2008 SAAB 9-3 gearbox

205 Car care
EngineTurbo 4-cylinder engineThe engine is a transverse four-cylinder
in-line engine with twin overhead camshafts
and 16 valves.
The engine is equipped with two balance-
shafts that reduce engine vibrations to a
minimum.
The balance shafts are chain-driven and
rotate at twice the speed of the crankshaft.
They produce forces and torques that are
opposed to those generated by the pistons
and connecting rods. The effect occurs
twice in each revolution of the engine, coun-
teracting the vibration from its moving parts,
and at the same time reducing unwanted
engine noise.
The gearbox, located on the right (viewed
from the front), is integrated with the engine.
Turbo V6 engineThe V6 engine is a turbocharged V6 engine
produced completely of aluminium with 60°
between the cylinder banks, 4 valves per
cylinder, 2 camshafts per bank.
The camshafts are driven via a chain trans-
mission. The engine is equipped with a
turbo whose turbine collects exhaust pres-
sure from both banks of cylinders.
To obtain optimum performance, fuel con-
sumption and low emission levels the
engine is equipped with CVCP (Continuous
Variable Cam Phasing). This means that
the engine’s intake camshafts can be
adjusted to achieve optimum functionality.
The switches are hydraulic.
Engine familiesSaab cars imported into the United States
and Canada meet all applicable emission
control standards. The engine family and
appropriate tune-up specifications are iden-
tified on a label in the engine bay.
These engine families meet applicable EPA
Federal Standards, California State Stan-
dards and Canadian Federal Standards and
are equipped with the following systems:
sequential multiport fuel injection system
three way catalytic converter
crankcase emissions control system
evaporative emission system.
93_US_M08.book Page 205 Friday, May 11, 2007 11:37 AM
ProCarManuals.com

291 Technical data
Fuel
EnginesElectrical systemFuel tank capacity 16.05 U.S. gal. (61 l)
For optimum performance Saab recom-
mends:Gasoline engines –
AON 90.
Gasoline with a lower octane rating can be used, although not
lower than AON 87. However, engine performance will fall slightly
and heavy loading and laboring should be avoided. For optimum
performance, use the recommended grade of fuel.
For further information on fuel, see page 161.
2.0T Ecopower
Rating, EEC at 5300 rpm ____________ 210 hp (155 kW)
Maximum torque, EEC at 2500-4000 rpm 221 ft.lb. (300 Nm)
Compression ratio__________________ 9.5:1
2.8 V6 Ecopower
Rating, EEC at 5500 rpm ____________ 255 hp (187 kW)
Maximum torque, EEC at 1800-4500 rpm 258 ft.lb. (350 Nm)
Compression ratio__________________ 10.0:1Voltage ___________________________ 12 V
Battery capacity ____________________ 60 Ah
Starter motor:
4-cyl engine ______________________ 1.8 kW
V6 engine ________________________ 1.4 kW
Alternator rating:
4-cyl engine with manual gearbox _____ 120 A/14 V
4-cyl engine with automatic gearbox ___ 140 A/14 V
V6 engine ________________________ 155 A/14 V
Firing order:
4-cyl engine ______________________ 1-3-4-2
V6 engine ________________________ 1-2-3-4-5-6
Spark plugs:
4-cyl engine
Type ____________________________ NGK PFR6T-10G
Electrode gap _____________________ 0.9–1.0 mm
Tightening torque __________________ 20 ft.lb. (28 Nm)
V6 engine
Type ____________________________ PLFR6C 10G
Electrode gap _____________________ 0.9–1.0 mm
Tightening torque __________________ 20 ft.lb. (28 Nm)93_US_M08.book Page 291 Friday, May 11, 2007 11:37 AM
ProCarManuals.com

297 Technical data
Plates and labelsWhen contacting your Saab dealer it may
sometimes be necessary to quote the car’s
vehicle identification, engine and gearbox
numbers.
1 V.I.N. number and barcode, inside wind-
shield
2 Gearbox number
3 Engine number
4USA: Tire information label can be found
on the B-pillar. See also page 254.
Canada: Label for tire pressure and color
codes (trim and body)
5 V.I.N. label and certification label.
USA: V.I.N. label also includes color
codes for trim and body
6 Chassis number (stamped on body).93_US_M08.book Page 297 Friday, May 11, 2007 11:37 AM
ProCarManuals.com

298 Technical data1 Region ________Y = Northern Europe
2 Country _______S = Sweden
3 Manufacturer ___3 = Saab Automobile AB
4 Product line ____F = 9-3
5 Model series ___B = 9-3 Linear
D = 9-3 Arc
F = 9-3 Aero6 Body version ___4 = 4-door
7 = Conver tible
5 = 5-door
7 Gearbox _______5 = 5-speed manual
6 = 6-speed manual
9 = 5-speed automatic
1 = 6-speed automatic
8Engine variant__Y = 2.0 Turbo
U = V6 engine
9 Check digit _____0-9 or X
10 Model year ____8 = 2008
11 Factory _______1 = Trollhättan
6 = Graz
12 Serial number __000001-999999 Position: 1234567891011 12
||||||||| | | |
Vehicle identifi-
cation number:Y S 3 F D 4 9 Y X 8 1 016584
| |||||
1 2 3 4 5 6 = identification codes for certain chassis components93_US_M08.book Page 298 Friday, May 11, 2007 11:37 AM
ProCarManuals.com

300 Technical dataWarning and indications that can
be shown on the SIDWhich warnings and indications that can be
shown depends on engine variant and car
specification.
Symbol Text
Antilock brake malfunc.
Contact service.
Brake malfunction.
Make a safe stop.
Brake fluid level low.
Make a safe stop.
Release park brake.
Oil pressure low.
Make a safe stop.
Low engine oil level.
Fill oil now.
Reduced engine power.
Contact service.
Limited performance.
Coolant level low.
Refill.
Hot engine. Make a
safe stop. Idle engine.
Airbag malfunction.
Contact service.
Gearbox too hot. Make a
safe stop. Open hood.
Battery not charging.
Make a safe stop.
Headlight levelling
malfunction.
Cornering headlights
malfunction
Tap brakes lightly
before using cruise ctrl.
Traction control failure.
Contact service.
Stability control failure.
Contact service.
Turn on the lights.
Washer fluid level low.
Refill.
Rain sensor malfunc.
Contact service.
Key not accepted.
Contact service.
Remote control battery
low. Replace battery.
Number of keys:
Active key number:
Steering lock malfunc.
Make a safe stop.
Pull out key, turn
steering wheel. Restart.
Theft protection failure.
Contact service.
Alarm tripped during
last arming period.
Rear left seat
backrest unlocked.
Rear right seat
backrest unlocked.
93_US_M08.book Page 300 Friday, May 11, 2007 11:37 AM
ProCarManuals.com

304 IndexDeep water, driving through
_______ 196
Definitions and terminology, tire ____ 254
Determining correct load, tires
_____ 256
Direction indicator stalk switch _____ 101
Direction indicators
______________ 101
Dome light, Convertible
__________ 232
Dome light, SportSedan __________ 232
Donor battery, boost starting
______ 200
Door handles
___________________ 48
Door mirrors
___________________ 124
Drive belt
______________________ 219
Drive belt, length
________________ 293
Driver’s seat with memory
_________ 21
Driving at night
_________________ 197
Driving in cold climates
___________ 187
Driving in deep water
____________ 196
Driving in hot climates ____________ 189
Driving techniques
______________ 185
Driving with a compact wheel fitted
_260
Driving with a heavy load on hilly
roads
________________________ 167
Driving with a load
______________ 196
Driving with a roof load ___________ 194
Driving with the trunk lid open
______ 196
EEasy entry, Convertible
____________ 73
EDR (Event Data Recorders)
______ 284
ESP®
________________________ 177
Economical motoring
____________ 185
Electrical system, technical data
____ 292Electrically adjustable seats
________ 20
Electric engine heater
____________ 186
Electric heating, front seats
________ 115
Electric windows
________________ 121
Electric windows, Convertible
_______ 77
Electronic Stability Program
_______ 177
Electronic steering wheel lock ______ 154
Emergency opening of the narrow
backrest, SportSedan
___________ 142
Emergency operation of the moonroof
132
Engine bay, cleaning
_____________ 267
Engine heater
__________________ 186
Engine immobilizer
_______________ 55
Engine management system
______ 206
Engine number
_________________ 299
Engine oil, checking
_____________ 210
Engine oil, grade
________________ 290
Engine oil, volume _______________ 291
Engine temperature gauge
_________ 88
Engine, description
______________ 205
Engine, technical data ____________ 289
Engines
_______________________ 292
Event Data Recorders (EDR)
______ 284
Extra electrical socket
____________ 136
FFacilitating entry to rear seat,
Convertible
____________________ 73
Factors affecting fuel consumption
__ 185
Filler cap
______________________ 160
Filling a portable fuel container
_____ 161Filling up
______________________ 159
Flat spots, tires
_________________ 246
Floor jack
______________________ 263
Folding down the rear seat backrest,
SportCombi
___________________ 143
Folding down the rear seat,
SportSedan ___________________ 138
Front fog lights __________________ 100
Front towing eye ________________ 197
Fuel container
__________________ 161
Fuel gauge
_____________________ 89
Fuel grade _____________________ 291
Fuel information
_________________ 161
Functions, car alarm
______________ 58
Fuse panel in luggage compartment
_240
Fuse table
_____________________ 239
Fuses
_________________________ 237
GGDO, garage door opener
_________ 126
Gearbox number
________________ 299
General safety instructions,
Convertible
____________________ 62
Glove box
_____________________ 136
Glovebox lighting
________________ 233
HHandbrake
_____________________ 179
Hazard warning lights
____________ 102
93_US_M08.book Page 304 Friday, May 11, 2007 11:37 AM
ProCarManuals.com

305 Index
Head restraint, Convertible
_________ 74
Head restraints
__________________ 23
Headlight flasher _________________ 99
Headlight levelling ________________ 98
Headlights
______________________ 98
Hood
_________________________ 204
Horn _________________________ 120
Horn button
____________________ 120
IIf a tire goes flat
________________ 251
Ignition switch
__________________ 152
Immobilizer
_____________________ 55
Important considerations for driving
_156
Important information, petrol-engined
cars with catalytic converters
_____ 157
Indicator lights
___________________ 82
Inflation, tires __________________ 244
Information about fuel
____________ 161
Instrument illumination, adjusting
___ 100
Interior lighting, Convertible
________ 78
Interior lighting, SportSedan and
SportCombi
___________________ 133
Interior rearview mirror
___________ 125
Intermittent malfunctioning, central
locking
_______________________ 50
JJump starting
__________________ 200
KKey
___________________________ 48
Kick-down
_____________________ 167
Kurvljusstrålkastare
_______________ 99
LLabeling, tire sidewall
____________ 252
Labels and plates, location
________ 299
Lashing eyes, SportCombi ________ 146
Lashing eyes, SportSedan ________ 141
Laying the car up
_______________ 181
LATCH (child safety) ______________ 25
Leather upholstery, cleaning
_______ 267
Lighting in luggage compartment,
Convertible
____________________ 79
Limp-home
____________________ 157
Limp-home, automatic transmission
_168
Load carriers, roof
_______________ 194
Load indices, tires _______________ 253
Loading your vehicle _____________ 254
Load-through hatch, SportCombi
___ 145
Load-through hatch, SportSedan ___ 140
Locking a car with flat battery
_______ 51
Locks
__________________________ 48
Long-term parking
_______________ 181
Luggage compartment
___________ 138
Luggage compartment lighting,
Convertible
____________________ 79Luggage compartment lighting,
SportSedan
_______________ 134
, 142
Luggage compartment lighting,
changing
_____________________ 234
MMain instrument panel
_____________ 82
Main/dipped beam
________________ 99
Maintenance schedule
___________ 280
Manual gear selection ____________ 170
Manual gearbox
_________________ 164
Manual tripping of car alarm
________ 58
Materials used in the car, reclamation
273
MAXI fuses
____________________ 238
Memory, driver’s seat
_____________ 21
Messages on SID, Convertible
______ 71
Milometer
_______________________ 90
Moonroof ______________________ 130
Mug holder ____________________ 134
NNew tires, buying
________________ 247
Night driving
___________________ 197
Number plate lighting, changing
____ 233
OORVR
________________________ 207
Oil capacity, engine
______________ 291
93_US_M08.book Page 305 Friday, May 11, 2007 11:37 AM
ProCarManuals.com

306 IndexOpening handles
_________________ 48
Opening the soft top, Convertible
____ 64
Outside mirrors
_________________ 124
Owner assistance _______________ 282
PPanic function, car alarm
__________ 58
Park Brake Shift Lock
____________ 166
Park Brake Shift Lock, temporary
override
______________________ 168
Parking
_______________________ 179
Parking aid ____________________ 182
Parking brake __________________ 179
Parking on a hill ________________ 180
Pinch protection, electric windows,
SportSedan and SportCombi
_____ 122
Pinch protection, moonroof
________ 132
Plates and labels, location ________ 299
Polishing and waxing
____________ 270
Poly-V-belt
____________________ 219
Portable fuel container
___________ 161
Position lights
___________________ 98
Power steering fluid, checking
_____ 215
Power steering fluid, grade
________ 294
Pressure gauge
_________________ 88
Pressure, tires
__________________ 244
Profiles, customized settings
_______ 94
QQuality grading, tires
_____________ 248
Quick guide, remote control
________ 49
RRain sensor
____________________ 105
Raising the soft top manually,
Convertible ____________________ 68
Reading lights, Convertible
_________ 78
Rear fog light
___________________ 101
Rear seat, folding down, SportCombi
143
Rear seat, safety belts
____________ 17
Rear seats, folding down, SportSedan
138
Rear towing eye
________________ 198
Rear windows, deactivating,
SportSedan and SportCombi
_____ 123
Rearview mirrors
________________ 124
Recommendations for automatic
transmission, towing a trailer
_____ 191
Recommendations for manual
gearbox, towing a trailer
_________ 192
Recommended snow chains _______ 296
Refueling
______________________ 159
Remote control
__________________ 48
Remote locking malfunction
________ 50
Replacement, wheel
_____________ 250
Reporting safety defects __________ 283
Rev counter
_____________________ 87
Reversing lights
________________ 102Rollover Pop-up Bars, Convertible
___ 76
Roof carriers, SportCombi with roof
rails
_________________________ 195
Roof carriers, SportSedan and
SportCombi without roof rails
_____ 194
Roof lighting, SportSedan and
SportCombi
___________________ 133
Roof lighting, changing
___________ 232
Running-in
_____________________ 163
SSaab Information Display
__________ 89
Saab Parking Assistance _________ 182
Safety belts
_____________________ 12
Safety belts, rear seat, SportSedan
and SportCombi
________________ 17
SAHR, head restraint _____________ 23
SDM
_________________________ 284
SID
___________________________ 89
SPA __________________________ 182
Seatbelts
_______________________ 12
Seatbelts in rear seat, Convertible
___ 75
Seatbelts, care
_________________ 266
Seatbelts, checking
______________ 266
Seats
__________________________ 18
Securing a load
_________________ 141
Sentronic, manual gear selection
___ 170
Service costs
___________________ 281
Service information
______________ 282
Service intervals
________________ 280
Service record retention
__________ 281
93_US_M08.book Page 306 Friday, May 11, 2007 11:37 AM
ProCarManuals.com