2008 Seat Exeo cooling

Checking and refilling levels
218tion. The damage caused by the use of these anti-freezes may lead to a loss
of liquid coolant, causing serious damage to the engine.•
The anti-freeze G12++ can be mixed on ly with anti-freeze additives G11,
G12 and G12+.
Checking the liquid coolant level
The liquid coolant level can be checked at a glance.– Switch the ignition off.
– Check the coolant level on liquid coolant expansion tank ⇒fig. 167. When the engine is cold, it should be between the
“min” and “max” marks. When the engine is hot, it may be
slightly above the “max” mark.Its location is shown in the correspon ding general overview of the engine
compartment. The liquid coolant level should be checked with the engine switched off.
The liquid coolant level is monitored
by a warning lamp in the instrument
panel ⇒ page 77. However, we recommend that it should be checked occa-
sionally.
Liquid coolant losses
Any loss of liquid coolant normally indicates a leak in the cooling system. In
this case the cooling system should be inspected by a specialist garage
without delay. It is not sufficient merely to top up the liquid coolant.
If there are no leaks in the system, a loss of liquid coolant can only occur if
the coolant boils and is forced out of the system as a result of overheating.
Caution
Radiator sealants must not be added to the liquid coolant. Such additives
could seriously impair the function of the cooling system.Topping up the liquid coolant
Be careful when topping up with liquid coolant.– Switch the engine off.
– Wait for the engine to cool down.
– Cover the cap on the expansion tank ⇒fig. 167 with a cloth, an d
carefully unscrew the cap anti-clockwise ⇒ .
– Add liquid coolant.
– Screw on the cap tightly.
Fig. 167 Engine compart-
ment: Liquid coolant
deposit
Exeo_EN.book Seite 218 Freitag, 17. Oktober 2008 11:24 11

Checking and refilling levels219
Safety First
Operating instructions
Practical tips
Te c h n i c a l D a t a
Make sure that the liquid coolant meets the required specifications
⇒
page 217, “Liquid coolant”. Do not use a different type of anti-freeze if
anti-freeze G12++ is not available. In th is case, use only water and bring the
anti-freeze concentration back up to the correct level as soon as possible.
Always top up with new liquid coolant.
Do not fill above the “max” mark. Excess liquid coolant is forced out of the
system through the valve in the filler cap when the engine gets hot.
If a lot of liquid coolant has been lost, wait for the engine to cool down before
putting in cold coolant. Failure to do so could result in serious engine
damage.
WARNING
•
The cooling system is under pressu re. Do not unscrew the cap on the
expansion tank when the engine is hot. Failure to comply could result in
burns.
•
The anti-freeze and liquid coolant c an be a health hazard. Therefore,
the anti-freeze should be stored in the original container in a safe place out
of reach of children. Failure to comply could result in poisoning.For the sake of the environment
Drained off coolant should not be used again. Drain off the used coolant into
a suitable container and dispose of it in the proper manner (observe environ-
mental regulations).
Radiator fan
The radiator fan can start running spontaneously.The auxiliary fan can continue to run for as long as 10 minutes after stopping
the engine – even after the ignition is switched off. It may also start running
suddenly ⇒ after some while if•
stored heat raises the coolant temperature, or
•
the hot engine compartment is additionally heated up by the sun.
WARNING
when working in the engine compartment be aware that the radiator fan
may start running suddenly, leading to the risk of injury.
Exeo_EN.book Seite 219 Freitag, 17. Oktober 2008 11:24 11

Index
292Catalytic converter . . . . . . . . . . . . . . . . . . . . . . 182
Central locking . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Manual locking . . . . . . . . . . . . . . . . . . . . . . . 99
Sunroof: opening and closing . . . . . . . . . . 110
Central locking system Anti-theft security system . . . . . . . . . . . . . . . 97
Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Locking and unlocking the vehicle from inside98
Opening and closing the windows . . . . . . 107
Security central locking . . . . . . . . . . . . . . . . 99
Switch on the driver's door . . . . . . . . . . . . . . 98
Tailgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Cetane number . . . . . . . . . . . . . . . . . . . . . . . . . 210
Changing the main headlight bulb
Main headlight . . . . . . . . . . . . . . . . . . . . . . 253
Changing the main headlight bulbs
Dipped beam headlight . . . . . . . . . . . . . . . 254
Changing the rear lights
luggage compartment lights . . . . . . . . . . . 269
Changing windscreen wiper blades . . . . . . . . . 221
Chassis number . . . . . . . . . . . . . . . . . . . . . . . . 278
Child safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Child safety seat ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . 52
Child seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48 Categorisation in groups . . . . . . . . . . . . . . . 48
Group 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Group 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Group 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49 Groups 0 and 0+ . . . . . . . . . . . . . . . . . . . . . . 48
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Securing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
Child seats on the front passenger seat . . . . . . . . . . . . . 29
Childproof lock Rear doors . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Cigarette lighter . . . . . . . . . . . . . . . . . . . . . . . . 147
Cleaning alloy wheel rims . . . . . . . . . . . . . . . . 202
Cleaning chrome . . . . . . . . . . . . . . . . . . . . . . . . 201
Cleaning engine compartment . . . . . . . . . . . . . 203
Cleaning steel wheel rims . . . . . . . . . . . . . . . . 202
Cleaning windows . . . . . . . . . . . . . . . . . . . . . . . 200
Climate control Air distribution . . . . . . . . . . . . . . . . . . . . . . 159
Air outlets . . . . . . . . . . . . . . . . . . . . . . . . . . 159
Air purity sensor . . . . . . . . . . . . . . . . . . . . . 157
Air recirculation . . . . . . . . . . . . . . . . . . . . . . 156
Air recirculation (automatic) . . . . . . . . . . . . 157
Automatic mode . . . . . . . . . . . . . . . . . . . . . 155
Blower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
ECON Mode (economy) . . . . . . . . . . . . . . . . 156
Economical use . . . . . . . . . . . . . . . . . . . . . . 160
Key settings . . . . . . . . . . . . . . . . . . . . . . . . . 160
Temperature selection . . . . . . . . . . . . . . . . 155
Clock, setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Cloth seat covers cleaning . . . . . . . . . . . . . . . . 204
Coat hooks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Cockpit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57 Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57 Compartments . . . . . . . . . . . . . . . . . . . . . . . . . . 149
In the door trim . . . . . . . . . . . . . . . . . . . . . . 150
In the front seats . . . . . . . . . . . . . . . . . . . . . 151
Cool box in glove compartment . . . . . . . . . . . . 150
Cooling system Coolant temperature gauge . . . . . . . . . . . . . 60
Malfunction . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Cruise control system . . . . . . . . . . . . . . . . . . . . 170 Adjust stored speed . . . . . . . . . . . . . . . . . . 171
Disabling . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Disabling temporarily . . . . . . . . . . . . . . . . . 172
Setting speed . . . . . . . . . . . . . . . . . . . . . . . 171
Curtain airbags . . . . . . . . . . . . . . . . . . . . . . . . . . 41 Description . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 42
DDanger of fitting a child seat on the front passenger seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Dash panel cleaning . . . . . . . . . . . . . . . . . . . . . 203
Data entry control . . . . . . . . . . . . . . . . . . . . . . . . 87
Date display . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Daytime running lights . . . . . . . . . . . . . . . . . . . 117
Diesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Diesel engine Winter driving . . . . . . . . . . . . . . . . . . . . . . . 211
Diesel engine particulate filter . . . . . . . . . . . . . 183
Diesel particulate filter . . . . . . . . . . . . . . . . . . . . 79 Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Exeo_EN.book Seite 292 Freitag, 17. Oktober 2008 11:24 11