2008 Mercury Mariner Hybrid brake fluid

BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Check fluid levels with the ignition
in the RUN position. Fluid levels
between the “MIN” and “MAX” lines
are within the normal operating
range; there is no need to add fluid.
If the fluid levels are outside of the
normal operating range the
performance of your brake system could be compromised; seek service
from your authorized dealer immediately.
Brake pad replacement information
The Regenerative Braking System checks the integrity of the brake
system at times when the vehicle is parked. This is done by developing
brake pressure for short periods of time. In order to change the brake
pads, it is necessary to enter the Pad Service Mode. This will prevent
brake pressure from being applied.
To enter the Pad Service Mode, perform the following with the vehicle
stationary:
1. Place the vehicle in Park and turn ignition to the ON position.
2. Apply the brake pedal.
3. Turn the ignition OFF, then ON three times and then release the brake
pedal. The total time elapsed for the three ignition cycles and brake
release must beless than 3 seconds.
The brake warning lamp will:
•flash as stored hydraulic pressure is released.
•remain illuminated once the pressure is completely released.
•flash if the brake is applied.
To exit the Pad Service Mode:
1. Apply the brake pedal and turn the ignition OFF then ON. This will
cause brake pressure to be developed within the brake system. Once
brake pressure is developed, the brake warning light will turn off.
2. The Pad Service Mode will also be exited if the gear shift lever is
moved from the (P) Park position, the vehicle is moved (wheels rotate)
or the ignition is turned OFF.
MAX
MIN
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
278

Note:The brake system on this vehicle can only be bled at a authorized
dealer.
TRANSMISSION FLUID
Checking electronically controlled continuously variable
transmission (eCVT)
Refer to yourscheduled maintenance informationchapter for
scheduled intervals for fluid checks and changes. Your transaxle does not
consume fluid. It is designed to be filled for life. However, the fluid level
should be checked if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged
and your foot on the brake pedal,
turn the key to the ACCESSORY
position but do not start the engine.
Turn the wheel to the left to gain
access to the check plug.
4. Latch the gearshift lever in P (Park) and make sure that the engine is
OFF by placing the ignition in the Lock position.
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
279

MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES
Item CapacityFord Part Name or
equivalentFord Part Number /
Ford Specification
Brake fluidBetween MIN and
MAX lines on
reservoirMotorcraft High
Performance DOT 3
Motor Vehicle Brake
FluidPM-1-C /
WSS-M6C62-A
Body hinges, latches,
door striker plates and
rollers, seat tracks, fuel
filler door hinge and
spring, primary and
auxiliary hood latches— Multi-Purpose GreaseXG-4 or XL-5 /
ESB-M1C93-B
Engine coolant 8.5 quarts (8.0L)Motorcraft Premium
Gold Engine Coolant
with bittering agent
(yellow-colored)
1
VC-7-B /
WSS-M97B51-A1 Motor/Electronics (M/E)
Coolant3.7 quarts (3.5L)
Cooling system stop
leak pellets—Motorcraft Cooling
System Stop Leak PelletsVC-6 /
WSS-M99B37-B6
Engine oil 4.5 quarts (4.25L)Motorcraft SAE 5W-20
Premium Synthetic
Blend Motor Oil (US)
Motorcraft SAE 5W-20
Super Premium Motor
Oil (Canada)
2
XO-5W20-QSP (US)
CXO-5W20-LSP12
(Canada) /
WSS-M2C930-A with API
Certification Mark
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
285

WHICH MAINTENANCE SCHEDULE SHOULD YOU FOLLOW?
Owner Checks and Services
Refer to Mileage Intervals for Additional Checks and Services
Certain basic maintenance checks and inspections should be performed
by the owner or a service technician at the intervals indicated. Service
information and supporting specifications are provided in thisOwner’s
Guide.
Any adverse condition should be brought to the attention of your dealer
or qualified service technician as soon as possible for the proper service
advice. The owner maintenance service checks are generally not covered
by warranties so you may be charged for labor, parts or lubricants used.
Maximum Oil Change Interval
❑12 months, 10,000 miles (16,000 km) or 200 hours of engine operation.
Motorcraft Premium Gold Engine Coolant change interval
❑6 years or 100,000 miles (160,000 km) - change Motorcraft Premium Gold Engine Coolant (whichever comes first)❑After initial change - change Motorcraft Premium Gold Engine Coolant every 3 years or 50,000 miles (80,000 km).
Check every month
❑Check function of all interior and exterior lights❑Check tires for wear and correct air pressure, including spare tire
❑Check windshield washer fluid level
❑Check engine oil level
Check every six months
❑Check lap/shoulder belts and seat latches for wear and function❑Check that externally mounted spare tire is properly stowed (tight)
❑Check parking brake for proper operation
❑Check safety warning lamps (brake, ABS, air bag, safety belt) for operation
❑Check cooling system fluid level and coolant strength
❑Check low voltage (underhood) battery connections and clean if necessary
❑Check washer spray, wiper operation and clean all wiper blades (replace as necessary)
❑Check and lubricate all hinges, latches and outside locks. Inspect for correct operation
❑Check and lubricate door rubber weatherstrips. Inspect for excessive wear
❑Check and clean body and door drain holes. Inspect for clogs and obstructions
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
296

Multi-point Inspection
In order to keep your vehicle running right, it is important that you have
the systems on your vehicle checked regularly. This can help identify any
potential issue before there are any problems. Ford Motor Company
suggests the following multi-point inspection to be performed at every
scheduled maintenance as the way to ensure your vehicle keeps running
right.
NORMAL SCHEDULED MAINTENANCE AND LOG
The following section contains the “Normal Schedule”. This schedule is
presented at specific mileage (kilometer) intervals with exceptions
noted.
ADDITIONAL INFORMATION AVAILABLE ON THE WEB
To learn more about the importance of routine and dealer-performed
maintenance on your vehicle, please visit the Ford Customer Service Web
site. You’ll also find important warranty information, customer assistance,
technical expertise, frequently asked questions and much more. The Web
site location is: www.genuineservice.com.
Then go to the vehicles and services pick at the Web site.
Multi-point inspection - Recommended at every visit
❑Check and top up fluid levels: brake, engine coolant recovery reservoir, motor/electronics reservoir and window washer.❑Inspect tires for wear and correct air pressure.
❑Check exhaust system for leaks, damage, loose parts and foreign materials.
❑Check low voltage (underhood) battery performance.
❑Check operation of horn, exterior lamps, turn signals and hazard warning lights.
❑Check radiator, coolers and heater and air conditioning hoses.
❑Inspect windshield washer spray and wiper operation.
❑Check windshield for cracks, chips and pitting.
❑Inspect for oil and fluid leaks.
❑Inspect engine air cleaner filter and elements.
❑Inspect half-shaft dust boots.
❑Check shocks, struts and other suspension components for leaks and damage.
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
297

A
Accessory delay ..........................62
Air cleaner filter ...............281–284
Air conditioning
automatic temperature
control system ..........................39
Airbag supplemental restraint
system ........................123, 132, 135
and child safety seats ............125
description ..............123, 132, 135
disposal ....................................138
driver airbag ............125, 133, 136
indicator light .........132, 134, 137
operation .................125, 133, 136
passenger airbag .....125, 133, 136
side airbag ...............................132
All Wheel Drive (AWD),
driving off road .........................198
Ambulance packages ..................15
Anti-lock brake system
(see Brakes) ..............................188
Anti-theft system ........................96
Audio system (see Radio) .........25
Automatic transaxle
fluid, adding ............................279
fluid, checking ........................279
Automatic transmission
driving an automatic
overdrive .................................194
fluid, refill capacities ..............285
fluid, specification ..................285
Auxiliary input jack (Line in) ....32
Auxiliary power point .................58
Axle
lubricant specifications ..........285
refill capacities ........................285B
Battery .......................................259
acid, treating emergencies .....259
jumping a disabled
battery .............................227, 232
maintenance-free ....................259
replacement, specifications ...284
servicing ..................................259
Belt-Minder.............................118
Booster seats .............................139
Brakes ................................187–188
anti-lock ...................................188
anti-lock brake system (ABS)
warning light ...........................189
fluid, checking and adding ....278
fluid, refill capacities ..............285
fluid, specifications .................285
lubricant specifications ..........285
parking ....................................190
shift interlock ..........................192
Bulbs ............................................50
C
Capacities for refilling fluids ....285
Cargo area shade ........................79
Cell phone use ............................15
Child safety restraints ..............138
child safety belts ....................138
Child safety seats ......................142
attaching with tether straps ..146
in front seat ............................143
in rear seat ..............................143
Child safety seats - booster
seats ...........................................139
Cleaning your vehicle
engine compartment ..............245
instrument panel ....................247
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
309

L
Lamps
bulb replacement
specifications chart ..................50
daytime running light ...............46
fog lamps ...................................45
headlamps .................................44
headlamps, flash to pass ..........46
instrument panel, dimming .....47
interior lamps ...............48–49, 51
replacing bulbs .........................51
Lane change indicator
(see Turn signal) ........................48
Liftgate ..................................78, 91
Lights, warning and indicator ....18
anti-lock brakes (ABS) ..........189
Load limits .................................172
Loading instructions .................178
Locks
autolock ...............................85, 87
childproof ..................................89
doors ..........................................85
Lubricant specifications ...........285
Lug nuts ....................................226
Luggage rack ...............................80
M
Manual transmission
fluid capacities ........................285
lubricant specifications ..........285
Message center ...........................70
english/metric button ...............74
system check button ................73
warning messages .....................75Mirrors ...................................62, 65
automatic dimming rearview
mirror ........................................62
fold away ...................................65
heated ........................................65
side view mirrors (power) .......65
Moon roof ....................................69
Motorcraft parts ........249, 267, 284
N
Navigation system .......................38
O
Octane rating ............................271
Oil (see Engine oil) ..................256
P
Parking brake ............................190
Parts (see Motorcraft parts) ....284
Passenger Occupant
Classification Sensor .................110
Power distribution box
(see Fuses) ...............................212
Power door locks ........................85
Power mirrors .............................65
Power point .................................58
Power steering ..........................191
Power Windows ...........................61
Preparing to drive your
vehicle ........................................192
R
Radio ............................................25
Relays ........................................209
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
312

replacing ..................................158
rotating ....................................161
safety practices .......................160
sidewall information ...............162
snow tires and chains ............172
spare tire .........................216, 218
terminology .............................154
tire grades ...............................153
treadwear ........................153, 157
Towing .......................................178
recreational towing .................183
trailer towing ..........................178
wrecker ....................................234
Transmission .............................192
brake-shift interlock (BSI) ....192
fluid, checking and adding
(automatic) .............................279
fluid, refill capacities ..............285
lubricant specifications ..........285
Trunk ...........................................91
Turn signal ..................................48V
Vehicle Identification Number
(VIN) ..........................................288
Vehicle loading ..........................172
Ventilating your vehicle ...........187
W
Warning lights (see Lights) .......18
Washer fluid ..............................254
Water, Driving through .............204
Windows
power .........................................61
rear wiper/washer .....................56
Windshield washer fluid and
wipers ..........................................55
checking and adding fluid .....254
liftgate reservoir .....................254
replacing wiper blades ...255–256
Wrecker towing .........................234
2008 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
314