2008 CHRYSLER PT CRUISER service schedule

SCHEDULE ªBºÐALL ENGINES
Follow schedule ªBºÐAll Engines if you usually operate
your vehicle under one or more of the following condi-
tions.
Change the automatic transmission fluid and filter every
60,000 miles (100 000 km) if the vehicle is usually
operated under one or more of the conditions marked
with anL.
Change the manual transaxle fluid every 48,000 miles (80
000 km) if the vehicle is usually operated under one or
more of the conditions marked with an ².
²Day and night temperatures are below 32É F (0É C).
²Stop and go driving.
²Extensive engine idling.
²Driving in dusty conditions.
²Short trips of less than 10 miles (16.2 km).
²More than 50% of your driving is at sustained high
speeds during hot weather, above 90É F (32É C).
²Trailer towing.²L
²Taxi, police, or delivery service (commercial ser-
vice).²L
²Off-road or desert operation.
²If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow schedule ªBÐAll
Enginesº of the9Maintenance Schedules9section of this
manual.
SCHEDULE ªBºÐALL ENGINES 437
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 138,000 141,000 144,000 147,000 150,000
(Kilometers) (230 000) (235 000) (240 000) (245 000) (250 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Rotate tires. X X X
Inspect the brake linings. X
Replace theengine air cleaner filter.*X
Replace the spark plugs.X
Change the manual transaxle fluid.² X
Replace theMake-up air filter.X
Inspect thePCV valve and replace if necessary.*³ X
* This maintenance is recommended by the manufacturer
to the owner, but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
² This maintenance is required only for police, taxi,
limousine type operation, or trailer towing.LThis maintenance is required only for police, taxi,
limousine type operation, or trailer towing.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE ªBºÐALL ENGINES 447
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles144,000 150,000
(Kilometers)(240 000) (250 000)
[Months][144] [150]
Change engine oil and engine oil filter. X X
Rotate tires.XX
Inspect thePCV valveand replace if necessary. * ³ X
Replace theair cleaner filter.X
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
452 SCHEDULE ªAºÐNON TURBO
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 110,000 115,000 120,000
(Kilometers) (177 000) (185 000) (193 000)
[Month] [132] [138] [144]
Change engine oil and engine oil filter. X X X
Rotate tires. X X X
Inspect thePCV Valveand replace if necessary. * X
Replace theengine air cleaner filter.X
Replace thespark plugs and ignition cables.X
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
³ This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent
mechanic.
SCHEDULE ªAºÐTURBO 457
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Theft Alarm (Security Alarm).............. 233
Tire Pressure Monitoring (TPMS)........... 332
Traction Control....................... 312
Turn Signal..................186,189,230,426
Voltage............................. 230
Warning (Instrument Cluster Description)..... 226
Loading Vehicle......................... 342
Tires ............................... 317
Locks
Child Protection........................ 22
Door................................ 19
Power Door........................... 20
Steering Wheel......................... 18
Low Tire Pressure System.................. 332
Lubrication, Body....................... 395
Luggage Rack (Roof Rack)................. 215
Lumbar Support........................ 166
Maintenance Free Battery.................. 392Maintenance, General..................... 384
Maintenance Procedures................... 384
Maintenance Schedule
Schedule ªAº-Non Turbo................. 448
Schedule ªAº-Turbo.................... 453
Schedule ªBº......................... 437
Schedule ªBº-All Engines................ 437
Maintenance Schedules.................... 434
Malfunction Indicator Light (Check Engine) . . 229,381
Manual Override, Convertible Top.........134,373
Manual, Service......................... 465
Manual Transaxle..................292,301,410
Downshifting......................... 304
Fluid Level Check...................... 410
Frequency of Fluid Change............... 410
Lubricant Selection..................... 410
Map/Reading Lights..................184,185
Master Cylinder (Brakes).................. 406
Methanol............................. 337
INDEX 479
10

INTRODUCTION INTRODUCTION HOW TO USE THIS MANUAL WARNINGS AND CAUTIONS VEHICLE IDENTIFICATION NUMBER VEHICLE MODIFICATIONS/ALTERATIONS THINGS TO KNOW BEFORE STARTING YOUR VEHICLE A WORD ABOUT YOUR KEYS
IGNITION KEY REMOVALLOCKING DOORS WITH A KEYKEY-IN-IGNITION REMINDERSENTRY KEY - IF EQUIPPED Replacement KeysSentry Key ProgrammingGeneral InformationSTEERING WHEEL LOCK - IF EQUIPPED If You Wish To Manually Lock The Steering
WheelTo Release The Steering Wheel LockAutomatic Transaxle Ignition Interlock SystemDOOR LOCKS MANUAL DOOR LOCKSPOWER DOOR LOCKS - IF EQUIPPEDCHILD PROTECTION DOOR LOCK SYSTEM - IF EQUIPPEDREMOTE KEYLESS ENTRY (SEDAN)
TO UNLOCK THE DOORS AND LIFTGATETO LOCK THE DOORS AND LIFTGATE - IF EQUIPPED WITH POWER OPTIONSPANIC ALARMTO TURN OFF FLASH LIGHTS WITH LOCKTO PROGRAM ADDITIONAL TRANSMITTERSGENERAL INFORMATION
TRANSMITTER BATTERY SERVICEREMOTE KEYLESS ENTRY (CONVERTIBLE) TO UNLOCK THE DOORSTO LOCK THE DOORSTO UNLATCH THE DECK LIDPANIC ALARMTO TURN OFF FLASH LIGHTS WITH LOCKTO PROGRAM ADDITIONAL TRANSMITTERS
GENERAL INFORMATIONTRANSMITTER BATTERY SERVICESECURITY ALARM SYSTEM - IF EQUIPPED To set the alarmTo disarm the systemSecurity System Manual OverrideLIFTGATE (SEDAN) Opening The Liftgate While the Security Alarm Is ActivatedDECK LID
(CONVERTIBLE) POWER DECK LID RELEASE (Convertible)EMERGENCY SEAT BACK RELEASE (SEDAN) EMERGENCY DECK LID RELEASE LATCH (CONVERTIBLE) POWER WINDOWS AUTO DOWN FEATUREREAR WINDOW SWITCHESWIND BUFFETING
OCCUPANT RESTRAINTS (SEDAN) LAP/SHOULDER BELTSLAP/SHOULDER SEAT BELT UNTWISTING PROCEDUREADJUSTABLE UPPER SHOULDER SEAT BELT ANCHORAGESEAT BELT PRETENSIONERSENHANCED SEAT BELT REMINDER SYSTEM
(BELTALERT) SEAT BELTS AND PREGNANT WOMENDRIVER AND FRONT PASSENGER SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIRBAGCHILD RESTRAINTOCCUPANT RESTRAINTS (CONVERTIBLE) LAP/SHOULDER BELTSLAP/SHOULDER SEAT BELT
UNTWISTING PROCEDURESEAT BELT PRETENSIONERSENHANCED SEAT BELT REMINDER SYSTEM (BELTALERT) SEAT BELTS AND PREGNANT WOMENDRIVER AND FRONT PASSENGER SUPPLEMENTAL RESTRAINT SYSTEM (SRS)CHILD RESTRAINT
ENGINE BREAK-IN RECOMMENDATIONS SAFETY TIPS Exhaust GasSafety Checks You Should Make Inside The VehiclePeriodic Safety Checks You Should Make Outside The VehicleUNDERSTANDING THE FEATURES OF YOUR VEHICLE CONVERTIBLE TOP
OPERATION To Lower The TopTo Raise The TopConvertible Top Boot Cover Installation-If EquippedConvertible Top Boot Cover Removal and StorageCONVERTIBLE TOP MANUAL OVERRIDEMIRRORS Inside Day/Night Mirror - If EquippedOutside Mirror-Drivers Side
Outside Mirror-Passengers SideElectric Remote-Control Mirrors - If EquippedIlluminated Vanity Mirrors - If EquippedSun Visor Sliding FeatureHANDS-FREE COMMUNICATION (UConnect) - IF EQUIPPED OperationsPhone Call FeaturesUConnect System Features
Advanced Phone ConnectivityThings You Should Know About Your UConnect SystemGeneral InformationSEATS FRONT SEAT ADJUSTMENTPOWER SEAT ADJUSTER -IF EQUIPPEDMANUAL LUMBAR - IF EQUIPPEDFOLDING FRONT PASSENGER SEAT - IF
EQUIPPEDDRIVERS SEAT BACK TILT - IF EQUIPPEDPASSENGER SEAT BACK TILT (EASY ENTRY SYSTEM) - CONVERTIBLEADJUSTABLE HEAD RESTRAINTSHEATED SEATS - IF EQUIPPEDFOLDING REAR SEAT (SEDAN)FOLDING REAR SEAT
(CONVERTIBLE)TUMBLING REAR SEAT (SEDAN)TUMBLING REAR SEAT (CONVERTIBLE)REAR SEAT REMOVAL (SEDAN)TO OPEN AND CLOSE THE HOOD LIGHTS Map/Reading Lights (Sedan)Map/Reading Lights (Convertible)Multi-Function Control Lever
Headlights, Parking Lights, Instrument Panel LightsDaytime Running Lights (DRL) - If EquippedLights-on ReminderFog Lights - If Equipped Turn Signals Highbeam/Lowbeam Select Switch Passing LightWINDSHIELD WIPERS AND WASHERS Windshield WashersMist
Feature Windshield Wiper OperationIntermittent Wiper SystemTILT STEERING COLUMN ELECTRONIC SPEED CONTROL - IF EQUIPPED To ActivateTo Set At A Desired SpeedTo DeactivateTo Resume SpeedTo Vary The Speed SettingManual TransaxleTo Accelerate
For PassingGARAGE DOOR OPENER - IF EQUIPPED PROGRAMMING HOMELINKGATE OPERATOR/CANADIAN PROGRAMMINGUSING HOMELINKREPROGRAMMING A SINGLE HOMELINK BUTTONSECURITYTROUBLESHOOTING TIPSGENERAL
INFORMATIONPOWER SUNROOF (SEDAN ONLY) - IF EQUIPPED Express Open FeatureWind BuffetingSunroof MaintenanceELECTRICAL POWER OUTLETS Electrical Outlet Use With Engine OffCONSOLE FEATURES STORAGE Center Console/Armrest Storage
Bin Storage PocketsREAR SHELF PANEL- IF EQUIPPED Position 1 (Top)Position 2 (Middle)Position 3 (Floor)Position 4 (Vertical)Position 5 (table)ROOF LUGGAGE RACK - IF EQUIPPED REAR WINDOW FEATURES Electric Rear Window Defroster Rear Wiper/Washer
Switch (Sedan Models Only) - If EquippedAdding Washer FluidUNDERSTANDING YOUR INSTRUMENT PANEL INSTRUMENT PANEL FEATURES INSTRUMENT CLUSTER-BASE INSTRUMENT CLUSTER-PREMIUM INSTRUMENT CLUSTER-TURBO INSTRUMENT
CLUSTER DESCRIPTIONS COMPASS MINI TRIP COMPUTER (CMTC) - IF EQUIPPED Compass Mini Trip Computer Reset ButtonCompass/Temperature DisplayOdometerDisplayTrip Odometer (ODO)ELECTRONIC VEHICLE INFORMATION CENTER (EVIC) - If
Equipped EVIC Functions Compass/Temperature/AudioAverage Fuel EconomyDistance To Empty (DTE)Elapsed TimeTire Pressure Monitor (TPM)PersonalSettings (Customer Programmable Features)SETTING THE ANALOG CLOCK RADIO GENERAL INFORMATION
Radio Broadcast SignalsTwo Types of SignalsElectrical DisturbancesAM ReceptionFM ReceptionSALES CODE REF - AM/FM/CD (SINGLE DISC) RADIO WITH OPTIONAL SATELLITE RADIO AND HANDS FREE PHONE CAPABILITY Operating Instructions - Radio Mode
Operating Instructions - CD ModeOperating Instructions - Auxiliary ModeOperating Instructions - Hands-Free Phone - If EquippedOperating Instructions - Satellite Radio - If EquippedSALES CODE RAQ - AM/FM/CD (6-DISC) RADIO WITH OPTIONAL SATELLITE RADIO,
HANDS-FREE PHONE, AND VIDEO ENTERTAINMENT SYSTEMS (VES) CAPABILITIES Operating Instructions - Radio ModeOperating Instructions - (CD Mode for CD Audio Play)LOAD/EJECT Button (CD Mode for CD Audio Play)Notes On Playing MP3 FilesOperating
Instructions - (CD Mode for MP3 Audio Play)LOAD/EJECT Button (CD Mode for MP3 Play)SATELLITE RADIO - IF EQUIPPED System ActivationElectronic SerialNumber/Sirius Identification Number (ESN/SID)Selecting Satellite Mode in REF, and RAQ, RadiosSelecting
a ChannelStoring and Selecting Pre-Set ChannelsUsing the PTY (Program Type) Button (if equipped)PTY Button SCANPTY Button SEEKSatellite AntennaReception QualityCD/DVD DISC MAINTENANCE RADIO OPERATION AND CELLULAR PHONES CLIMATE
CONTROLS Climate ControlsOperating Tips STARTING AND OPERATING STARTING PROCEDURES AUTOMATIC TRANSAXLEMANUAL TRANSAXLENORMAL STARTINGEXTREMELY COLD WEATHER (BELOW -20 degrees F or -29 degrees C)IF THE ENGINE FAILS
TO STARTAFTER STARTINGTURBOCHARGER COOL-DOWN AUTOMATIC TRANSAXLE - IF EQUIPPED BRAKE/TRANSMISSION INTERLOCK SYSTEMAUTOMATIC TRANSAXLE IGNITION INTERLOCK SYSTEMFOUR-SPEED AUTOMATIC TRANSAXLERESET
MODEGEAR RANGES FOR THE FOUR-SPEED AUTOMATIC TRANSAXLEAUTOSTICK - IF EQUIPPED AUTOSTICK OperationAUTOSTICK General InformationMANUAL TRANSAXLE OPERATION - IF EQUIPPED 2.4 LITER TURBO - IF EQUIPPED MANUAL
TRANSAXLE - RECOMMENDED SHIFT SPEEDSDownshiftingPARKING BRAKE BRAKE SYSTEM ANTI-LOCK BRAKE SYSTEM (ABS) - IF EQUIPPEDPOWER STEERING TRACTION CONTROL SYSTEM - IF EQUIPPED TIRE SAFETY INFORMATION Tire Markings
Tire Identification Number (TIN)Tire Loading and Tire PressureTIRES - GENERAL INFORMATION Tire PressureTire Inflation PressuresRadial Ply TiresCompact Spare Tire - If EquippedLimited-Use Spare - If EquippedTire SpinningTread Wear IndicatorsLife of Tire
Replacement TiresAlignment and BalanceTIRE CHAINS SNOW TIRES TIRE ROTATION RECOMMENDATIONS TIRE PRESSURE MONITOR SYSTEM (TPMS) - IF EQUIPPED BASESYSTEM - IF EQUIPPEDGENERAL INFORMATIONFUEL REQUIREMENTS -
GASOLINE ENGINES 2.4L AND 2.4L STANDARD TURBO ENGINESREFORMULATED GASOLINEGASOLINE/OXYGENATE BLENDSMMT IN GASOLINEMATERIALS ADDED TO FUELFUELSYSTEM CAUTIONSCARBON MONOXIDE WARNINGSADDING FUEL Fuel
Filler Cap (Gas Cap)Loose Fuel Filler Cap MessageVEHICLE LOADING TRAILER TOWING COMMON TOWING DEFINITIONSTRAILER HITCH CLASSIFICATIONTRAILER TOWING WEIGHTS (MAXIMUM TRAILER WEIGHT RATINGS)TRAILER AND TONGUE WEIGHT
TOWING REQUIREMENTSTOWING TIPSRECREATIONAL TOWING (BEHIND MOTORHOME, ETC.) Towing This Vehicle Behind Another Vehicle (Flat towing with all fourwheels on the ground)WHAT TO DO IN EMERGENCIES HAZARD WARNING FLASHER IF YOUR
ENGINE OVERHEATS JACKING AND TIRE CHANGING JACK LOCATIONSPARE TIRE STOWAGEPREPARATIONS FOR JACKINGJACKING INSTRUCTIONS JUMP-STARTING PROCEDURES DUE TO A LOW BATTERY DRIVING ON SLIPPERY SURFACES ACCELERATIONTRACTIONFREEING A STUCK VEHICLE TOWING A DISABLED VEHICLE With Ignition KeyWithout The Ignition KeyCONVERTIBLE TOP MANUAL OVERRIDE MAINTAINING YOUR VEHICLE 2.4L TURBO ENGINE COMPARTMENT 2.4L ENGINE
COMPARTMENT ONBOARD DIAGNOSTIC SYSTEM - OBD II Loose Fuel Filler Cap MessageEMISSIONS INSPECTION AND MAINTENANCE PROGRAMS REPLACEMENT PARTS AUTHORIZED DEALER SERVICE MAINTENANCE PROCEDURES ENGINE OILDRIVE
BELTS - CHECK CONDITION AND TENSIONSPARK PLUGSIGNITION WIRING SYSTEMCATALYTIC CONVERTERENGINE TIMING BELTCRANKCASE EMISSION CONTROL SYSTEMFUEL FILTERAIR CLEANER ELEMENT (AIR FILTER)MAINTENANCE-FREE
BATTERYAIR CONDITIONER MAINTENANCEPOWER STEERING - FLUID CHECKFRONT SUSPENSION BALL JOINTSSTEERING LINKAGEBODY LUBRICATIONWINDSHIELD WIPER BLADESWINDSHIELD WASHER RESERVOIREXHAUST SYSTEMCOOLING
SYSTEMHOSES AND VACUUM/VAPOR HARNESSESFUEL SYSTEM CONNECTIONSBRAKE SYSTEMAUTOMATIC TRANSAXLEMANUAL TRANSAXLEAPPEARANCE CARE AND PROTECTIONFROM CORROSIONCONVERTIBLE TOP CARE WashingGeneral
CleaningCloth Top Additional Cleaning ProcedureCloth Top ProtectionWeather Strip CareINTEGRATED POWER MODULE (IPM) VEHICLE STORAGE REPLACEMENT BULBS BULB REPLACEMENT HeadlightsFront Park/Turn Signal/Side Marker LightsFront Fog Lights
- If EquippedTail/Stop, and Rear Turn Signal LightsBack Up Lights Center High Mounted Stop LightFLUIDS AND CAPACITIES FLUIDS, LUBRICANTS AND GENUINE PARTS ENGINECHASSISMAINTENANCE SCHEDULES EMISSIONS CONTROL SYSTEM
MAINTENANCE MAINTENANCE SCHEDULE SCHEDULE B-ALL ENGINESSCHEDULE A-NON TURBOSCHEDULE A-TURBOIF YOU NEED CONSUMER ASSISTANCE SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE Prepare For The Appointment
Prepare A ListBe Reasonable With RequestsIF YOU NEED ASSISTANCE DaimlerChrysler Motors Corporation Customer CenterDaimlerChrysler Canada Inc. Customer CenterIn Mexico contactCustomer Assistance For The Hearing Or Speech Impaired (TDD/TTY)Service
ContractWARRANTY INFORMATION (U.S. Vehicles Only) MOPAR PARTS REPORTING SAFETY DEFECTS In The 50 United States And Washington, D.CIn CanadaPUBLICATION ORDER FORMS DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY
GRADES TreadwearTraction GradesTemperature GradesINDEX