2008 DODGE RAM 2500 DIESEL transmission

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MopartATF+4, Automatic Transmission Fluid.
Transfer Case MopartATF+4, Automatic Transmission Fluid.
Manual Transmission Fluid G-56 MopartATF+4, Automatic Transmission Fluid.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P. or equivalent.
Front and Rear Axle Fluid 2500/3500
ModelsGL-5 SAE 75W-90 Synthetic or equivalent.Limited slip additive is not re-
quired.
Brake Master Cylinder MopartDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MopartATF+4, Automatic Transmission Fluid.
482 MAINTAINING YOUR VEHICLE

take some washer fluid and apply it to a cloth or towel
and wipe clean the wiper blades, this will help blade
performance.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the batteries and clean and tighten the termi-
nals as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and transfer case (if
equipped), add as needed.
²Check all lights and all other electrical items for correct
operation.
²Drain water from the fuel filter.
²Check Filter MinderŸ (If Equipped). Replace air
cleaner filter element if necessary.At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the U-Joints (if equipped) and front suspension
components.
²Check the automatic transmission fluid level.
²Check the manual transmission fluid level.
²Check the coolant level, hoses, and clamps.
²Lubricate outer tie rod ends (4X4) models only.
²Lubricate Front Drive Shaft Fitting (4X4).
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
MAINTENANCE SCHEDULES 485
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

(Miles) (45,000) (52,500) (60,000) (67,500) (75,000)
Kilometers 72 000 84 000 97 000 109 000 121 000
[Months] [36] [42] [48] [54] [60]
Change engine oil and engine oil filter. X X X X X
Lubricate Front Drive Shaft Fitting (4X4). X X X X X
Rotate tires. X X X X X
Lubricate outer tie rod ends. X X X X X
Change the transfer case fluid (4X4). X
Change front and rear axle fluid (4X4). X X X
Change the automatic transmission fluid & filter if
using your vehicle for any of the following: police,
taxi, fleet or frequent trailer towing.X
Change manual transmission fluid. X
Flush and replace engine coolant at 60 months, if
not replaced at 100,000 miles (160 000 km).***X
Inspect drive belt, replace as necessary. X X
Replace fuel filter element. X X X
488 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

(Miles) (112,500) (120,000) (127,50) (135,000) (142,500) (150,000)
Kilometers 181 000 193 000 205 0000 217 000 229 000 241 000
[Months] [90] [96] [102] [108] [114] [120]
Change engine oil and engine oil filter. X XXXXX
Lubricate Front Drive Shaft Fitting (4X4). X XXXXX
Rotate tires. X XXXXX
Lubricate outer tie rod ends. X XXXXX
Flush and replace engine coolant at 120 months,
if not replaced at 100,000 miles (161 000 km).***X
Inspect drive belt, replace as required.* X X X
Change transfer case fluid (4X4). X
Check transfer case fluid level (4X4).X
Change front and rear axle fluid (4X4). X X X
Change the automatic transmission fluid & filter. X X
Change manual transmission fluid. X
Replace fuel filter element. X X X
Inspect front wheel bearings. X X
MAINTENANCE SCHEDULES 491
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................... 349
Adjustable Pedals....................... 138
Air Cleaner, Engine (Engine Air Cleaner
Filter).............................419,452
Air Conditioner Maintenance............... 430
Air Conditioning Refrigerant.............430,431
Air Conditioning System................252,430
Air Conditioning System, Zone Control........ 255
Air Filter.............................. 419
Air Pressure, Tires....................325,333
Airbag............................35,48,55
Airbag Light.......................58,77,190
Airbag On/Off Switch..................... 55
Alarm, Panic............................ 24
Alarm (Security Alarm).................19,192
Alarm System (Security Alarm)............... 19
Alignment and Balance................... 332
Alterations/Modifications, Vehicle............. 8
Antenna, Satellite Radio................... 245Antifreeze (Engine Coolant)..............438,439
Capacities........................... 479
Anti-Lock Warning Light...............195,314
Anti-Theft Security Alarm (Theft Alarm)........ 19
Anti-Theft System.....................19,192
Appearance Care........................ 455
Ashtray............................... 162
Assistance Towing....................... 102
Auto Unlock, Doors...................... 146
Automatic Dimming Mirror................. 85
Automatic Door Locks.................... 146
Automatic Transaxle...................... 12
Interlock System........................ 19
Automatic Transmission................... 447
Adding Fluid......................448,449
Fluid and Filter Changes................. 450
Fluid Level Check...................... 448
Fluid Type........................447,482
Shift Indicator........................ 192
506 INDEX

Fan .................................. 442
Filters
Closed Crankcase Ventilation (CCV)......... 426
Engine Oil.....................413,416,480
Flashers
Turn Signal.......................... 133
Flat Tire Stowage.....................386,396
Fluid, Brake........................... 482
Fluid Capacities......................... 479
Fluid Level Checks
Brake............................... 444
Manual Transmission.................446,447
Power Steering........................ 431
Transfer Case......................... 446
Fluids, Lubricants and Genuine Parts.......... 480
Fog Lights.......................132,193,469
Fold Flat Load Floor..................... 174
Four Wheel Drive....................... 294
Four-Way Hazard Flasher.................. 384Freeing A Stuck Vehicle................... 400
Front Axle (Differential)................432,446
Fuel..............................348,349
Adding............................. 349
Diesel.........................348,349,480
Gauge.............................. 199
Light............................... 199
Requirements......................... 348
Specifications......................... 349
Tank Capacity........................ 479
Fuses................................ 459
Garage Door Opener (HomeLinkt) ........... 151
Gauges............................... 189
Coolant Temperature.................... 191
Fuel................................ 199
Oil Pressure.......................... 191
Speedometer......................... 190
Tachometer.......................... 190
INDEX 511
10

Bulb Replacement...................465,466
Cap Top Clearance..................... 474
Cargo .............................. 133
Center Mounted Stop................... 473
Check Engine (Malfunction Indicator)........ 194
Cruise.............................. 199
Daytime Running...................... 132
Dome.............................. 142
Dual Wheel Assembly Rear............... 476
Fog ..........................132,193,469
Four-Wheel Drive Indicator............... 298
Hazard Warning Flasher................. 384
Headlights........................... 131
High Beam........................134,190
High Beam Indicator.................... 190
High Beam/Low Beam Select............. 134
Illuminated Entry....................... 20
Instrument Cluster..................... 189
Intensity Control....................... 130Interior............................. 129
Lights On Reminder.................... 132
Passing............................. 134
Reading............................. 142
Seat Belt Reminder..................... 190
Service...........................465,466
Side Marker.......................... 478
Tire Pressure Monitoring (TPMS)........... 196
Transfer Case......................... 298
Transmission Warning................... 198
Turn Signal..................133,190,466,470
Warning (Instrument Cluster Description)..... 189
Limited-Slip Differential................306,446
Loading Vehicle......................... 352
Tires ............................... 320
Locks................................. 26
Child Protection........................ 30
Door................................ 26
Keys................................ 12
514 INDEX

Power Door........................... 27
Steering Wheel......................... 18
Lower Anchors and Tether for CHildren
(LATCH).............................. 65
Lubrication, Body....................... 433
Lug Nuts............................. 392
Lumbar Support........................ 119
Maintenance........................... 410
Maintenance Procedures................... 412
Maintenance Schedule.................... 484
Manual, Service......................... 501
Manual Transmission..................291,447
Fluid Level Check...................446,447
Lubricant Selection..................... 482
Shift Speeds.......................... 292
Map/Reading Lights..................... 142
Mirrors................................ 84
Automatic Dimming..................... 85Electric Powered....................... 86
Outside.............................. 85
Rearview............................. 84
Trailer Towing......................87,370
Modifications/Alterations, Vehicle............. 8
Monitor, Tire Pressure System............... 338
Mopar Parts.........................409,500
Multi-Function Control Lever............... 133
Navigation Radio........................ 238
Navigation System....................... 238
New Vehicle Break-In Period................ 74
Noise Control
Maintenance.......................... 452
Tampering Prohibited................... 452
Noise Emission Warranty...............451,453
Occupant Restraints....................... 35
Odometer..........................192,199
INDEX 515
10