2008 HONDA FIT transmission

The emissions control systems are
designed and certif ied to work to-
gether in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Honda replacement parts or their
equivalent f or repairs. Using lower
quality parts may increase the
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The exhaust emissions controls
include f our systems: PGM-FI,
ignition timing control, exhaust gas
recirculation, and three way catalytic
converter. These f our systems work
together to control the engine’s
combustion and minimize the
amount of HC, CO, and NOx that
come out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It then controls how much f uel to inject
under all operating conditions.
This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor.
2
2
Exhaust Emissions Controls Replacement Parts
Emissions Cont rols
PGM-FI System Ignit ion T iming Cont rol Syst em
Exhaust Gas Recirculat ion (EGR)Syst em
Three Way Catalytic Converter
252
\f—\f—y\fy
(
\fy\fy
2008 Fit

If you take your vehicle f or an
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Keep the vehicle in Park
(automatic transmission) or
neutral (manual transmission).
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes).
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F. Without touching the accelerator
pedal, let the engine idle f or 20
seconds.
1.
2.
3. 4.
5.
6.
T esting of Readiness Codes
Emissions T esting
254
\f—\f—y\fy
(
\fy\fy
2008 Fit

CONT INUED
....................................
Accessories .144
ACCESSORY (Ignition Key
.......................................
Position) .78
...............
Accessory Power Socket .99
....................
Additives, Engine Oil .188
.......
Adjusting the Steering Wheel .75
...........................
Advanced Airbags .27
...............................
Airbag (SRS) .9,22
..............
Air Conditioning System .102
.........................................
Usage .103
.......................
Air Pressure, Tires .210
.......................
Alcohol in Gasoline .136
......................................
Antif reeze .190
Anti-lock Brakes (ABS)
...............................
Indicator .62,168
...................................
Operation .168
..............
Anti-thef t, Audio System .128
.
Anti-thef t Steering Column Lock .78
................................
Audio System .107
...
Automatic Seat Belt Tensioners .20
.............
Automatic Speed Control .131
..............
Automatic Transmission .157
..........................
Capacity, Fluid .244
...............
Checking Fluid Level .193 ..........................
Paddle Shif ters .162
.......................................
Shif ting .157
Shif t Lever Position
...............................
Indicators .157
................
Shif t Lever Positions .158
....................
Shif t Lock Release .161
......................
Auxiliary Input Jack .127
............................
Capacities Chart .244
.............
Carbon Monoxide Hazard .53
Battery
Charging System ...........................
Indicator .60,230
............................
Jump Starting .226
..............................
Maintenance .214
............................
Specif ications .245
..............................
Bef ore Driving .135
....................................
Belts,Seat.8,18
...........................
Beverage Holders .98
..................................
Booster Seats .50
Brakes
...........
Anti-lock System (ABS) .168
.............
Break-in, New Linings .136
....................
Bulb Replacement .201
...........................................
Fluid .195
.........................................
Parking .96 .................
System Indicator .60,232
..........................
System Design .167
........................
Wear Indicators .167
.............................
Braking System .167
.................
Break-in, New Vehicle .136
..
Brightness Control, Instruments .74
..................
Brights, Headlights .72,73
Bulb Replacement
..........................
Back-up Lights .201
..............................
Brake Lights .201
Front Parking Lights/
...
Front Side Marker Lights .198
.................................
Fog Lights .199
.................................
Headlights .196
.........
High-mount Brake Light .202
............................
Specif ications .245
....................................
Taillights .201
............
Turn Signal Lights .198,201
..............................
Bulbs, Halogen .196
Index
A
B
C
INDEX
I
\f—\f—y\f\fy
(
\fy\fy
2008 Fit

ÎÎÎ
ÎÎ
..............................................
Cargo .146
....................
Cargo, How to Carry .146
.............................
Carrying Cargo .146
.............
CAUTION, Explanation of .iii
.........................................
CD Care .124
.....................
CD Error Messages .123
.......................................
CD Player .114
.................................
Center Pocket .97
........................
Certif ication Label .242
.................................
Chains, Tires .214
....................
Changing a Flat Tire .219
.................................
Changing Oil .188
........................................
How to .188
......................................
When to .179
...
Charging System Indicator .60,230
..............
Check Fuel Cap Indicator .68
............
Checklist, Bef ore Driving .153
.....................................
Child Saf ety .34
..............................
Booster Seats .50
.............................
Child Seats .34,41
.....
Important Saf ety Reminders .34
..........................................
Inf ants .39
............................
Large Children .49
.........................................
LATCH .43
......................
Risks with Airbags .35
.............................
Small Children .40 .........................................
Tethers .47
...........................
Warning Labels .36
.........
Where Should a Child Sit? .35
.................................
Child Seats .34,41
.........................................
LATCH .43
..........
Tether Anchorage Points .47
..................
Childproof Door Locks .80
................
Cleaning the Seat Belts .203
....................
Cleaning the Wheels .208
..............................................
Clock .129
...................................
Clutch Fluid .195
........................
CO in the Exhaust .251
............
Cold Weather, Starting in .154
...............
Consumer Inf ormation .258
.............
Controls, Instruments and .57
Coolant
........................................
Adding .190
....................................
Checking .140
.........................
Proper Solution .190
...............
Temperature Indicator .63
Crankcase Emissions Control ........................................
System .251
................
Cruise Control Indicator .65
............
Cruise Control Operation .131
.....................................
Cup Holders .98
.............
Customer Service Of f ice .258 ...............
DANGER, Explanation of .iii
...................................
Dashboard .3,58
............
Daytime Running Lights .73
Daytime Running Lights
...................................
Indicator .65
.................................
Dead Battery .226
............
Def ects, Reporting Saf ety .260
................
Def ogger, Rear Window .74
..............
Def rosting the Windows .105
.........................
Detachable Anchor .93
....................................
Dimensions .244
.........
Dimming the Headlights .72,73
Dipstick
..........
Automatic Transmission .193
..................................
Engine Oil .139
..........................
Directional Signals .72
........
Disc Brake Wear Indicators .167
.......................................
Disc Care .124
.......
Disc Player Error Messages .123
.....................
Disposal of Used Oil .189
Doors
..............
Childproof Door Locks .80
..............
Locking and Unlocking .79
......................
Power Door Locks .79
Index
D
II
——yy
(
yy
2008 Fit

Î
CONT INUED
........
DOT Tire Quality Grading .246
Downshif ting, Manual
.............................
Transmission .155
...........
Driver and Passenger Safety .5
...........................................
Driving .151
....................................
Economy .141
........................
Driving Guidelines .152
Driving with the Paddle
.......................................
Shif ters .162
..................
Dust and Pollen Filter .205
..............................
Economy, Fuel .141
..................................
Emergencies .217
.............
Battery, Jump Starting .226
...........
Brake System Indicator .232
................
Changing a Flat Tire .219
.....
Charging System Indicator .230
..................
Checking the Fuses .234
.........
Hazard Warning Flashers .74
............................
Jump Starting .226
.....
Low Oil Pressure Indicator .230
...
Malf unction Indicator Lamp .231
..................
Overheated Engine .228
.......................................
Towing .238 ...........................
Emergency Brake .96
......................
Emergency Flashers .74
......................
Emergency Towing .238
.......................
Emissions Controls .251
........................
Emissions Testing .254
Engine
............
Adding Engine Coolant .190
Coolant Temperature
...................................
Indicator .63
.........................
If It Won’t Start .224
Malf unction Indicator
......................................
Lamp .231
.......................................
Oil Lif e .179
........
Oil Pressure Indicator .60,230
..............
Oil, What Kind to Use .187
...............................
Overheating .228
............................
Specif ications .244
....................
Speed Limiter .156,160
.......................................
Starting .154
......................
Ethanol in Gasoline .136
.
Evaporative Emissions Controls .251
...............................
Exhaust Fumes .53
Expectant Mothers, Use of Seat
........................................
Belts by .16 ...................................
Fan, Interior .103
.........................................
Features .101
....................
Filling the Fuel Tank .137
Filters
.........................
Dust and Pollen .205
...............................................
Oil .188
.............
Flashers, Hazard Warning .74
...................
Flat Tire, Changing a .219
Fluids
..........
Automatic Transmission .193
..........................................
Brake .195
.........................................
Clutch .195
..............
Manual Transmission .194
..................
Windshield Washer .192
.........
Folding the Rear Seat Down .91
...............
Folding the Rear Seat Up .90
..........................
Four-way Flashers .74
..............................
Front Airbags .9,25
Front Seat
......................................
Adjusting .86
.....................................
Airbags .9,25
Index
E F
INDEX
III
\f—\f—y\f\fy
(
\fy\f\fy
2008 Fit

ÎÎ
...............
Gas Mileage, Improving .141
..........................................
Gasohol .136
.........................................
Gasoline .136
.....................
Low Fuel Indicator .62
...........................................
Gauge .68
................
Octane Requirement .136
........................
Tank, Ref ueling .137
................
Gas Station Procedures .137
Gauges
...............................................
Fuel .68
Gearshif t Lever Positions ..........
Automatic Transmission .158
..............
Manual Transmission .155 ........................................
Glove Box .98
Gross Vehicle Weight Rating
.....................................
(GVWR) .148
.................................................
Fuel .136
..........
Check Fuel Cap Indicator .68
......................
Fill Door and Cap .137
.....................
Low Fuel Indicator .62
...........................................
Gauge .68
................
Octane Requirement .136
...............................
Oxygenated .136
........................
Tank, Ref ueling .137
...............................
Fuel Economy .141
.....................
Fuses, Checking the .234 .............
Halogen Headlight Bulbs .196
..............
Hazard Warning Flashers .74
Headlights
........................................
Aiming .196
.......
Daytime Running Lights .73
..................
High Beam Indicator .65
.........................
Reminder Chime .73
........
Replacing Halogen Bulbs .196
...................................
Turning on .73
..............................
Head Restraints .87
.....................
Heating and Cooling .102
............................
High Beam Lever .73
.......................
Hood, Opening the .138
..............................................
Horn.4,70
...........................
Hydraulic Clutch .195
...
Identif ication Number, Vehicle .242 Ignition
..............................................
Keys .76
...........................................
Switch .78
............
Timing Control System .252
........................
Immobilizer System .77
.........
Important Safety Precautions .6
Index
G H
I
IV
\f—\f—y\f\fy
(
\fy\f
y
2008 Fit

...
Low Oil Pressure Indicator .60,230
................................
Lower Anchors .43
...
Lubricant Specif ications Chart .244
...........
Luggage, Storing (Cargo) .146
...........
Luggage Net (Cargo Net) .150
..................................
Maintenance .177
......
Main Items and Sub Items .182
........................................
Minder .179
.........................
Minder Indicator .66
Owner’s Maintenance
...................................
Checks .184
..........................................
Saf ety .178
.......
Malf unction Indicator Lamp .231
...................
Manual Transmission .155
...............
Checking Fluid Level .194
.......................................
Shif ting .155
........
Manual Transmission Fluid .194
.........................
Meters, Gauges .59,67
...................
Methanol in Gasoline .136
..........................
Mirrors, Adjusting .95
...............
Modif ying Your Vehicle .144 ...................
Neutral Gear Position .159
..................
New Vehicle Break-in .136
.....................
Normal Shif t Speeds .156
...................
NOTICE, Explanation of .i
...............
Numbers, Identif ication .242
...
Octane Requirement, Gasoline .136
.........................................
Odometer .68
...............................
Odometer, Trip .67
Oil
........................
Change, How to .188
......................
Change, When to .179
......................
Checking Engine .139
..............
Pressure Indicator .60,230
Selecting Proper Viscosity
......................................
Chart .187
...........
ON (Ignition Key Position) .78
Onboard Ref ueling Vapor
....................................
Recovery .251
..............................
Outside Mirrors .95
....................
Overheating, Engine .228
....
Owner’s Maintenance Checks .184 .........................
Oxygenated Fuels .136
..............................
Paddle Shif ters .162
..............
Panel Brightness Control .74
........................
Park Gear Position .158
...........................................
Parking .166
.................................
Parking Brake .96
Parking Brake and Brake
.................
System Indicator .60,232
.................................
Parking Lights .72
..
Parking Over Things that Burn .166
....
Passenger Airbag Of f Indicator .31
.............................
PGM-FI System .252
...................................
Pollen Filter .205
..........................
Power Door Locks .79
..................
Power Socket Location .99
..............................
Power Windows .94
.........
Pregnancy, Using Seat Belts .16
........................
Preparing to Drive .153
.........
Protecting Adults and Teens .11
...
Additional Safety Precautions .17
.....
Advice f or Pregnant Women .16
Index
M N
P
O
VI
——yy
(
yy
2008 Fit

Î
Î
Î
Î
Î ÎÎ
ÎÎ
...............................................
Tires .208
..............................
Air Pressure .210
........................................
Chains .214
.........................
Checking Wear .210
....
DOT Tire Quality Grading .246
......................................
Inf lation .209
..................................
Inspection .210
.....................................
Labeling .248
Low Tire Pressure
.........................
Indicator .64,170
..............................
Maintenance .211
Pressure Monitoring
..................................
System .170
...................................
Replacing .212
......................................
Rotating .212
...........................................
Snow .213
............................
Specif ications .245
...................
Tools, Tire Changing .219
Towing
.....................................
A Trailer .173
................
Emergency Wrecker .238
TPMS (Tire Pressure Monitoring ................................
System) .170
.............................
Indicator .64,171
Required Federal
............................
Explanation .249 Transmission
Checking Fluid Level, ..............................
Automatic .193
Checking Fluid Level, ...................................
Manual .194
..................
Fluid Selection .193,194
..............
Identif ication Number .243
.............
Shif ting the Automatic .157
..................
Shif ting the Manual .155
.....................................
Treadwear .246
.......................................
Trip Meter .67
....................................
Turn Signals .72
Unexpected, Taking Care
..........................................
of the .217
..
Unif orm Tire Quality Grading .246
........................
Unleaded Gasoline .136
.......
Used Oil, How to Dispose of .189
.................
Vehicle Capacity Load .147
......................
Vehicle Dimensions .244
....
Vehicle Identif ication Number .242 .............................
Vehicle Storage .216
.....................................
Ventilation .104
.................................................
VIN .242
..................................
Viscosity, Oil .187
............
WARNING, Explanation of .iii
.........
Warning Labels, Location of .54
..................
Warranty Coverages .259
Washers, Windshield
........
Checking the Fluid Level .192
..............
Fluid Level Indicator .65
.....................................
Operation .71
Wheels ...............
Adjusting the Steering .75
............
Alignment and Balance .212
..........
Aluminum Alloy Wheels .208
.....................................
Cleaning .208
..............................
Wrench, Nut .221
Windows ...................................
Auto Down .94
..................
Operating the Power .94
...........................
Rear, Def ogger .74
Index
V W
UINDEX
IX
——y


y
(
yy
2008 Fit