are the plant code where it was
manufactured, and the last four numbers
represent the week and year the tire was
built. For example, the numbers 1706 means
the 17th week of 2006. The other numbers
are marketing codes used at the
manufacturer's discretion. This information
can be used to contact consumers if a tire
defect requires a recall.8, Maximum permissible inflation
pressureThe maximum inflation pressure for the tire.
This pressure should not be used for normal
driving.
9, Treadwear gradeThis number indicates the tire's wear rate.
The higher the treadwear number is, the
longer it should take for the tread to wear
down. A tire rated at 400 for example, will
last twice as long as a tire rated at 200.10, Traction gradeThis letter indicates a tire's ability to stop on
wet pavement. A higher graded tire should
allow you to stop your vehicle on wet roads in
a shorter distance than a tire with a lower
grade.
Traction is graded from highest to lowest as
AA, A, B, and C.11, Temperature gradeHeat resistance grading. The tires resistance
to heat is grade A, B, or C, with A indicating
the greatest resistance to heat. This grading
is provided for a correctly inflated tire, which
is being used within its speed and loading
limits.12, Tire composition and materialsThe number of plies in both the tread area,
and the sidewall area, indicates how many
l aye rs o f ru bb e r co ate d m ate ri al m ake u p t h e
structure of the tire. Information is also
provided on the type of materials used.
Rating
Speed (mph)
Q99 R106S 112
T 118
U124
H130 V149
W168 Y186
Roadster OHB.book Page 6 Th ursday, October 2, 2008 8:59 AM

Wheels and tires
11-7
Technical specifications
Tire placard/labelThe tire information label on the pillar behind
the driver’s door contains the following
information:
• The maximum number of occupants for
the vehicle.
• The vehicle capacity weight, which
includes the weight of the driver,
passengers and cargo.
• The size of the tires with which the
vehicle was originally equipped.
• Cold inflation pressures for the front and
rear tires.
Note: The label must not be changed, even if
different wheels are fitted at a later stage.Steps for determining correct load
limit
WARNING: Do not exceed the vehicle
capacity weight (the total weight of
driver, passenger and cargo) given.
S
WARNING: Overloading the vehicle will
have an adverse affect on braking and
handling characteristics, which could
compromise your safety.
S
1. Locate the statement “The combined weight of occupants and cargo should
neve r exce e d 2 50 kg or 5 51 l bs ” as s h ow n
on your vehicle’s placard.
2. Determine the combined weight of the driver and passengers that will be riding
in your vehicle.
3. Subtract the combined weight of the driver and passengers from 250 kg or 551
lbs (weight given on placard).
4. The resulting figure equals the available amount of cargo and luggage load
capacity. For example, if there will be two
150 lb passengers in your vehicle, the
amount of available cargo and luggage
load capacity is 251 lbs: (551 - 300 (2 x
150) = 251 lbs).
TR0091
TIRE AND LOADING INFORMATIONSEATING CAPACITY TOTAL 2 FRONT2 REAR 0
SEE OWNERSMANUAL FOR ADDITIONAL
INFORMATION
The combined weight of occupants and cargo should never exceed 250 kg or 551lbs
ORIGINAL TIRE SIZE
COLD TIRE INFLATION PRESSURE
175/55R16
225/45R17 FRONT
REAR
207kPa, 30PSI
275kPa, 40PSI
5. Determine the combined weight of luggage and cargo being loaded on the
vehicle. That weight may not safely
exceed the available cargo and luggage
load capacity calculated in Step 4.
6. Your vehicle should never be used to tow a trailer.
The number and weight of passengers will
affect the cargo and luggage load capacity. In
the example above, the cargo and luggage
load capacity is 251 lbs. However, if only one
occupant is in the vehicle, the luggage load
capacity will increase. If the vehicle carries
one 150 lb person, the luggage load capacity
will increase to 401 lbs (551 - 150 = 401 lbs).
Note: If the passengers weigh more, the
luggage load capacity will decrease.Uniform tire quality gradingThe following information relates to the tire
grading system developed by the National
Highway Traffic Safety Administration
(NHTSA) which will grade tires by tread wear,
traction and temperature performance.
Note: Tires that have deep tread, and winter
tires, are exempt from these marking
requirements.
Quality grades, where applicable, can be
found on the tire sidewall between the tread
shoulder and maximum section width. For
example:TREADWEAR 180
TRACTION AA
TEMPERATURE A
Roadster OHB.book Page 7 Th ursday, October 2, 2008 8:59 AM