2008 MERCEDES-BENZ GL320 spare wheel

525 Practical hints
Flat tire
Mounting the new wheel
1Wheel bolt for 18", 19", 20" and 21"
light alloy wheels
2Wheel bolt for Minispare wheel (locat-
ed in vehicle tool kit (
page 490))
Clean contact surfaces of wheel and
wheel hub.
Guide spare wheel onto the alignment
bolt and push it on the wheel hub.
Insert wheel bolts and tighten them
slightly.
Unscrew the alignment bolt, install last
wheel bolt and tighten slightly.
!Wheel bolts2 must be used when mount-
ing the Minispare wheel. The use of any wheel
bolts other than wheel bolts2 for the Minispare
wheel will damage the vehicle’s brakes.
!To avoid paint damage, place wheel flat
against hub and hold it there while installing first
wheel bolt.
Warning!G
Always replace wheel bolts that are
damaged or rusted.
Never apply oil or grease to wheel bolts.
Damaged wheel hub threads should be
repaired immediately. Do not continue to
drive under these circumstances! Contact
an authorized Mercedes-Benz Light Truck
Center or call Roadside Assistance.
Incorrect wheel bolts or improperly tight-
ened wheel bolts can cause the wheel to
come off. This could cause an accident.
Make sure to use the correct wheel bolts.
Warning!G
Only use genuine Mercedes-Benz wheel
bolts. Other wheel bolts may come loose.
Do not tighten the wheel bolts when the
vehicle is raised. Otherwise the vehicle
could fall off the jack.
164.boo Seite 525 Freitag, 30. März 2007 12:54 12

526 Practical hints
Flat tire
Lowering the vehicle
Vehicles with scissors-type jack:
Attach ratchet to vehicle jack in such a
way that the wordDOWN can be seen.
Lower the vehicle until its resting fully
on its own weight.
Vehicles with screw-type jack:
Turn crank counterclockwise.
Vehicles with scissors-type jack:
Turn ratchet in Direction of DOWN.
Remove the jack.
1-5Wheel bolts
Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of
110 lb-ft (150 Nm).
Store jack and all other vehicle tool kit
items back into the storage well.
Warning!G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
110 lb-ft (150 Nm).
iThe removed road wheel cannot be stored in
the spare wheel well under the cargo compart-
ment floor, but should be transported in the car-
go compartment wrapped in a protective cover.
Vehicles with TPMS or Advanced TPMS*:
Do not activate the tire inflation pressure moni-
tor until a full size wheel/tire with functioning
sensor has been placed back into service on the
vehicle.
164.boo Seite 526 Freitag, 30. März 2007 12:54 12

558 Technical data
Rims and tires
Minispare wheel
ModelGL 320 CDI
GL 450
GL 550
Rim4.5B x 19 H2
Wheel offset1.58 in (40 mm)
Minispare tire1
1Must not be used with snow chains.
T 165/90 D19 119M
or
T 165/90 R19 119M
!Please compare the recommended tire
inflation pressure for your vehicle with the tire
inflation pressure on the yellow label located on
the Minispare wheel rim.
If the tire inflation pressure on the yellow label
on the Minispare wheel rim differs from the
values given in this Operator’s Manual, inflate
the tire to the recommended tire inflation pres-
sure given on the yellow label on the Minispare
wheel rim.iPlease note that the tire inflation pressure of
the Minispare tire differs from the tire inflation
pressure of the road tires.
164.boo Seite 558 Freitag, 30. März 2007 12:54 12

573 Index
Battery, Vehicle 528
Charging 535
Disconnecting and connecting 530
Jump starting 536
Removing and installing 530
Bead 416
Beverage holder see Cup holder
Bi-Xenon headlamps* see headlamps
Bolts, Spare wheel 494
Brake fluid 564
Checking 376
Messages in the multifunction
display 469
Brake lamp
Cleaning lenses 429
Messages in the multifunction
display 477
Replacing bulbs 511
Brake pads 348
Messages in the multifunction
display 467
Brakes 348
Warning lamp 437
Break-in period 346
Bulbs, replacing see Replacing bulbsButton for Voice control* system 30,
156
C
California retail buyers and lessees,
Important notice for 11
Camera see Rear view camera*
Can holder see Cup holder
Capacities and recommended
fuel/lubricants 562
Card holder 33, 37, 320
Cargo compartment cover blind 310
Cargo net* 312
Cargo tie-down rings 302
Carpets, Cleaning 433
Carriers* 295
Catalytic converter
(gasoline engine) 371
CD changer 165, 315
CD player 165
Center console
Lower part 33
Upper part (Vehicles with
enhanced off-road package*) 32
Upper part (Vehicles without
enhanced off-road package*) 31Central locking
Automatic 128
Locking/unlocking from the
inside 128
Switch 128
Certification label 550
CHECK ENGINE malfunction indicator
lamp 439, 440
Checking tire pressure electronically with
the Advanced Tire Pressure Monitoring
System (Advanced TPMS)*,
(Canada only) 401
Checking tire pressure electronically with
the Tire Pressure Monitoring System
(TPMS), (USA only) 398
Checklist
Off-road driving 357
Returning from off-road driving 363
164.boo Seite 573 Freitag, 30. März 2007 12:54 12

578 Index
ETD 89, 446
Safety guidelines 78
Expanding cargo compartment 304
Exterior rear view mirrors 51, 208
Folding 210
Power folding* 209
Synchronizing 209
F
Fastening the seat belts 53
Filler neck, Engine oil 381
First aid kit 490
Flat tire 519
Lifting the vehicle 520
Lowering the vehicle 526
Minispare wheel 494
Mounting the spare wheel 520
Preparing the vehicle 520
Floormats 325Fluids
Automatic transmission fluid 381,
562
Brake fluid 377, 563, 564
Capacities 562
Engine coolant 377, 381, 563, 567
Engine oil 380, 562, 564
Power steering fluid 562
Windshield washer and headlamp
cleaning system* 377, 569
Fog lamps 146
Corner-illuminating front fog
lamps* 147
Messages in the multifunction
display 478
Rear fog lamp 146
Replacing bulbs 510
4-ETS 107
Off-road - 4-ETS 108
Front air bags 79
Front defroster 221, 235
Front lamps see Headlamps
Front passenger front air bag 74, 79
Messages in the multifunction
display 460, 461, 462, 463Front passenger front air bag off indicator
lamp 31, 32, 85
Front seat head restraints see
Head restraints
Front towing eye 540
Fuel 375, 563
Additives 566
Capacities, Fuel tank 563
Consumption statistics 184, 185
Filling the tank 374
Fuel filler flap and cap 374, 497
Fuel gauge 29
Fuel tank reserve warning lamp 29,
446
Premium unleaded gasoline 375,
563, 565
Requirements, Octane rating 565
Fuel cap
Messages in the multifunction
display 474
164.boo Seite 578 Freitag, 30. März 2007 12:54 12

583 Index
Lighter see Cigarette lighter (Depending
on vehicle configuration)
Lighting, Exterior and interior 143
Limp-Home Mode 200, 439, 440
Loading see Vehicle loading
Locator lighting 146, 176
Lock buttons, KEYLESS-GO*
Outside door handle 71
Locking the vehicle see Key
Loss of keys, Mechanical key 120
Loss of keys, SmartKey 120
Loss of keys, SmartKey with
KEYLESS-GO* 120
Loss of Service and Warranty Information
Booklet 549
Low beam headlamps
Messages in the multifunction
display 479
Replacing bulbs 505
Switching on 61, 143
LOW RANGE mode* 201
Messages in the multifunction
display 488
Lubricants 562
Lumbar support 137M
Main dimensions 560
Maintenance 12, 422
Calling up service indicator
display 424
Clearing service indicator
message 423
Maintenance System 422
Resetting service indicator 424
Service indicator message 422
Service term exceeded 423
Maintenance System 422
Manual headlamp mode see Headlamps
Maximum cooling, MAXCOOL* see
Automatic climate control
(3-zone)* 237
Maximum load rating, Tires 417
Maximum loaded vehicle weight,
Tires 417
MB Tex upholstery, Cleaning and
care of 434
Mechanical key 496Memory function* see Seats
Menus see Control system menus
Messages in display see Multifunction
display messages
Microphone, Hands-free 34
Minispare wheel see Spare wheel
Mirrors
Adjusting 51
Auto-dimming rear view
mirrors* 208
Exterior rear view mirror 51
Interior rear view mirror 51, 208
MON 375, 565
Multicontour seat* 138
Multifunction display 155
Changing settings see Control system
menus and Control system sub-
menus
Displaying current gear range 197
Selecting display 173
Selecting language 172
164.boo Seite 583 Freitag, 30. März 2007 12:54 12

589 Index
Vehicle level control 279
Shifting
Automatic transmission 56, 189
Side impact air bags 80
Side marker lamps
Cleaning lenses 429
Messages in the multifunction
display 480
Replacing bulbs 510, 513
Side windows see Power windows
Sidewall 417
SmartKey see Key, SmartKey
SmartKey see Key, SmartKey with
KEYLESS-GO*
Snow chains 421
Snow tires see Winter tires
Spare wheel 494
Mounting 520
Wheel bolts 492, 525
Speed settings
Cruise control 257
Distronic* 266
Speedometer 27, 263Spinning see Tires, Direction of rotation
SRS 88
Indicator lamp 29, 446
Messages in the multifunction
display 446
Standing lamps 143
Replacing bulbs 504, 505, 509, 511,
513
Standing water, Driving through 360
Starter switch 25, 42
Positions 42
Starting difficulties, Engine 59
Starting, Engine 56
Steep terrain, Driving 358
Steering column 49, 50
Steering wheel 48
Adjustment, Electrically* 50
Adjustment, Manually 49
Buttons 30, 156
Cleaning 433
Steering wheel gearshift control,
Automatic transmission 198
Stolen Vehicle Recovery services 338Storage compartments 36, 315
Cup holder 320
Cup holders 320
Door pockets 36
Front center console 317
Glove box 315
Parcel net, Front passenger
footwell 319
Parcel nets, Front seat backrest 319
Rear seats, In front of 318
Storage/telephone* compartment
Armrest, Front 317
Storing tires 386
Stranded vehicle 542
Submenus see Control system submenus
Sun visors 210
Sunroof see Power tilt/sliding sunroof*
Sunshade
Rear panorama roof 212
Suspension tuning see Air suspension
program
Symbols used in this Operator’s
Manual 16
164.boo Seite 589 Freitag, 30. März 2007 12:54 12

592 Index
Important notes, Tire inflation
pressure 394
Inflation pressure 377, 393, 395
Information placard 388
Inspection 385
Load rating 406, 407, 417
Loading Information 388
Loading terminology 415
Loading the vehicle 387
Low tire pressure telltale, Canada
only 27, 444
Maximum load 418
Messages in the multifunction
display 444
Ply composition and material
used 418
Problems under-/overinflation 405
Retreads 384
Rims and tires 555
Rotating 387
Run Flat Indicator (Canada only) 396
Service life 385
Sizes 406
Snow chains 421
Spare wheel 494, 520
Speed rating 353, 408, 418Storing 386
Temperature 394, 414
Terminology 415
TIN 410, 417
Tire Identification Number see TIN
Tire Pressure Monitoring System
(TPMS), (USA only) 398
TPMS malfunction telltale 444
Traction 352, 414, 418
Tread 418
Tread depth 386, 420
Treadwear indicators 418
Vehicle maximum load on 418
Wear pattern 419
Winter tires 420
Tongue Weight Rating see TWR
Tools 490
Top tether
Children in the vehicle 96
Towing
Trailer 197, 364, 367
Towing eye bolt 540
Towing the vehicle 540, 542
Tow-starting 536, 538Traction 414, 418
4-ETS, Driving safety systems 101,
107
Trailer
Attaching 366
Checking weights 366
Electrical connections 365
Hitch* 364
Loading 365
Towing 364, 367
Weights and ratings 365
Transfer case 201
LOW RANGE mode* 201
Switching LOW RANGE mode* 202
Transmission gear selector lever see
Gear selector lever
Transmission position indicator 155
Transmission positions 192
Transmission see Automatic transmission
Traveling abroad 370
Tread 418
Tread depth 386, 420
Treadwear indicators 418
Trip computer 184
Trip odometer, resetting 153
164.boo Seite 592 Freitag, 30. März 2007 12:54 12